2001 HONDA INSIGHT radiator

Fill the reserve tank to the MAX
mark. Install the reserve tank cap.
Start the engine and let it run f or
about 30 seconds. Then turn of f
the engine.
Pour coolant into the radiator up
to the base of the f iller neck.
14. 15.
16.
Cooling Syst em
Maint enance
176

Periodically check the engine’s
radiator and air conditioning
condenser f or leaves, insects, and
dirt stuck to the f ront surf ace. These
block the air f low and reduce cooling
ef f iciency. Use a light spray f rom a
hose or a sof t brush to remove them.If the air conditioning does not get as
cold as before, have your dealer
check the system. Recharge the
system with Ref rigerant HFC-134a
(R-134a). (See Specif ications on page
.)
Run the air conditioning at least once
a week during the cold weather
months. Run it f or at least ten
minutes while you are driving at a
steady speed with the engine at
normal operating temperature. This
circulates the lubricating oil con-
tained in the ref rigerant.
Your car’s air conditioning is a sealed
system. Any major maintenance,
such as recharging, should be done
by a qualif ied mechanic. You can do
a couple of things to make sure the
air conditioning works ef f iciently.
245
Maint enance
Air Conditioning System (Optional)
190
AAIIRRCCOONNDDIITTIIOONNIINNGGCCOONNDDEENNSSEERR Whenever you have the air conditioning
system serviced, make sure the service
f acility uses a ref rigerant recycling
system. This system captures the
ref rigerant f or reuse. Releasing
ref rigerant into the atmosphere can
damage the environment.
The condenser and radiator f ins bend
easily. Only use a low-pressure spray
or sof t-bristle brush to clean them.

CONT INUED
Unclip the end of the hold-down
wire f rom its slot. Pivot it out of
the way and remove the bulb.
Insert the new bulb into the hole,
making sure the tabs are in their
slots. Pivot the hold-down wire
back in place and clip the end into
the slot.
Install the rubber seal over the
back of the headlight assembly.
Make sure it is right side up; it is
marked ‘‘TOP.’’
Push the electrical connector onto
the tabs of the new bulb. Make
sure it locks in place.
Turn on the headlights to test the
new bulb.
Reinstall the radiator reserve tank.Remove the socket from the
headlight assembly by turning it
one-quarter turn counterclockwise.
Pull the bulb straight out of its
socket.
Install the new bulb into the
socket.Insert the socket back into the
headlight assembly. Turn it
clockwise to lock it in place.
Testthelightstomakesurethe
new bulb is working.
If you are changing the bulb on
the driver’s side, start the engine,
turn the steering wheel all the way
to the right, and turn off the
engine. If you are changing the
bulb on the passenger’s side, turn
the steering wheel to the left.
4. 5. 6. 7. 8.
1.
1. 2. 3. 4. 5.
Lights
Maint enance
Replacing the Front Parking
Lights
Replacing the Front Side Marker/
Turn Signal and Parking L ightBulb
201

If the temperature gauge stays at
the red mark, turn of f the engine.
Wait until you see no more signs
of steam or spray, then open thehood.
If you don’t f ind an obvious leak,
check the coolant level in the
radiator reserve tank (see page). If the level is below the
MIN mark, add coolant to halfway
between the MIN and MAX marks. If the temperature stays normal,
check the coolant level in the
radiator reserve tank. If it has
gone down, add coolant to the
MAX mark. Put the cap back on
tightly.
If there was no coolant in the
reserve tank, you may also have to
add coolant to the radiator. Let the
engine cool down until the pointer reaches the middle of the tempera-
ture gauge, or lower, bef ore check-
ing the radiator.
Using gloves or a large heavy
cloth, turn the radiator cap
counterclockwise, without pushing
down, to the f irst stop. This
releases any remaining pressure in
the cooling system. After the
pressure releases, push down on
the cap and turn it until it comes
off.
Start the engine and set the
temperature control dial to
maximum. Add coolant to the
radiator up to the base of the f iller
neck. If you do not have the
proper coolant mixture available,
you can add plain water.
Remember to have the cooling
system drained and ref illed with
the proper mixture as soon as you
can.
Look f or any obvious coolant leaks,
such as a split radiator hose.
Everything is still extremely hot,
so use caution. If you f ind a leak, it
must be repaired bef ore you
continue driving (see
on page ). Put the radiator cap back on
tightly. Run the engine and watch
the temperature gauge. If it goes
back to the red mark, the engine
needs repair. (See
on page .)
4. 5.
6. 7. 8. 9.
12.
11.
10.
239
125 239
Emergency
Towing
Emergency
Towing
If Your Engine Overheats
T aking Care of t he Unexpect ed 227
Removing the radiator cap
while the engine is hot can
cause the coolant to spray out,
seriously scalding you.
Always let the engine and
radiator cool down before
removing the radiator cap.

Î
Î
..................................
Saf ety Belts . 8, 34
.........
Safety Defects, Reporting . 259
.................................
Saf ety Features . 7
...........................................
Airbags . 9
..................................
Door Locks . 10
..........................
Head Restraints . 10
.......................................
Seat Belts . 8
.....................
Seats & Seat-Backs . 10
.............
Saf ety Labels, Location of . 41
...............................
Saf ety Messages . ii
.....................................
Seat Belts . 8, 34
...............
Additional Information . 34
.....................................
Cleaning . 208
......................
Lap/Shoulder Belt . 34
................................
Maintenance . 35
Reminder Light and
................................
Beeper . 34, 46
...................
System Components . 34
...............
Use During Pregnancy . 17
...
Wearing a Lap/Shoulder Belt . 15
........................
Seats, Adjusting the . 76
...............................
Serial Number . 242
...........................
Service Intervals . 156
...........................
Service Manual . 259 .........
Service Station Procedures . 121
..........................
Setting the Clock . 103
.....
Shif t Lever Position Indicator . 140
........................
Shif t Lock Release . 144
...............................
Signaling Turns . 63
.....................................
Snow Tires . 197
...................
Solvent-type Cleaners . 209
..................................
Sound System . 98
Spare Tire
......................................
Inf lating . 216
............................
Specif ications . 245
....................
Specif ications Charts . 244
...................................
Speedometer . 50
..........
SRS, Additional Inf ormation . 36
...
Additional Safety Precautions . 39
How the SRS Indicator
.......................................
Works . 38
...........
How Your Airbags Work . 36
........................
SRS Components . 36
..................................
SRS Service . 39
.............................
SRS Indicator . 34, 46
....
START (Ignition Key Position) . 70
.......................
Starting the Engine . 135
In Cold Weather at High ..................................
Altitude . 135
................
With a Dead Battery . 224
...................
Radiator Overheating . 227
......
Radio/Cassette Sound System . 98
..
Rear Lights, Bulb Replacement . 203
............................
Rear View Mirror . 79
.................
Rear Window Def ogger . 65
....................
Rear Window Washer . 65
.......................
Rear Window Wiper . 65
...............
Reclining the Seat Backs . 76
Replacement Inf ormation
.................
Air Cleaner Element . 183
..........................
Engine Coolant . 173
................
Engine Oil and Filter . 169
..........................................
Fuses . 233
................................
Light Bulbs . 203
....................................
Schedule . 156
...................................
Drive Belt . 191
...........................................
Tires . 195
.............................
Wiper Blades . 187
Replacing Seat Belts Af ter a ............................................
Crash . 35
Reserve Tank, Engine ...............................
Coolant . 124, 173
...............................
Restraint, Child . 19
................................
Rotation, Tire . 195
Index
RS
VI