2002 BMW MOTORRAD R 1150 GS Adventure oil level

11
4
General information and controls
391256784
1011
R 1150 GS1Suspension strut,
adjustment, front (
b50)
2 Oil level sight glass,
engine (
b31)
3 Engine oil filler (
b31)
4 Reservoir for clutch fluid
(
b45)
5 Power socket, 12 VOA
Provision for connecting
additional equipment – max.
load 5 A
OAOptional accessories
6Suspension strut,
adjustment, rear (
b51)
7 Lifting handle
8 Suspension strut, adjusting
shock absorber (
b52)
9 Dualseat lock (
b 16-18)
10 Primary spark plug, left
11 Secondary spark plug, left
( ) Figure in bracketsbpage number for
description
General view, left side
10ge01g6.fm Seite 4 Montag, 7. Juni 2004 10:11 10

2
29
Safety check
Checklist
For this reason, check the
details in the following sections
before you start the journey:
– Fuel level
– Positions of the handlebar-lever fittings
–Brakes
– Brake fluid level
– Clutch fluid level
– Warning lights and telltale lights
–Lights
– Shock absorber settings and spring preload
– Wheel rim and tyre condition,
tread depth and tyre
pressures
– Load, gross weight – Check regularly (every time
you stop for fuel),
on the basis of the following
section:
– Engine oil level
(every second/third stop for
fuel):
– brake pads
If you encounter any problems
or difficulties, it is always best to
contact your authorised BMW
motorcycle dealer. He will pro-
vide the necessary advice and
assistance.
10geBKg6.book Seite 29 Dienstag, 19. November 2002 1:11 13

2
30
Safety check
Engine oil
Checking oil levelCheck the oil level at regular
intervals.
Always check the oil level when
the engine is at operating tem-
perature, because the differ-
ence between the oil level
indicated when the engine is at
operating temperature and the
oil level indicated when the
engine is very cold due to
extremely low outdoor temper-
atures (-10 °C/14 °F) can be as
much as 10 mm (0.393 in).
After switching off the engine at
operating temperature, wait at
least 5 minutes for the oil to
drain back into the sump.Checking the oil level after the
engine has been run only briefly
or when it is not properly warm
will falsify the reading and could
lead to the engine being oper-
ated with the wrong quantity of
oil, because cold oil is viscous
and takes longer to drain back
into the sump. At extremely low
outdoor temperatures (-10 °C/
14 °F), this can take as long as
12 hours.
e
Attention:
To avoid damage to the engine:
– Never exceed the maximum oil level.
– Always keep the oil level above the minimum mark.
Always check the oil level with
the motorcycle upright.
 Check the oil level with the engine at its regular operating
temperature
 Check the oil level after the engine has been stopped for
at least 5 minutes
 Make sure that the motorcy-
cle is upright
– Make sure the ground is level and firm
10geBKg6.book Seite 30 Dienstag, 19. November 2002 1:11 13

2
31
Safety check
1
MAXMIN2
 Check the oil level at the sight glass:
MAX Top edge
of marking ring
MIN Bottom edge
of marking ring
– The difference between the
two marks is approx. 0.5 litre
(0.88 pint)
 If necessary, remove oil filler plug 2 and top up the engine
oil through engine oil filler 1.
 Reinstall oil filler plug 2e Attention:
Warning light, engine oil pres-
sure red
p (b 9) indicates no
(or very little) oil pressure in
the lube-oil system; this light
m u s t n o t b e r e g a r d e d a s a n o i l
level check. Oil pressure
builds up after 1-2 seconds
and the warning light goes out
– the redengine oil pressure
warning light
p should remain
off while the engine is running.
Engine oil
BMW recommends Castrol
10geBKg6.book Seite 31 Dienstag, 19. November 2002 1:11 13

