2002 BMW MOTORRAD K 1200 LT check engine light

2
Introduction
i
General information and con-
trols
General view, left side ........ 4-5
General view, right side ...... 6-7
Cockpit .............................. 8-9
Telltale and warning
lights .............................. 10-11
Ignition switch and steering
lock ................................ 12-13
Handlebar fittings ........... 14-15
Hazard warning flashers ...... 16
Adjusting windscreen/deflec-
tors ..................................... 17
Reverser ........................18-20
Cruise control ............... 21-24
On-board computer ....... 25-29
Cases.................................. 30
Topcase .............................. 31
Front seat .......................32-33
Rear seat .......................34-36
Seat heating ........................ 37
Helmet holder ..................... 38Safety check
Checklist ............................. 39
Engine oil ...................... 40-41
Fuel ................................ 42-43
Handlebar levers ............ 44-45
Brake system - general .. 46-47
Brake system - with
BMW Integral ABS ......... 48-50
Clutch ................................. 51
Suspension spring preload . 52
Wheels ........................... 53-54
Loading.......................... 55-56
Lights ............................. 57-58
Coolant ............................... 59
Contents
10LTbkg4.bk Seite 2 Dienstag, 27. August 2002 8:28 08

2 2
39
Safety check
Checklist
Use the safety checklist –
before every journey
Please perform the safety
check accurately. If your motor-
cycle needs any routine mainte-
nance, you can then attend to it
before the journey starts
(
b Maintenance Instructions),
or have it carried out by a spe-
cialist workshop, preferably an
authorised BMW Motorrad
dealer. This is to ensure that
your motorcycle corresponds
with road-vehicle use and
safety laws.
A motorcycle in perfect techni-
cal condition is essential for
your safety and that of other
road users.For this reason, check the
details in the following sections
before you start the journey:
–Fuel level
–Positions of the handlebar-
lever fittings
–Brake fluid level
–Clutch fluid level
–Brakes
–Warning lights and telltale
lights
–Suspension spring preload
–Wheel rim and tyre condition,
tread depth and tyre pressures
–Load, gross weight
–Lights
–Coolant level
–Check regularly (every time
you stop for fuel),
on the basis of the following
section:
–Engine oil level
(every second/third stop for
fuel):
–brake pads
If you encounter any problems
or difficulties, it is always best to
contact your authorised BMW
motorcycle dealer. He will pro-
vide the necessary advice and
assistance.
10LTbkg4.bk Seite 39 Dienstag, 27. August 2002 8:28 08

2 2
41
Safety check
BMW recommends Castrol
Engine oil
Place the motorcycle on the
main (centre) stand
–Make sure the ground is
level and firm.
Read off the oil level at the
sight glass:
A (MAX)top edge of
sight glass
C (MIN)bottom edge of
sight glass
–The difference is equivalent
to approx. 0.5 litres
(0.88 Imp.pints)
If necessary, remove oil filler
plug3 and pour in engine oil
using funnel2, through oil
filler neck1Insert and tighten the filler
plug3
e Caution:
Warning light, engine oil pres-
sure red
p(b 11) indicates
no (or very little) oil pressure in
the lube-oil system; this light
m u s t n o t b e r e g a r d e d a s a n o i l
level check. Oil pressure
builds up after 1-2 seconds
and the warning light goes out
– the redengine oil pressure
warning light
p should remain
off while the engine is running.
1
2
3
C
B
A
10LTbkg4.bk Seite 41 Dienstag, 27. August 2002 8:28 08

2 2
59
Safety check
Coolant
Checking coolant level
e Caution:
Always keep the coolant level
above the minimum mark. Add
coolant only when the engine is
cold.
Place the motorcycle on its
main (centre) stand
–Make sure the ground is
level and firm.
Open the left case (
b 30)
Check coolant level at the
expansion tank, using a
pocket lamp if necessary:
MAXMaximum level
MINMinimum level
e Caution:
Never overfill the expansion
tank under the seat.
Add coolant if necessary
Lock left case (
b 30)
L Note:
If the expansion tank is full and
coolant temperature is high (as
indicated by red warning light
j
b 11) or coolant consumption
is excessive, consult an author-
ised BMW motorcycle dealer.
MAX
MIN
10LTbkg4.bk Seite 59 Dienstag, 27. August 2002 8:28 08

