2002 BMW MOTORRAD K 1200 GT coolant

2
Introduction
i
General information and
controls
General view, left side ........... 4
General view, right side ......... 5
Cockpit ................................. 6
Telltale and warning
lights .................................. 7-8
Hazard warning flashers ........ 9
Ignition switch and steering
lock ................................ 10-11
Left handlebar fitting ........... 12
Right handlebar fitting ......... 13
Cruise control ................ 14-17
Adjusting footrest
plate ............................... 18-19
Seat ............................... 20-21
Adjusting windscreen .......... 22
System case .................. 23-25Safety check
Checklist ........................ 26-27
Engine oil ....................... 28-29
Fuel ................................ 30-31
Handlebar levers ............ 32-33
Brake system
- general ........................ 34-35
Brake system - with
BMW Integral ABS ......... 36-39
Coolant level .................. 40-41
Clutch ................................. 42
Spring preload .................... 43
Shock-absorber
adjustment .......................... 44
Wheels ........................... 45-46
Accessories and tyres......... 47
Loads............................. 48-49
Lights ............................. 50-53
Contents
10k41bkg2.book Seite 2 Donnerstag, 24. Juli 2003 9:17 09

6
General information and controls
1
1Fuel gauge (b 30)
2 Trip meter reset knob
3 Speedometer
4 Odometer
5 Trip meter
6 Revolution counter (
b 62) 7
Coolant temperature gauge
A Engine cold
B Engine at normal oper-
ating temperature
C Engine overheated
(
b 67)
8 Telltale and warning lights
(
b 7, 8)
9 Ignition switch and steering
lock (
b 10, 11)
( ) Number in parentheses
b page number for description
Cockpit
CA
1234567
98
B
10k41bkg2.book Seite 6 Donnerstag, 24. Juli 2003 9:17 09

8
General information and controls
1
Telltale and warning lights
1Warning light, coolant tem-
perature
j red (b 40, 67)
2 Warning light, battery
charge current red
r
(b 67)
3 Telltale light, high-beam
headlight blue
q
4 Warning light, engine oil
pressure red
p (b 29, 66) 5
Warning light, fuel level/
when approx. 4 litres
(0.9 gal) left in tank yellow
m
(b 31, 66)
( ) Number in parentheses
bpage number for description
34512
10k41bkg2.book Seite 8 Donnerstag, 24. Juli 2003 9:17 09

20
General information and controls
1
Removing seat:Turn key1 in the seat lock to
position A and hold it in this
position
 Pull the seat to the rear and up into the 1st stage C of the
locking mechanism.
 Remove the seat
– Toolkit is accessible
–Tubeless tire repair kit is accessible
– Fuses are accessible
– Coolant expansion tank is accessible
Adjusting seat:– The seat can be moved to 2 positions:
E = high D = low
e Attention:
When installing the seat, make
sure that it is firmly located.
Turn key 1 in the seat lock to
position A and hold it in this
position
 Pull the seat to the rear and up into the 1st stage C of the
locking mechanism.
Seat
A
1
B
C
10k41bkg2.book Seite 20 Donnerstag, 24. Juli 2003 9:17 09

22
27
Safety check
2
For this reason, check the
details in the following sections
before you start the journey:
– Fuel level
– Positions of the handlebar levers
–Brakes
–Brake fluid level
– Clutch fluid level
– Coolant level
– Shock-absorber setting and spring preload
– Wheel rim and tyre condition, tread depth and tyre
pressures
– Load, gross weight
–Lights
– Warning lights and indicator lights with ignition switched
on – Check regularly (every time
you stop for fuel), on the basis
of the following section:
– Engine oil level (every sec- ond/third stop for fuel):
– Brake pads
If you encounter any problems
or difficulties, it is always best to
contact your authorised BMW
motorcycle dealer.
He will provide the necessary
advice and assistance.
Checklist
10k41bkg2.book Seite 27 Donnerstag, 24. Juli 2003 9:17 09

40
Safety check
2
Coolant level
Checking coolant level
e Attention:
Always keep the level above the
minimum mark. Check coolant
level only when the engine is
cold.  Place motorcycle on main
(centre) stand
– Make sure the ground is
level and firm.
 Remove the seat if necessary
(
b 20)
 Check coolant in expansion
tank:
MAX Maximum level
MIN Minimum level
10k41bkg2.book Seite 40 Donnerstag, 24. Juli 2003 9:17 09

22
41
Safety check
2
e Attention:
The coolant level must be be-
tween the MIN and MAX
marks.
Never overfill the expansion
tank.
•Top up the coolant if neces-
sary (
b Maintenance Instruc-
tions, Chapter 3)
L Note:
If the expansion tank is full and
coolant temperature is high (as
indicated by red warning light

j b 8) or coolant consumption
is excessive, consult a special-
ist workshop, preferably an au-
thorised BMW motorcycle
dealer.
Coolant level
MAX
MIN
10k41bkg2.book Seite 41 Donnerstag, 24. Juli 2003 9:17 09

3
67
Starting – Riding – Parking
Coolant temperatureWarning light5 (red)
goes out when the engine is
started, above idle speed.
e Attention:
If the coolant temperature warn-
ing light 5 comes on, stop the
engine and allow it to cool down.
Check coolant level in the expan-
sion tank (
b 40).
If the expansion tank is full, but
the warning light remains on, or if
coolant consumption is exces-
sive, consult a specialist work-
shop, preferably an authorised
BMW motorcycle dealer.
Battery charge currentWarning light 6 goes out above
idle speed.
e Attention:
If warning light 6 comes on dur-
ing the journey:
Seek the advice of a specialist
workshop, preferably an author-
ised BMW motorcycle dealer.
Warning lights
65
10k41bkg2.book Seite 67 Donnerstag, 24. Juli 2003 9:17 09