2002 FORD THUNDERBIRD power steering

If the vehicle's powertrain system or its battery has just been serviced,
the on-board diagnostics system is reset to a ªnot ready for I/M testº
condition. To ready the on-board diagnostics system for I/M testing, a
minimum of 30 minutes of city and highway driving is necessary as
described below:
²First, at least 10 minutes of driving on an expressway or highway.
²Next, at least 20 minutes driving in stop-and-go, city-type traffic with
at least four idle periods.
Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete.
POWER STEERING FLUID
Refer to the scheduled maintenance guide for the service interval
schedules. If adding fluid is necessary, use only MERCONtAT F.
1. Start the engine and let it run
until it reaches normal operating
temperature (the engine coolant
temperature gauge indicator will be
near the center of the normal area
between H and C).
2. While the engine idles, turn the
steering wheel left and right several
times.
3. Turn the engine off.
4. Check the fluid level in the
reservoir. It should be between the
MIN and MAX lines. Do not add
fluid if the level is in this range.
5. If the fluid is low, add fluid in
small amounts, continuously
checking the level until it reaches
the range between the MIN and
MAX lines. Be sure to put the cap
back on the reservoir.
MAX
MIN
MAX
MIN
Maintenance and specifications
219

REFILL CAPACITIES
Fluid Ford Part
NameApplication Capacity
Brake fluid High
Performance
DOT 3 Motor
Vehicle Brake
Fluid
1
All Fill to MAX line
on reservoir
Engine oil
(includes filter
change)Motorcraft SAE
5W-20 Super
Premium Motor
Oil3.9L-4V V8
engine5.7L (6.0
quarts)
Engine coolant
2Motorcraft
Premium Engine
Coolant
(green-colored)
orMotorcraft
Premium Gold
Engine Coolant
(yellow-colored)3.9L-4V V8
engine11.3L (11.9
quarts)
Power steering
fluidMotorcraft
MERCONtAT FAll Fill to MAX line
on reservoir
Engine cooling
fan fluidMotorcraft
MERCONtAT FAll Fill to MAX line
on reservoir
Rear axle
3Motorcraft SAE
75W-140 High
Performance
Synthetic Rear
Axle LubricantAll 1.4L (2.9-3.0
pints)
Fuel tank N/A All 68.2L (18.0
gallons)
Transmission
fluid
4Motorcraft
MERCONtV
AT FAutomatic
(5R55N)11.2L (11.9
quarts)5
Maintenance and specifications
228

Item Ford part
nameFord part
numberFord
specification
Door latch, hood
latch, auxiliary
hood latch, door
hinges, striker
plates, seat
tracks and fuel
filler door hingeMulti-Purpose
GreaseD0AZ-19584-AA
or
F5AZ-19G209-AAESB-M1C93-B or
ESR-M1C159-A
Engine coolant Motorcraft
Premium Engine
Coolant
(green-colored)VC-4±A (US) or
CXC-10 (CanadaESE-M97B44±A
Motorcraft
Premium Gold
Engine Coolant
(yellow-colored)VC-7-A WSS-M97B51-A1
Engine oil Motorcraft SAE
5W-20 Super
Premium Motor
OilXO-5W20-QSP WSS-M2C153-H
with API
Certification
Mark
Lock cylinders Motorcraft
Penetrating and
Lock LubricantMotorcraft XL-1 none
Power steering
and engine
cooling fan fluidMotorcraft
MERCONtAT FXT-2-QDX MERCONt
Rear Axle
LubricantMotorcraft SAE
75W-140 High
Performance
Synthetic Rear
Axle Lubricant
2
F1TZ-19580-B
or
XY-75W14O-QLWSL-M2C192-A
Automatic
transmission
fluidMotorcraft
MERCONtV
AT F
3
XT-5-QM MERCONtV
Maintenance and specifications
230

