2001 HONDA INSIGHT automatic transmission

ÎÎÎ
Î
Î Î
Specif ications
T echnical Inf ormation
244 Dimensions
Weights
Engine
Capacities
66.7 in (1,695 mm)
53.3 in (1,355 mm)
94.5 in (2,400 mm)
56.5 in (1,435 mm)
52.2 in (1,325 mm)
2.8x3.21in(72x81.5mm) 60.8 cu-in (995 cm
)
10.8 : 1 10.6 US gal (40
, 8.8 Imp gal)
155.0 in (3,938 mm)
Length
Width
Height
Wheelbase
Track
Gross vehicle weight rating See the certification label attached
to the driver’s doorjamb.
Water cooled 4-stroke SOHC3-cylinder gasoline engine 0.61 US gal (2.3, 0.51 Imp gal)
1.06 US gal (4.0, 0.88 Imp gal)
2.6 US qt (2.5
, 2.2 Imp qt)
Type
BorexStroke
Displacement
Compression ratio
Spark plugs ILZFR5A-11 Including the coolant in the reserve tank and that remaining in the
engine.
Reserve tank capacity: 0.11 US gal (0.4
, 0.09 Imp gal)
4.8 US qt (4.5
, 4.0 Imp qt)
2.4 US qt (2.3
, 2.0 Imp qt)
3.2 US qt (3.0, 2.6 Imp qt)
1.6 US qt (1.5
, 1.3 Imp qt)
1.7 US qt (1.6, 1.4 Imp qt)
10.3 : 1 5.8 US qt (5.5
, 4.8 Imp qt)
3.5 US qt (3.3, 2.9 Imp qt)
Fuel tank
Engine
coolant
Engine oil
Manual transmission
fluid
Automatic transmission
fluid (CVT)
Windshield washer reservoir
Front Rear
Approx.
1:
2 : Contact your Honda dealer when replacement is necessary. MTCVT ChangeTotal
Change
Without filter
Total
Change Total
Change Total
2 : U.S. model
2 21
Including filter

CONT INUED
If you take your vehicle f or a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle re-tested within the
next two or three days, you can
condition the vehicle for re-testing
by doing the f ollowing.
Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).
Make sure the ambient
temperature is between 20° and
95°F.
Make sure the vehicle has been
parked with the engine of f f or 8
hours or more. Without touching the accelerator
pedal, start the engine and let it
idle f or 20 seconds.
Keep the vehicle in Park
(automatic transmission) or
Neutral (manual transmission).
Increase the engine speed to 2,000
rpm and hold it there until the
temperature gauge rises to at least
1/4of thescale(approximately3
minutes).
St at e Emissions T est ing
T esting of Readiness Codes
T echnical Inf ormation253

CONT INUED
...
Accessories and Modif ications . 128
................................
Accessories . 128
...
Additional Safety Precaution . 129
............................
Modif ications . 129
ACCESSORY (Ignition Key .......................................
Position) . 70
...............
Accessory Power Socket . 80
....................
Additives, Engine Oil . 168
...............................
Airbag (SRS) . 9, 47
................
Air Conditioning System . 90
..............................
Maintenance . 190
............................................
Usage . 90
.........................
Air Outlets (Vents) . 90
.......................
Air Pressure, Tires . 192
.........................
Normal Driving . 192
.......................
Alcohol in Gasoline . 248
......................................
Antif reeze . 171
Anti-thef t Steering Column
..............................................
Lock . 69
..........................
Appearance Care . 207
..................................
Audio System . 98
........................
Auto Idle Stop . 137, 145
..............
Automatic Transmission . 140
..........................
Capacity, Fluid . 244 ...............
Checking Fluid Level . 178
.......................................
Shif ting . 140
.
Shif t Lever Position Indicator . 140
................
Shif t Lever Positions . 140
....................
Shif t Lock Release . 144
Battery Charging System ...........................
Indicator . 56, 229
............................
Jump Starting . 225
..............................
Maintenance . 185
............................
Specif ications . 245
..............................
Bef ore Driving . 119
..........................................
Belts, Seat . 8
.............................
Beverage Holder . 80
.................................
Body Repairs . 213
Brakes
.............
Break-in, New Linings . 120
...........................................
Fluid . 181
....................
Bulb Replacement . 203
.........................................
Parking . 79
.................
System Indicator . 46, 231
........................
Wear Indicators . 148
.............................
Braking System . 149 ........................
Break-in, New Car . 120
..
Brightness Control, Instruments . 62
........................
Brights, Headlights . 61
Bulb Replacement
..........................
Back-up Lights . 203
...............................
Brake Light . 203
................
Front Parking Lights . 201
........
Front Side Marker Lights . 201
.................................
Headlights . 200
.............................
Interior Light . 205
.................
License Plate Lights . 204
............................
Specif ications . 245
....................
Turn Signal Lights . 201
..............................
Bulbs, Halogen . 200
............................
Capacities Chart . 244
.............
Carbon Monoxide Hazard . 40
.............................
Carrying Cargo . 130
Cassette Player
............................................
Care . 118
...................................
Operation . 104
..............
CAUTION, Explanation of . ii
Index
A
B
C
I

