Page 1040 of 1897
DI-6
- DIAGNOSTICSENGINE
162 Author: Date:
2001 AVALON (RM808U)
TOYOTA hand-held tester only:
When the diagnosis system is switched from the nor-
mal mode to the check mode, it erases all DTC and
freezed frame data recorded in the normal mode. So
before switching modes, always check the DTC and
freezed frame data, and note them down.
(1) Prepare the OBD II scan tool (complying with SAE
J 1978) or TOYOTA hand-held tester.
(2) Connect the OBD II scan tool or TOYOTA hand-
held tester to the DLC3 at the lower center of the
instrument panel.
(3) Turn the ignition switch ON and push the OBD II
scan tool or TOYOTA hand-held tester switch ON.
(4) Use the OBD II scan tool or TOYOTA hand-held
tester to check the DTC and freezed frame data and
note them down (For operating instructions, see the
OBD II scan tool's instruction book.).
If there is no DTC in the normal mode, check the 1st
trip DTC using Continuous Test Results function
(Mode 7 for SAE J1979) on the OBD II scan tool or
TOYOTA hand-held tester.
(5) See page DI-14 to confirm the details of the DTC.
NOTICE:
When simulating symptoms with an OBD II scan tool
(excluding TOYOTA hand-held tester) to check the
DTC, use the normal mode. For code on the DTC chart
subject to º2 trip detection logicº, perform the follow-
ing either action.
Turn the ignition switch OFF after the symptom is
simulated the 1st time. Then repeat the simulation
process again. When the problem has been simulated
twice, the MIL lights up and the DTCs are recorded in
the ECM.
Check the 1st trip DTC using Mode 7 (Continuous Test
Results) for SAE J1979.
(c) Clear the DTC.
The DTCs and freezed frame data will be erased by either
action.
Operating the OBD II scan tool (complying
with SAE J1978) or TOYOTA hand-held tes-
ter to erase the codes. (See the OBD II scan
tool's instruction book for operating instruc-
tions.)
Disconnecting the battery terminals or EFI
fuse.
Page 1215 of 1897
H12004
Battery10Airbag Sensor Assembly
LA
C63
B-Y 5 12
1F 1A1I
II2
B-Y 5 B-Y
5 AB DLC1
B-Y
56 M7
SRS Warning Light
LG-B
IJ1 4
LG-B
2G 2B
SRS WRN
Engine Room J/BB
FL Block F7
F6 1
1
B FL MAINDriver Side J/B
12
- DIAGNOSTICSSUPPLEMENTAL RESTRAINT SYSTEM
DI-479
635 Author: Date:
2001 AVALON (RM808U)
SRS Warning Light Circuit Malfunction
CIRCUIT DESCRIPTION
The SRS warning light is located on the combination meter.
When the SRS is normal, the SRS warning light lights up for approx. 6 seconds after the ignition switch is
turned from the LOCK position to ACC or ON position, and then turns off automatically.
If there is a malfunction in the SRS, the SRS warning light lights up to inform the driver of the abnormality.
When terminals Tc and E1 of the DLC1 are connected, the DTC is displayed by blinking the SRS warning
light.
WIRING DIAGRAM
DI5RJ-04
Page 1216 of 1897
AB0117H01293H01295
Airbag Sensor Assembly
LOCK
DI-480
- DIAGNOSTICSSUPPLEMENTAL RESTRAINT SYSTEM
636 Author: Date:
2001 AVALON (RM808U)
INSPECTION PROCEDURE
Always lights up, when ignition switch is in LOCK position
1 Prepare for inspection (See step 1 on page DI-475).
2 Does SRS warning light turn off?
PREPARATION:
(a) Turn the ignition switch to LOCK.
(b) Disconnect negative (-) terminal cable from the battery,
and wait at least for 90 seconds.
(c) Disconnect the airbag sensor assembly connector.
(d) Connect negative (-) terminal cable to the battery.
CHECK:
Check operation of SRS warning light.
NO Check SRS warning light circuit or terminal AB
circuit of DLC1.
YES
Replace airbag sensor assembly.
Page 1224 of 1897
DI15Z-10
Supplemental Restraint System Check Sheet
Date Problem Occurred
Customer 's Name
Registration No.
Registration Year
Frame No.
Odometer Reading
Weather
Temperature
Vehicle Operation
Road Conditions
Details Of Problem
Vehicle Inspection and Repair
History Prior to Occurrence of
Malfunction (Including Supple-
mental Restraint System)
Diagnosis System Inspection
SRS Warning Light
Inspection
DTC Inspection1st Time
2nd Time
1st Time
2nd TimeInspector 's
Name
Fine Cloudy Rainy Snowy Other
Approx.
Starting Idling
Driving [ Constant speed Acceleration Deceleration
Other ]
Remains ON Sometimes Lights Up Does Not Light Up
Remains ON Sometimes Lights Up
Does Not Light Up
Normal Code Malfunction Code
Normal Code Malfunction Code[ Code. ]
[ Code. ]km
Miles //
//
// Date Vehicle Brought In
DI-348
- DIAGNOSTICSSUPPLEMENTAL RESTRAINT SYSTEM
504 Author: Date:
2001 AVALON (RM808U)
CUSTOMER PROBLEM ANALYSIS CHECK
Page 1230 of 1897
H11969
DI1MZ-1 1
R13006
DLC1
E1 Tc
- DIAGNOSTICSSUPPLEMENTAL RESTRAINT SYSTEM
DI-349
505 Author: Date:
2001 AVALON (RM808U)
PRE-CHECK
1. SRS WARNING LIGHT CHECK
(a) Turn the ignition switch to the ACC or ON position and
check that the SRS warning light lights up.