instrument cluster lens ..........191
instrument panel ....................191
interior .....................................191
plastic parts ....................189±190
safety belts ..............................192
washing ....................................187
waxing .....................................187
wheels ......................................188
windows ..................................192
wiper blades ............................190
Clock ............................................33
Console ........................................83
Controls
power seat .................................97
steering column ........................70
Convertible ..................................72
cleaning .....................................76
installation of the boot .............73
lowering the convertible top ...72
raising the convertible top ......74
Coolant
checking and adding ..............202
coolant temperature light ........13
refill capacities ................206, 228
specifications ..................229, 231
Cruise control (see Speed
control) ........................................66
Customer Assistance ................153
Ford accessories for your
vehicle .....................................193
Ford Extended Service
Plan ..........................................179
Getting assistance outside
the U.S. and Canada ..............183
Getting roadside assistance ...153
Getting the service
you need .................................177
Ordering additional owner's
literature .................................184The Dispute Settlement
Board .......................................180
Utilizing the
Mediation/Arbitration
Program ...................................183
D
Daytime running lamps
(see Lamps) ................................49
Defrost
rear window ..............................48
Dipstick
automatic
transmission fluid ...................221
engine oil .................................197
Doors
door ajar warning .....................15
lubricant specifications ..........229
Driving under special
conditions
through water .........................146
Dual automatic temperature
control (DATC) ...........................35
E
Emergencies, roadside
jump-starting ..........................169
Emission control system ..........217
Engine ........................................231
check engine/service engine
soon light ..................................10
cleaning ...................................188
coolant .....................................202
fail-safe coolant ......................207
idle speed control ...................200
lubrication
specifications ..................229, 231
Index
238

Lumbar support, seats ...............96
M
Manual transmission
fluid capacities ........................228
lubricant specifications ..........231
Master lighting switch ................49
Mirrors
side view mirrors (power) .......65
Motorcraft parts ................214, 227
O
Octane rating ............................212
Odometer .....................................17
Oil (see Engine oil) ..................197
P
Panic alarm feature, remote
entry system ................................88
Parking brake ............................138
Parts (see Motorcraft parts) ....227
Power distribution box
(see Fuses) .......................159, 162
Power door locks ..................84, 90
Power steering ..........................140
fluid, checking and adding ....219
fluid, refill capacity ................228
fluid, specifications .........229, 231
R
Rear window defroster ...............48
Relays ........................................156
Remote entry system ...........86, 88illuminated entry ......................89
locking/unlocking doors .....84, 87
opening the trunk .....................87
panic alarm ...............................88
replacement/additional
transmitters ...............................89
replacing the batteries .............88
S
Safety belts (see Safety
restraints) ......................15, 99±103
Safety defects, reporting ..........186
Safety restraints ..................99±103
belt minder .............................104
cleaning the safety
belts .................................108, 192
extension assembly ................108
for adults .........................100±103
for children .............................122
warning light and
chime ...........................13, 15, 104
Safety seats for children ..........123
Seat belts
(see Safety restraints) ...............99
Seats ............................................95
child safety seats ....................123
cleaning ...................................191
SecuriLock passive anti-theft
system ....................................91, 93
Servicing your vehicle ..............195
Spark plugs,
specifications .....................227, 231
Specification chart,
lubricants ...........................229, 231
Speed control ..............................66
Speedometer ...............................17
Index
241

Starting your vehicle ........132±134
jump starting ..........................169
Steering
speed sensitive .......................140
Steering wheel
controls ......................................70
tilting .........................................62
T
Tachometer .................................18
Tires ...........................164, 223±225
changing ..........................164±165
checking the pressure ............225
replacing ..................................226
rotating ....................................225
snow tires and chains ............227
tire grades ...............................224
treadwear ................................224
Towing .......................................148
recreational towing .................152
trailer towing ..........................148
wrecker ....................................176
Traction control ........................138
active light ................................14
Transmission .......................12, 140
fluid, checking and adding
(automatic) .............................221
fluid, refill capacities ..............228
lubricant specifications ..229, 231manual operation ......................12
Trip odometer .............................18
Trunk ...........................................84
remote release ....................65, 87
Turn signal ......................14, 16, 52
V
Vehicle dimensions ...................231
Vehicle Identification Number
(VIN) ..........................................233
Vehicle loading ..........................146
Ventilating your vehicle ...........136
W
Warning chimes .....................15±16
Warning lights (see Lights) .......10
Water, Driving through .............146
Windows
power .........................................63
Windshield washer fluid and
wipers
checking and cleaning ........60±61
operation ...................................60
replacing wiper blades .............61
Wrecker towing .........................176
Index
242