2001 SAAB 9-3 air conditioning

80 Instruments and controlsManual climate-control
systemThe air is drawn in through an intake at the
bottom edge of the windshield. It passes
through an efficient filter before being
routed through the climate-control system
and into the cabin. The cabin discharge vent
is located on the right behind the rear
bumper. The air discharge vents should be
kept free of snow and ice in the winter.
The rate of air flow inside the car is con-
trolled by means of the fan switch. Temperature control The temperature of the incoming air can
be steplessly varied using the temperature
control.
Air distribution The air distribution control is used to direct
the flow of air to the defroster, dash and floor
vents.
The control permits settings intermediately
between the three main settings so that the
available air can be apportioned between
the floor and the windshield (defroster) or
between the floor and the panel.
To counter cold drafts from the front side
windows when the control has been set to
defroster or floor, a small flow of air issues
from the dash vents. The dash vents swivel universally, so that
the air can be directed as desired.
The flow of air through the dash vents can
be adjusted for each vent by means of the
adjacent control.
Air to the rear side windows is supplied by
the floor ducts. To demist these windows
you should therefore select a defroster/floor
combination.
If the windows are thoroughly cleaned it is
much easier to keep them free of mist.
Fan
IB755
Control panel: manual system 1 Temperature
2 Fan speed
3 Air distribution
4 Air conditioning (A/C)
5 Rear-window heating
6 Recirculation
IB032
Dash vent 1 Adjusting the direction of the air flow.
2 Adjusting the air flow
ProCarManuals.com

82 Instruments and controls
The air conditioning is combined with the
conventional climate-control system and is
switched on by pressing the button,
provided that the fan control is in
position 1-4.
The incoming air is treated in three stages:
first it passes through a filter; it is then dehu-
midified and cooled and, finally, if required,
heated.
The air conditioning can be used at outdoor
temperatures down to 32°F (0°C). Condensation water When the A/C compressor is on, the incom-
ing air is dehumidified. The resulting con-
densation water is drained away through an
outlet under the car.
It is therefore perfectly normal for water to
be seen dripping from this outlet when the
car is parked. The warmer the ambient air
and the higher the humidity, the more con-
densation will form. When the button is depressed the
regular air intake will be closed. In this posi-
tion, the air inside the cabin is recirculated.
Use recirculation when you want rapid cool-
ing, at extremely high air temperatures.
Switch the air conditioning (A/C) on first.
Recirculation can be useful to activate man-
ually to prevent unpleasant smells being
drawn into the car from outside.
Note that recirculation should not be
used when the outside temperature is
lower than 50°F (+10°C) except briefly,
e.g. to avoid unpleasant air from enter-
ing the car. Prolonged use of recircula-
tion could cause the windows to mist or
ice up.
Air conditioning (A/C)
Recirculation
IB794
Air vent at rear side window
ProCarManuals.com

86 Instruments and controlsFunctions The function you have manually selected will be locked in, while
other functions remain automatic.
Temperature maintenance, except in positions HI and LO, is, there-
fore always automatic. The active function is shown in the display.
A manual selection is cancelled by pressing AUTO or by repeated
pressing of the button used to make the manual choice. For further
functions, see ”Programming II”, page 91.
Button Display
When the system is set to AUTO, the
temperature, air distribution, fan
speed and recirculation will be con-
trolled automatically.
The air conditioning is activated auto-
matically if the outside temperature is
above 32°F (0°C). When AUTO is
depressed again, all automatically
selected settings are shown on the
display.
Button Display
Setting the cabin temperature
1 Switch on the ignition.
2 Set the desired cabin tempera-
ture using the two buttons.
3 The temperature you have now
chosen will be stored, remaining
in the memory even when the
ignition is switched off, unless
ACC has been programmed with
a different "ON" setting. See pro-
gramming, page 90.
IB764
ProCarManuals.com

191 Car care
IB944
Hood release handle ....... 192
Engine .............................. 194
Engine bay ....................... 193
Engine oil ......................... 196
Transmission fluid .......... 197
Coolant ............................. 198
Brake- clutch fluid and
brake pads ..................... 200
Power steering ................ 201
Battery .............................. 201
Drive belt .......................... 203
Wipers and washers ....... 204
Wiper blades .................... 204
Changing bulbs ............... 206
Fuses ................................ 212
Wheels.............................. 217
Safety belts ...................... 224 Upholstery and trim ......... 225
Textile carpeting .............. 225
Engine bay ........................ 226
Washing ............................ 226
Waxing and polishing ...... 227
Touching up the paint ..... 227
Anti-corrosion treatment . 228
Recovery and/or recy-
cling of automotive mate-
rials .................................. 230
Air conditioning (A/C
system) ........................... 232 Car care
ProCarManuals.com

232 Car careAir conditioning
(A/C system)
Fault diagnosis If a fault occurs in the A/C system, there are
a number of checks you can perform your-
self. If the fault persists, however, have the
system checked by an authorized Saab
dealer.Important!

