2001 YAMAHA WARRIOR 350 battery

8-77
Yuki_Data:Yuki_data:Yuki:Yuki_1:ATV:HM00B067_YFM350X-60:YFM350-8.frame
EL
EBU00382
Replenishing the battery fluid
A poorly maintained battery will corrode and
discharge quickly. The battery fluid should be
checked at least once a month.
1. The level should be between the upper
and lower level marks. Use only distilled
water if refilling is necessary.
2. Disconnect the negative (
-) lead.
3. Disconnect the positive (+) lead and re-
move the battery.
CAUTION:Normal tap water contains minerals which are
harmful to a battery. Therefore, refill only withdistilled water.
1. Maximum level mark 2. Minimum level mark
1. Repère de niveau maximum 2. Repère de niveau minimum
1. Marca del nivel maxima 2. Marca del nivel mínimo

8-79
Yuki_Data:Yuki_data:Yuki:Yuki_1:ATV:HM00B067_YFM350X-60:YFM350-8.frame
EL
4. When the machine is not to be used for a
month or longer, remove the battery and
store it in a cool, dark place. Completely
recharge the battery before reusing.
5. If the battery is to be stored for a longer
period than the above, check the specific
gravity at least once a month and re-
charge the battery when it is too low.
6. Always make sure the connections are
correct when putting the battery back in
the machine. Make sure the breather hose
is properly connected and is not damaged
or obstructed.

8-93
Yuki_Data:Yuki_data:Yuki:Yuki_1:ATV:HM00B067_YFM350X-60:YFM350-8.frame
EL
EBU00440
Troubleshooting chart1. Fuel
Check if there is fuel
in the fuel tank.There is fuel.Turn the fuel
cock to “OFF”.No fuel.Fuel cock
clogged.
Clean fuel
cock. Some fuel.Turn the fuel
cock to “RES”.Restart engine.
No fuel.Supply fuel.
2. Compression
Use the electric starter
to see if there is
compression.There is compression.
Compression normal.
No compression.Ask a Yamaha dealer to
inspect.
3. Ignition
Remove plug and
check electrodes.WetWipe clean with dry cloth.
DryAttach plug cap and
ground to chassis.Use the
electric starter.Spark good.Ignition system
normal.
Spark weak.
Adjust plug gap
or replace plug. No spark.
Ask a Yamaha dealer to
inspect. 4. Battery
Use the electric
starter.Engine turns over
quickly.Battery good.
Engine turns over
slowly.Check fluid, recharge,
check connections.Check fuel
flow.
Turn the fuel
cock to “ON”.
Remove the
fuel pipe.

9-9
Yuki_Data:Yuki_data:Yuki:Yuki_1:ATV:HM00B067_YFM350X-60:YFM350-
EL
5. Block up the frame to raise all wheels off
the ground.
6. Tie a plastic bag over the exhaust pipe
outlet to prevent moisture from entering.
7. If storing in a humid or salt-air atmo-
sphere, coat all exposed metal surfaces
with a light film of oil. Do not apply oil to
any rubber parts or the seat cover.
8. Remove the battery and charge it. Store it
in a dry place and recharge it once a
month. Do not store the battery in an ex-
cessively warm or cold place (less than
0 ˚C or more than 30 ˚C).
NOTE:

Make any necessary repairs before storing the
machine.

10-5
Yuki_Data:Yuki_data:Yuki:Yuki_1:ATV:HM00B067_YFM350X-60:YFM350-SPEC-E.frame
EL
Shock absorber:
Front
RearCoil spring / Oil damper
Coil spring / Gas-Oil damper
Wheel travel:
Front
Rear200 mm
200 mm
Electrical:
Ignition system
Generator system
Battery type/voltage, capacityC.D.I.
C.D.I. Magneto
GM12CZ-4A-2/12V, 12AH
Headlight type: Krypton bulb
Bulb voltage, wattage
´
quantity:
Headlight
Taillight
Indicator light:
Neutral
Reverse12V, 30W/30W
´
2
12V, 3.8W
´
1
12V, 3.4W
´
1
12V, 3.4W
´
1 MODEL YFM350X