CONT INUED
.....
Charging System Indicator . 229
..................
Checking the Fuses . 233
.....
Low Oil Pressure Indicator . 228
...
Malf unction Indicator Lamp . 230
..................
Overheated Engine . 227
...........................
Emergency Brake . 79
......................
Emergency Flashers . 65
......................
Emergency Towing . 239
.......................
Emissions Controls . 250 Engine
............................................
Belts . 191
....
Coolant Temperature Gauge . 58
Malf unction Indicator
................................
Lamp . 48, 230
..............
Oil, What Kind to Use . 167
...............................
Overheating . 227
............................
Specif ications . 244
.......................................
Starting . 135
..........
Engine Speed Limiter . 139, 143
......................
Ethanol in Gasoline . 248
.
Evaporative Emissions Controls . 250
...............................
Exhaust Fumes . 40
Expectant Mothers, Use of Seat
........................................
Belts by . 17
..................
Exterior, Cleaning the . 208 ............................
Fabric, Cleaning . 211
.....................................
Fan, Interior . 84
Features, Comfort and
................................
Convenience . 83
....................
Filling the Fuel Tank . 121
Filter
.........................
Dust and Pollen . 191
...............................................
Oil . 167
5-speed Manual Transmission ...............
Checking Fluid Level . 180
................................
Shif ting the . 136
.............
Flashers, Hazard Warning . 65
...................
Flat Tire, Changing a . 217
Fluids
Automatic Transmission .....................................
(CVT) . 178
..........................................
Brake . 181
.........................................
Clutch . 181
..............
Manual Transmission . 180
..................
Windshield Washer . 177
FM Stereo Radio ...................................
Reception . 112
.....
Foreign Countries, Driving in . 249
..........................
Four-way Flashers . 65 .................................................
Fuel . 126
......................
Fill Door and Cap . 121
...........................................
Gauge . 58
................
Octane Requirement . 120
...............................
Oxygenated . 248
........................
Reserve Indicator . 58
........................
Tank, Filling the . 121
.....................
Fuses, Checking the . 233
...............
Gas Mileage, Improving . 126
..........................................
Gasohol . 248
.........................................
Gasoline . 120
...............
Fuel Reserve Indicator . 48
...........................................
Gauge . 50
................
Octane Requirement . 120
........................
Tank, Filling the . 121
................
Gas Station Procedures . 121
Index
F
G
III

GaugesEngine Coolant ...........................
Temperature . 58
...............................................
Fuel . 58
...............................
Speedometer . 50
.................................
Tachometer . 58
Gearshif t Lever Positions
Automatic Transmission .....................................
(CVT) . 140
5-speed Manual .........................
Transmission . 136
..............................
Glass Cleaning . 212
........................................
Glove Box . 80
.............
Halogen Headlight Bulbs . 200
Hatch
.................................
Opening the . 71
...................
Open Monitor Light . 47
..............
Hazard Warning Flashers . 65
Headlights
............
Daytime Running Lights . 62
..................
High Beam Indicator . 47
........................
Reminder Beeper . 61
........
Replacing Halogen Bulbs . 200 ...................................
Turning on . 63
.............................................
Heating . 84
.............
High Altitude, Starting at . 135
.................
High-Low Beam Switch . 61
....................................
Hood Latch . 184
.......................
Hood, Opening the . 122
....................................................
Horn . 3
...........................
Hydraulic Clutch . 181
.................................
Hydroplaning . 151
...
Identif ication Number, Vehicle . 242
Ignition
..............................................
Keys . 67
...........................................
Switch . 69
............
Timing Control System . 251
.........
Important Safety Precautions . 6
.........
Indicators, Instrument Panel . 45
Inf ant Seats
..........
Tether Anchorage Points . 41
...................
Inf lation, Proper Tire . 192
.........................
Normal Driving . 193
...................................
Inside Mirror . 78
.............................
Inspection, Tire . 194
............................
Instrument Panel . 45 ........
Instrument Panel Brightness . 62
...........................
Interior Cleaning . 211
...................................
Interior Light . 82
........................................
Introduction . i
........................
Jacking up the Car . 217
.......................................
Jack, Tire . 217
................................
Jump Starting . 224
..................................................
Keys . 67
.......................
Label, Certif ication . 242
.................
Lane Change, Signaling . 63
..........................
Lap/Shoulder Belt . 34
....................
Lif etime Fuel Mileage . 55
Lights
....................
Bulb Replacement . 203
.......................................
Indicator . 47
.........................................
Parking . 46
..................................
Turn Signal . 63
Index
H I J K L
IV