When the A/C system is in operation, mois-
ture from the air will condense on the evap-
orator. When the car is then parked, this
condensation will drip off the evaporator
and form a small pool of water on the
ground. This is normal. The warmer the
ambient air and the higher the humidity, the
greater the amount of condensation formed.Inadequate cooling:
a Make sure that the temperature and
air-distribution controls are in the
appropriate settings, see page 81.
b Check that the condenser (forward of
the radiator) has not become clogged
with dirt and insects.
c Make sure that the drive belt for the com-
pressor is not slipping, see page 203.
d Check the fuses for the ventilation fans
and compressor, see page 214.
NOTE The A/C system is designed for use
with R134a refrigerant.
 Refrigerant handling requires special
equipment and special procedures for
charging and draining the system.
 All repairs and adjustments on the A/C
system must be carried out by a Saab
dealer authorized for this kind of work.
 Never mix R134a and R12 refriger-
ants.
WARNING
 The A/C system is pressurized. Do not
break any connections or undo A/C
system components.
 Escaping refrigerant gas can cause
blindness or other injury.
ProCarManuals.com

257 Index
Index
AA/C system, fault diagnosis
________ 232
A/C system, maintenance _________ 232
ACC
__________________________ 84
ACC, useful tips
_________________ 92
Adjustment, steering wheel
________ 137
Air conditioning (A/C), fault diagnosis
and maintenance
______________ 232
Airbag
_________________________ 28
Alarm __________________________ 41
Alarm functions
__________________ 44
Alarm signals
___________________ 44
Anti-corrosion treatment
__________ 228
Anti-theft system
_________________ 41
Ashtray
_______________________ 141
Audio System
___________________ 93
Automatic climate control (ACC)
_____ 84
Automatic transmission
___________ 162
BBattery
________________________ 201
Boost starting from donor battery
___ 187
Brake fluid, check
_______________ 200
Brake fluid, grade _______________ 251
Brake pad wear indicators
____ 170
, 200Brakes
________________________ 170
Braking _______________________ 170
Bulb table _____________________ 211
CCD changer
____________________ 105
CD player
_____________________ 103
CHECK messages
_______________ 72
CHECKING
_____________________ 72
Cabin lighting __________________ 139
Calibration, ACC _________________ 90
Car alarm
______________________ 41
Car phone, installation
___________ 113
Care of safety belts
______________ 224
Cassette player
_________________ 100
Central locking __________________ 36
Change of address notification
_____ 238
Changing a wheel
_______________ 221
Changing bulbs
_________________ 206
Changing the coolant
____________ 199
Changing the engine oil __________ 196
Changing the key battery __________ 39
Changing the wheels round _______ 218
Changing wiper blades
___________ 204
Chassis number
________________ 253
Child car seats
__________________ 19
Child safety
_____________________ 19
Child safety locks, rear doors
_______ 39
Child seats
_____________________ 19
Cigar lighter ____________________ 141Cleaning the soft top, Convertible
____ 57
Climate-control system, manual
_____ 80
Compact spare wheel
____________ 220
Condensation water, A/C __________ 82
Condensation water, ACC __________ 85
Convertible
_____________________ 47
Coolant
_______________________ 198
Courtesy Headlight Feature
________ 76
Cruise Control
__________________ 169
Cup holder
_____________________ 140
DDICE/TWICE
___________________ 213
Date code, tires _________________ 220
Dim low beam
___________________ 75
Dimmer
________________________ 78
Direction indicators
_______________ 76
Direction-indicator stalk
____________ 76
Dome lighting
__________________ 139
Door mirrors
___________________ 143
Drive belt
______________________ 203
Driving in deep water
_____________ 185
Driving in hot weather ____________ 179
Driving technique
________________ 176
Driving with a compact spare wheel
_ 190
Driving with a load
_______________ 184
Driving with a roof load
___________ 182
Driving with the trunk lid open
______ 185
ProCarManuals.com