72
Starting – Riding – Parking
3
2
34 Warning lights
ABS warning lightThe ABS warning light 1 lights
up if the BMW Integral ABS
(
b 85) develops a fault
Warning light, general General warning light 2 lights
up if the BMW Integral ABS
develops a fault (
b 85), or if the
tail light or brake light is defec-
tive.
Low fuel levelWhen warning light3 comes
on, there are still approx.
4 litres (0.9 gal) of fuel in the
tank.
* depending on national-market speci-
fication
Engine oil pressureWarning light4 goes out above
idle speed.
e Caution:
If warning light4 comes on dur-
ing the journey, take the follow-
ing action immediately if no
road safety risk is incurred:
Declutch
Operate the emergency off
switch
Bring the motorcycle safely to
a halt
Check engine oil level
(
b 41)
Top up the oil if the level is low. If
the warning light comes on even
though the oil level is correct, you
must consult a specialist work-
shop, preferably an authorised
BMW motorcycle dealer.
1*
10LTbkg4.bk Seite 72 Dienstag, 27. August 2002 8:28 08

3
73
Starting – Riding – Parking
56Warning lights
Coolant temperature
Warning light5 (red) goes out
when the engine is started,
above idle speed.
e Caution:
If the coolant temperature warn-
ing light 5 comes on, stop the
engine and allow it to cool
down.
Check coolant level in the
expansion tank (
b 59).
If the expansion tank is full, but
the warning light remains on, or
if coolant consumption is ex-
cessive, consult a specialist
workshop, preferably an author-
ised BMW motorcycle dealer.
Battery charge currentWarning light6 goes out above
idle speed.
e Caution:
If warning light 6 comes on dur-
ing the journey: seek the advice
of a specialist workshop, prefer-
ably an authorised BMW motor-
cycle dealer.
10LTbkg4.bk Seite 73 Dienstag, 27. August 2002 8:28 08

94
Index
i
AABS, 80
Adjusting deflectors, 17
Adjusting windscreen, 17
Aerial, 4
Anti-lock brake system
notes, 78, 80-85
Audio system controls
passenger, 6
BBMW Integral ABS, 78-84
brake fluid level, 50
brake fluid reservoir, front, 6
brake fluid reservoir, rear, 6
troubleshooting chart, 85
warning lights, 10
Brake pads
running in, 69
Brake pads, checking, 47
Brake servo, 80
Brake system
general, 46, 47
with BMW Integral
ABS, 48, 49, 50
Brake system, checking, 46
CCases
opening/closing, 30
Cassette player/radio, 9
Catalytic converter, 63
safety instructions, 63CD changer, 7
Changing gear, 75
Checklist, 39
Clock, 10
Clock (in cockpit), 10
Clutch
fluid level, 51
Clutch lever, adjusting, 44
Cockpit
general view, 8, 9
Coolant level
checking, 59
Coolant reservoir, 5
Coolant temperature, 72
Coolant temperature gauge, 9
Cruise control
notes, 21
operation, 22, 23, 24
switch, 14
EEmergency off (kill) switch for
ignition, 15, 70
Engine oil, 40
oil filler neck, 41
Engine oil pressure
telltale light, 72
Engine speed, 74
Environmental protection, 89
A – E
10LTbkg4.bk Seite 94 Dienstag, 27. August 2002 8:28 08

96
Index
i
Loading, 55, 56
Low/high headlight switch, 14
MMain (centre) stand, 66, 67
Motorcycle accessories, 91
NNeutral, 70
Notes on safety
general, 62
OOctane number, fuel, 43
Odometer, 8
Oil filler neck, 7, 40, 41
Oil funnel, 41
location, 4
Oil level
check, 40, 41
engine oil pressure, 11, 72
sight glass, 7
On-board computer, 8
ambient temperature, 28
average fuel consumption, 29
average speed, 29
calling up functions, 25
estimated range, 28
handlebar controls, 26
recalculation, 27
starting recalculation, 27
On-board literature
location, 4
PPower socket
rider and passenger, 4
RRadio/cassette player, 9
Rear seat
adjusting backrest, 34, 35, 36
Rear-seat heating, 37
Refuelling, 42
Remote control
audio system
handlebar controls, 14
passenger, 6
on-board computer, 26
Repair kit for tubeless tyres, 5
Residual braking function, 49, 81
Rev. counter, 8
Reverser, 18
selector lever, 5
RHD traffic
headlight adjustment, 58
Rider’s equipment, 90
Riding, 74
Rims, 53
Roadspeed indicator, 8
Running-in speeds, 68
SSafety check, 39
Safety instructions
braking, 76
catalytic converter, 63
L – S
10LTbkg4.bk Seite 96 Dienstag, 27. August 2002 8:28 08