(b) Check that the SRS warning light goes out after approx.
6 seconds.
HINT:
When the ignition switch is at ACC or ON and the SRS
warning light remains on or flashes, the airbag sensor as-
sembly has detected a malfunction code.
If, after approx. 6 seconds have elapsed, the SRS warn-
ing light sometimes lights up or the SRS warning light
lights up even when the ignition switch is OFF, a short in
the SRS warning light circuit can be considered likely.
Proceed to ºSRS warning light circuit malfunctionº on
page DI-479.
2. DTC CHECK (Using diagnosis check wire)
(a) Present troubles codes:
Output the DTC.
(1) Turn the ignition switch to the ACC or ON position
and wait for approx. 20 seconds.
(2) Using SST, connect terminals Tc and E1 of the
DLC1.
SST 09843-18020
NOTICE:
Pay due attention to the terminal connecting position to
avoid a malfunction.
(b) Past troubles codes:
Output the DTC.
(1) Using service wire, connect terminals Tc and E1 of
the DLC1.
SST 09843-18020
(2) Turn the ignition switch to the ACC or ON position
and wait for approx. 20 seconds.
NOTICE:
Pay due attention to the terminal connecting position to
avoid a malfunction.
Page 1236 of 1897
DI164-28
- DIAGNOSTICSSUPPLEMENTAL RESTRAINT SYSTEM
DI-361
517 Author: Date:
2001 AVALON (RM808U)
PROBLEM SYMPTOMS TABLE
Proceed with troubleshooting of each circuit in the table below.
SymptomSuspect AreaSee page
With the ignition switch in ACC or ON position, the SRS warning
light sometimes lights up after approx. 6 seconds have elapsed.
SRS warning light is always lit up even when ignition switch is in
the LOCK position.SRS warning light circuitDI-479
With the ignition switch in ACC or ON position, the SRS warning
light does not light up.
DTC is not displayed.
SRS warning light is always lit up at the time of DTC check pro-
cedure.Tc terminal circuitDI-484
DTC is displayed without Tc and E1 terminal connection.
Page 1246 of 1897
DI6L1-01
I13634
Theft Deterrent ECU
IND 12
3A
J5
J/C7
3G7
W-B
A
A
IGW-B
V-W V10
IC1 22
21
C9
Security Indicator
T4 J/B No. 3
W-B
DI-532
- DIAGNOSTICSTHEFT DETERRENT SYSTEM
688 Author: Date:
2001 AVALON (RM808U)
CIRCUIT INSPECTION
Indicator Light Circuit
CIRCUIT DESCRIPTION
When the theft deterrent system is preparing to set, this circuit lights up the indicator light. When the system
has been set, it continuously turns the indicator light on for 0.75 secs. and turns it off for 1.25 secs., thus
blinking the indicator light.
WIRING DIAGRAM
INSPECTION PROCEDURE
1 Check indicator light.
PREPARATION:
Remove combination meter.
CHECK:
Connect the positive (+) lead from the battery to terminal B22 and the negative (-) lead to terminal B21 of
combination meter connector then check indicator light comes ON.
(See combination meter on page BE-43)
NG Replace combination meter.
OK
Page 1256 of 1897
DI01Q-10
THEFT DETERRENT SYSTEM Check Sheet
Inspector 's name:
Customer 's Name
Date of VehicleRegistration No.
Registration Year
Frame No.
Odometer Reading / /km
Mile
Weather Conditions
When Problem
Occurred Frequency Problem OccursWeather
Outdoor temperature
/ /
Constant Sometimes ( Times per day, month)
Once only Brought in
Theft deterrent system cannot be set.
Indicator light does not flash when the theft deterrent system is set.
(It stays on or does not light at all.)
Theft deterrent system
does not operate. When unlocked using the
door lock knob.
When the engine hood is
opened.
System cannot be
canceled once set. When door is unlocked using key or wireless door lock control system.
When the key is inserted in the ignition key cylinder and turned to ACC or ON
position.
(However, only when the system has never operated)
When the luggage compartment door is opened with the key.
System cannot be
canceled during warning
operation. When door is unlocked using key or wireless door lock control system.
When the key is inserted in the ignition key cylinder and turned to ACC or ON
position.
Warning operation starts when the system is set and the door or luggage compartment door is opened with
the key.
Others.
Date Problem First Occurred
Fine Cloudy Rainy Snowy
Various/Others
Hot Warm Cool
Cold (Approx. 5F ( 5C))
Problem Symptom
Malfunction
Horns only
Theft deterrent horn only
Headlights only
Taillights only
Starter cut only
Door lock operation only
DI-518
- DIAGNOSTICSTHEFT DETERRENT SYSTEM
674 Author: Date:
2001 AVALON (RM808U)
CUSTOMER PROBLEM ANALYSIS CHECK
