2002 FORD THUNDERBIRD fuel pump

Fuel quality
If you are experiencing starting, rough idle or hesitation driveability
problems during a cold start, try a different brand of ªPremiumº
unleaded gasoline. If the problems persist, see your dealer or a qualified
service technician.
It should not be necessary to add any aftermarket products to your fuel
tank if you continue to use high quality fuel of the recommended octane
rating. Aftermarket products could cause damage to the fuel system.
Repairs to correct the effects of using an aftermarket product in your
fuel may not be covered by your warranty.
Many of the world's automakers
issued the World-wide Fuel Charter
that recommends gasoline
specifications to provide improved
performance and emission control
system protection for your vehicle.
Gasolines that meet the World-wide
Fuel Charter should be used when
available. Ask your fuel supplier
about gasolines that meet the
World-wide Fuel Charter. In Canada,
look for fuels that display theAuto Makers' Choiceylogo.
Cleaner air
Ford endorses the use of reformulated ªcleaner-burningº gasolines to
improve air quality.
Running out of fuel
Avoid running out of fuel because this situation may have an adverse
affect on powertrain components.
If you have run out of fuel:
²You may need to cycle the ignition from OFF to ON several times after
refueling, to allow the fuel system to pump the fuel from the tank to
the engine.
²Your ªCheck Engineº indicator may come on. For more information on
the ªCheck Engineº indicator, refer to theInstrument Cluster
chapter.
Maintenance and specifications
213

²Allow no more than 2 automatic click-offs when filling.
²Always use fuel with the recommended octane rating.
²Use a known quality gasoline, preferably a national brand.
²Use the same side of the same pump and have the vehicle facing the
same direction each time you fill up.
²Have the vehicle loading and distribution the same every time.
Your results will be most accurate if your filling method is consistent.
Calculating fuel economy
1. Fill the fuel tank completely and record the initial odometer reading
(in kilometers or miles).
2. Each time you fill the tank, record the amount of fuel added (in liters
or gallons).
3. After at least three to five tank fill-ups, fill the fuel tank and record
the current odometer reading.
4. Subtract your initial odometer reading from the current odometer
reading.
5. Follow one of the simple calculations in order to determine fuel
economy:
Multiply liters used by 100, then divide by total kilometers
traveled.
Divide total miles traveled by total gallons used.
Keep a record for at least one month and record the type of driving (city
or highway). This will provide an accurate estimate of the vehicle's fuel
economy under current driving conditions. Additionally, keeping records
during summer and winter will show how temperature impacts fuel
economy. In general, lower temperatures give lower fuel economy.
Driving style Ð good driving and fuel economy habits
Give consideration to the lists that follow and you may be able to change
a number of variables and improve your fuel economy.
Habits
²Smooth, moderate operation can yield up to 10% savings in fuel.
²Steady speeds without stopping will usually give the best fuel
economy.
Maintenance and specifications
215

refill capacities ........................228
service points ..........................196
starting after a collision .........154
Engine block heater .................135
Engine fan .................................208
Engine oil ..................................197
checking and adding ..............197
dipstick ....................................197
filter, specifications ........199, 227
recommendations ...................199
refill capacities ........................228
specifications ..................229, 231
Exhaust fumes ..........................135
F
Fail safe cooling ........................207
Floor mats ...................................83
Fluid capacities .........................228
Fuel ............................................209
calculating fuel economy .......214
cap .....................................11, 211
capacity ...................................228
choosing the right fuel ...........212
comparisons with EPA fuel
economy estimates .................217
detergent in fuel .....................213
filling your vehicle
with fuel ..................209, 211, 214
filter, specifications ........214, 227
fuel pump shut-off switch .....154
gauge .........................................17
improving fuel economy ........214
low fuel warning light ..............14
octane rating ...................212, 231
quality ......................................213
running out of fuel .................213
safety information relating to
automotive fuels .....................209Fuses ..................................156±157
G
Gas cap (see Fuel cap) ......11, 211
Gas mileage (see Fuel
economy) ...................................214
Gauges .........................................16
engine coolant temperature
gauge .........................................16
fuel gauge ..................................17
odometer ...................................17
speedometer .............................17
tachometer ................................18
trip odometer ............................18
GAWR (Gross Axle Weight
Rating) .......................................146
definition .................................146
driving with a heavy load ......146
location ....................................146
GVWR (Gross Vehicle Weight
Rating) .......................................146
calculating ...............................146
definition .................................146
driving with a heavy load ......146
location ....................................146
H
Hazard flashers .........................154
Head restraints ...........................95
Headlamps ...................................49
aiming ........................................51
autolamp system .......................49
bulb specifications ....................53
daytime running lights .............49
flash to pass ..............................50
high beam .................................15
replacing bulbs .........................54
Index
239