CONT INUED
........
Steam Coming f rom Engine . 227
Steering Wheel
.............
Anti-theft Column Lock . 69
.....................
Stereo Sound System . 98
...........................
Storing Your Car . 200
Supplemental Restraint
..................................
System .9,36
......................................
Servicing . 39
.........................
SRS Indicator . 34, 46
...................
System Components . 36
..................................
Synthetic Oil . 168 .....................
Underside, Cleaning . 208
Unexpected, Taking Care
..........................................
of the . 215
....
Unif orm Tire Quality Grading . 246
........................
Unleaded Gasoline . 120
.....................
Upholstery Cleaning . 211
.......
Used Oil, How to Dispose of . 170
.................
Vehicle Capacity Load . 131
......................
Vehicle Dimensions . 244
....
Vehicle Identif ication Number . 242
.............................
Vehicle Storage . 206
.....................................
Tachometer . 58
......
Taillights, Changing Bulbs in . 203
Taking Care of the
...............................
Unexpected . 215
....................................
Tape Player . 104
Technical Descriptions
......
DOT Tire Quality Grading . 246
.....
Emissions Control Systems . 250
.....................
Oxygenated Fuels . 248
Three Way Catalytic
...............................
Converter . 252
.......................
Temperature Gauge . 58 ..............
Tether Anchorage Points . 33
..
Three Way Catalytic Converter . 252
..........................
Time, Setting the . 103
....................................
Tire Chains . 197
.........
Tire, How to Change a Flat . 195
...............................................
Tires . 192
..............................
Air Pressure . 193
.........................
Checking Wear . 194
..........................
Compact Spare . 216
......
DOT Tire Quality Grading . 246
......................................
Inf lation . 192
..................................
Inspection . 194
...................................
Replacing . 195
......................................
Rotating . 195
...........................................
Snow . 197
............................
Specif ications . 244
................................
Tire Chains . 197
...................
Tools, Tire Changing . 217
Towing
.....................................
A Trailer . 152
................
Emergency Wrecker . 238
Transmission Checking Fluid Level, ..................
Automatic (CVT) . 178
Checking Fluid Level, ...................................
Manual . 180 ...........................
Fluid Selection . 180
..............
Identif ication Number . 243
..................
Shif ting the Manual . 136
.....................................
Treadwear . 246
.....................................
Trip Meters . 53
....................................
Trip Mileage . 54
....................................
Turn Signals . 63
Index
T U V
VII

Service Inf ormat ion Summary
Gasoline:
Fuel Tank Capacity:
Recommended Engine Oil:Brake Fluid:
Automatic Transmission Fluid:
Tire Pressure (measured cold):
5-speed Manual Transmission Fluid:
10.6 US gal (40
, 8.8 Imp gal)
Oil change capacity (including
filter): 2.6 US qt (2.5
, 2.2 Imp qt)
API Service SJ ‘‘Energy
Conserving’’ oil, SAE 0W-20
viscosity (see page ).
Unleaded gasoline, pump octane
number of 87 or higher.
Honda Heavy Duty Brake Fluid
DOT 3 preferred, or a DOT 3 or
DOT 4 brake fluid as a temporary
replacement (see page ).
Spare Tire:
Rear:
Front:
Use Honda ATF-Z1 (Automatic
Transmission Fluid) only.
Honda Manual Transmission
Fluid preferred, or an API service
SG, SH or SJ, SAE 10W-30 or
10W-40 motor oil as a temporary
replacement (see page ).
Capacity (including differential):
1.6 US qt (1.5
, 1.3 Imp qt) 38 psi (260 kPa)
35 psi (240 kPa)
60 psi (420 kPa)
167 181
180