2001 Lexus ES300 fuses

INTRODUCTION
395
Checking brake fluid
Parts (if level is low):
FMVSS No. 116 DOT 3 or SAE J1703 brake fluid
Tools:
 Funnel (only for adding fluid)
Checking power steering fluid
Parts (if level is low):
Automatic transmission fluid DEXRON
II or III
Tools:
 Rag or paper towel
 Funnel (only for adding fluid)
Checking battery condition
Tools:
Warm water
 Baking soda
 Grease
 Conventional wrench (for terminal clamp bolts)
Checking and replacing the blade type
fuses
Parts (if replacement is necessary):
Fuse with same amperage rating as original
Checking the cartridge type fuses
Parts (if replacement is necessary):
Genuine Lexus fuse or equivalent with same
amperage rating as original
Adding washer fluid
Parts:
Water
 Washer fluid containing antifreeze (for winter use)
Tools:
 Funnel

SECTION 6 ± 4
443
SERVICE PROCEDURES AND
SPECIFICATIONS
Electrical components
Specifications444
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking battery condition 451
. . . . . . . . . . . . . . . . . . . . .
Battery recharging precautions 455
. . . . . . . . . . . . . . . . .
Checking and replacing the blade type fuses 455
. . . . .
Checking the cartridge type fuses 461
. . . . . . . . . . . . . . .
Adding washer fluid 464
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the headlight aim 464
. . . . . . . . . . . . . . . . . . . . .
Replacing light bulbs 469
. . . . . . . . . . . . . . . . . . . . . . . . . .

ELECTRICAL COMPONENTS
445


1 2 3Engine compartment
4Driver's side instrument panel
± FUSES
64E025a
1Engine compartment
64E065
2Engine compartment

ELECTRICAL COMPONENTS
455
BATTERY RECHARGINGPRECAUTIONS
During recharging, the battery is producing
hydrogen gas.
Therefore, before recharging:
1. If recharging with the battery installed on the vehicle,
be sure to disconnect the ground cable.
2. Make sure the power switch on the recharger is off
when connecting the charger cables to the battery and
when disconnecting them.
CAUTION
Always charge the battery in an unconfined area. Do
not charge the battery in a garage or closed room
where there is not sufficient ventilation.
 Only do a slow charge (5 A or less). Charging at a
quicker rate is dangerous. The battery may explode
causing personal injuries.
NOTICE
Never recharge the battery while the engine is
running. Also, be sure all accessories are turnedoff.
CHECKING AND REPLACING THE BLADE TYPE FUSES

ELECTRICAL COMPONENTS
456
64E064
64E029±2

Engine compartment 1Pull±out tool 2Spare
fuses

ELECTRICAL COMPONENTS
459
64G008

Good
Blown
a. Look carefully at the fuse. If the thin wire is broken,
the fuse has blown. If you are not sure or if it is too dark
to see, try replacing the suspected fuse with one of the
same value that you know is good.
b. Only install a fuse with the amperage rating
designated on the fuse box lid.
If you do not have a spare fuse, in an emergency you can
pull out the ªRADIO NO.1º, ªRAD±NO.2º or ªPOWER
OUTLETº fuse, which may be dispensable for normal
driving, and use it if its amperage rating is the same.
If you cannot use one of the same amperage, use one
lower than, but as close as possible to, the amperage.
If the amperage is lower than that specified, the fuse
might blow out again but this does not indicate anything
wrong. Be sure to get the correct fuse as soon as
possible and return the substitute to its original clips.It is a good idea to purchase a set of spare fuses and
keep them in your vehicle for emergencies.
If the new fuse immediately blows out, there is a problem
with the electrical system. Have your Lexus dealer
correct it as soon as possible.

ELECTRICAL COMPONENTS
461
CHECKING THE CARTRIDGETYPE FUSES
64E011±1
64E015±1

Engine compartment

ELECTRICAL COMPONENTS
462
64E014

Driver's side instrument panel
If the headlights or other electrical components do
not work and the blade type fuses are O.K., check
the cartridge type fuses. If any of the cartridge type
fuses are blown, they must be replaced.