2002 BMW MOTORRAD K 1200 GT fuel

22
31
Safety check
2
Refuel
– Refuel only with super (pre-mium) grade unleaded fuel to
DIN 51607 standard or equiv-
alent, minimum octane
number 95 (RON) and
85 (MON)
 Close the fuel filler cap
Capacity
L Note:
The fuel gauge and warning
light function only when the ig-
nition is on.
– Usable tank capacity 21 litres ( 4.62 gal)
–A yellow warning light 1
comes on when there are
approximately 4 litres (0.9 gal)
of fuel left in the tank
1 Fuel
10k41bkg2.book Seite 31 Donnerstag, 24. Juli 2003 9:17 09

3
57
Starting – Riding – Parking
Important notes
Catalytic converter
e Attention:
To avoid damage to the cata-
lytic converter:
 Do not run the fuel tank dry
 Push-start only when the
engine is cold
 Do not run the engine with a
spark-plug cap detached
 Do not exceed the engine- speed limits marked on the
revolution counter
 Comply with all specified
maintenance intervals
 Stop the engine at once if it
misfires
 In the event of misfiring or a severe drop in engine power,
consult a specialist work-
shop, preferably an author-
ised BMW motorcycle dealer
If misfiring or malfunction of the
fuel-air mixture preparation sys-
tem causes unburned fuel to
reach the catalytic converter,
there is a risk of it overheating
and being damaged.
Risk of fireHigh temperatures occur at the
exhaust system, particularly if a
catalytic converter is installed.
d Warning:
Make sure that whether riding
or standing still or when the
motorcycle is parked, no eas-
ily flammable material
(for example hay, grass,
leaves, clothing or luggage
etc.) can come into contact
with the hot exhaust system.
Do not allow the engine to
idle unnecessarily or for a
lengthy period when the mo-
torcycle is at a standstill
— risk of overheating or fire.
Ride away immediately after
starting the engine.
10k41bkg2.book Seite 57 Donnerstag, 24. Juli 2003 9:17 09

64
Starting – Riding – Parking
3
Before you start
Switch on the ignition– Move the kill switch to the run position A
 Ignition switch ON
In an emergency only:
 Move switch 1 to the B
position.
– The Motronic, fuel pump and
starter motor electrical cir-
cuits are de-energised
L Note:
If you move the kill switch to the
B position while the ignition is
on (switch in ON position), the
BMW Integral ABS remains op-
erational (
b 72-79).
Fully retract the side stand
L Note:
If the side stand is extended
and a gear engaged, you can-
not start the motorcycle.
Select neutral– Neutral indicator light green
k is on (b 7)
– Gear indicator shows “0”
L Note:
Engine does not start:
–Move the gear lever to thek
position or disengage the
clutch
Engine stops when first gear is
engaged:
–Fully retract the side stand; if
necessary, consult the trouble-
shooting chart (
b Maintenance
Instructions, Chapter 2)
10k41bkg2.book Seite 64 Donnerstag, 24. Juli 2003 9:17 09

66
Starting – Riding – Parking
3
ABS warning lightThe ABS warning light 1 lights up
if the BMW Integral ABS develops
a fault (
b 79).
Warning light, general General warning light 2 lights up if
the BMW Integral ABS develops a
fault (
b 79), or if the tail light or
brake light is defective.
Low fuel levelWhen warning light 3 comes on,
there are still approximately
4 litres (0.9 gal) of fuel in the tank.
Engine oil pressureWarning light 4 goes out above
idle speed.
*n depending on national-market
specification
e Attention:
If warning light 4 comes on dur-
ing the journey, take the follow-
ing action as soon as traffic
conditions permit:
Declutch
 Operate the kill switch
 Bring the motorcycle safely to
a halt
 Check engine oil level
(
b 28)
Top up with fresh oil if the oil
level is low. If the warning light
for engine oil pressure lights up
even though the oil level is cor-
rect, it is absolutely essential to
consult a specialist workshop,
preferably an authorised BMW
motorcycle dealer.
Warning lights
1*2
43
10k41bkg2.book Seite 66 Donnerstag, 24. Juli 2003 9:17 09