3
73
Starting – Riding – Parking
5
Engine oil pressureWarning light5 goes out above
idle speed.
e Attention:
If warning light 5 comes on dur-
ing the journey, take the follow-
ing action as soon as traffic
conditions permit:
Declutch
 Operate the kill switch
 Bring the motorcycle safely to a halt
 Check engine oil level
(b 31)
e Attention:
If the warning light comes on
even though the oil level is cor-
rect, you must consult a spe-
cialist workshop, preferably an
authorised
BMW motorcycle dealer.
Warning lights
10geBKg6.book Seite 73 Dienstag, 19. November 2002 1:11 13

3
74
Starting – Riding – Parking
The Rider Information Display
operates only when the ignition
is on.
Engine oil temperature
indicator 1
A= engine oil too hot ( red)
OEOptional extra
e Attention:
Switch off the engine, wait 5 min-
utes and then check the oil level
(
b 30). If the oil level is correct, al-
ways consult a specialist work-
shop without delay, preferably an
authorised BMW motorcycle
dealer.
Avoid high engine speeds until
the problem has been dealt with.
B = engine oil at regular operating
temperature
C = engine oil cold ( blue)
Rider Information DisplayOE (RID)
1
A
B
C
10geBKg6.book Seite 74 Dienstag, 19. November 2002 1:11 13

98
Index
i
AAnti-lock braking systemnotes, 88, 89
switching off, 86
BBMW Integral ABS, 60Changing brake fluid, 41
Checking brake fluid level, 41
CCatalytic convertersafety instructions, 61
Checking brake fluid level, 38
Checking brake pads, 37
Checking front brake fluid level, 39, 43
Checking rear brake fluid
level, 40, 44
Checking the brake system, 36
Choke cold start lever, 14
Choke lever
position, 14
Clock (RID), 75
DDipswitch, 14
Dualseat lock, 4
EEngine oil, 31 level check, 4
oil filler, 31 Engine oil filler, 4
Engine oil temperature indicator
(RID), 74
Engine-oil pressure
telltale light, 9
FFront brakebrake fluid reservoir, 5
Front spring preload, 50
Fuel octane number, 33
Fuel cap, 5
Fuel gauge (RID), 74
Fuel tank capacity, 33
Fuse box, 5
GGear shifts, 76, 77
General view left side, 6
Right side, 5, 7
General view, left side, 4
HHandlebar fitting, left, 14
Handlebar fitting, right, 15
Handlebar levers
Clutch lever, 34
handbrake, 35
Hazard warning lights, 12
Heated handlebar grips, 12, 15
Helmet holder, 5
A - H
10geBKg6.book Seite 98 Dienstag, 19. November 2002 1:11 13

99
Index
i
High/low (dipped) headlight switch, 14
Horn, 14
Hydraulic fluid clutch, 45
IIgnition switch and steering lock, 8
function, 10
Instrumente Cockpit, 8
KKatalysator, 61
Key positions, 11
Kill switch, 15
LLights
general instructions, 46, 47
headlight beam throw, 46, 47
MMain (centre) stand, 64, 65
Motorcycle equipment, 95
NNeutral, 69
OOctane number, fuel, 33
Odometer, 8
Oil filler, 4, 31 Oil level
checking, 31
engine oil pressure, 9
Oil level sight glass, 4
PPartially integral brakes, 82
Power socket, 4, 13
RRear brake fluid reservoir, 5
Refuelling, 32, 33
Residual braking function, 42, 83
Revolution counter, 8
Rider Information Display Fuel gauge, 75
Gear indicator, 75
Rider Information Display (RID), 8
clock, 75
engine oil temperature, 74
Rider’s equipment, 94
Riding, 76, 77
Risk of fire, 61
Risk of overheating, 61, 70
Risk of poisoning, 60
Running in new brake pads, 67
Running in new tyres, 67
SSafety checklist, 28
Safety instructions
braking, 78, 79
catalytic converter, 61
general, 60
H - S
10geBKg6.book Seite 99 Dienstag, 19. November 2002 1:11 13