68
Starting – Riding – Parking
3
Engine speedChoose engine speeds in
accordance with the coolant
temperature reading (
b 6), and
do not use maximum engine
speeds unless the engine has
reached its regular operating
temperature.
In the red zone of the rev. coun-
ter the fuel supply is interrupted
in order to protect the engine,
so that misfiring occurs.
L Note:
The governor cuts in at
9,400 rpm.
Load changes
d Warning:
Try not to open or close the
throttle abruptly, particularly
on wet or slippery roads.
Gearshifts
L Note:
Never slip the clutch exces-
sively when changing gear.
Vary your speed only by using
the throttle in a suitable gear,
not by slipping the clutch.
The digital cockpit display
shows which gear has been
selected (
b 7).
Riding, gear shifts
10k41bkg2.book Seite 68 Donnerstag, 24. Juli 2003 9:17 09

89
Index
i
EEmergency off (kill) switch for ignition, 13
Engine oil, 29
Oil filler neck, 29
Engine oil pressure
telltale light, 66
Engine speed, 68
FFront brake Brake fluid level, 38
Handbrake lever, 33
Fuel Octane number, 31
Fuel filler cap, 4, 30
Fuel gauge, 6
Fuel tank capacity, 66
Fuse box, 4
GGear indicator, 7
Gearshift lever, 19
Gearshifts, 68, 69
General view, Left side, 4
Right side, 5
HHandlebar fitting
Left, 12
Right, 13
Handlebar lever
Handbrake lever, 33 Hazard warning flashers, 9
Headlight basic setting, 53
Headlight switch, 12
Heated handlebar grips, 13
High-beam/low-beam headlight
switch, 12
Horn, 12
Horn push, 12
IIgnition switch and steering lock, 6, 10
Function, 11
Installing system case, 25
Integral brake function, 74
KKeys, 10
LLHD traffic Headlight setting, 51
Lifting handle, 4
Light switch, 13
Lights, 50, 52, 53 Beam throw, 40, 51
Notes, 40
Loading, 47
MMain (centre) stand, 60, 61
Motorcycle accessories, 85
E - M
10k41bkg2.book Seite 89 Donnerstag, 24. Juli 2003 9:17 09

90
Index
i
NNeutral (gearbox), 64
Notes on safetyGeneral, 56
OOctane number, fuel, 31
Odometer, 6
Oil filler neck, 5, 29
Oil levelCheck, 29
Engine oil pressure, 8, 66
Sight glass, 5
Overheating, 57, 65
PPartially integral brakes, 74
Permitted gross weight, 49
Power socket, 4
RRefuelling, 30
Removing system case, 24
RESIDUAL BRAKING FUNCTION, 37, 75
Revolution counter, 6
RHD traffic Headlight setting, 51
Rider’s equipment, 84
Riding, 68
Right flashing turn indicator switch, 13 Rims, 45
Running-in speeds, 62
SSafety check, 26, 27
Safety instructions
Catalytic converter, 57
Safety margin, 73
Seat Adjusting, 20
Installing, 21
Removing, 20
Seat lock, 4
Self-cancelling turn indicators, 12,
13
Self-diagnosis with pull-away test,
76
Sensitive electronic control, 72
Service, 81
Service worldwide, 82
Side stand, 58, 59, 64
Speedometer, 6
Spring preload
Front wheel, 43
Starter button, 13
Starter switch, 13
Starting, 65
Switch on the ignition, 64
System case, 23, 25
N - S
10k41bkg2.book Seite 90 Donnerstag, 24. Juli 2003 9:17 09

91
Index
i
TTank cap, 4
Telltale and warning lightsABS, 7, 66
Battery charge current, 8
Battery charge light, 67
Coolant temperature, 8, 67
Cruise control, 7
Engine oil pressure, 8, 66
High-beam headlight, 8
Low fuel level, 8, 66
Neutral, 7
Turn indicator, right, 7
Telltale lights Turn indicator, left, 7
Toolkit, 4
Tools, 4, 20
Tread depth, tyres, 45, 46
Troubleshooting ABS, 79
Troubleshooting chart, 79
Turn indicator switch, left, 12
Turn-indicator cancel switch, 13
Tyres
Inflation pressure, 46
Running in, 63WWarning lightLow fuel level, 66
Warning lights
ABS, 66
Battery charge light, 67
Coolant temperature, 67
Engine oil pressure, 66
General, 66
Warnings
Braking, 70
T - Z
10k41bkg2.book Seite 91 Donnerstag, 24. Juli 2003 9:17 09