2001 HONDA INSIGHT heating

The climate control system draws air
through the exterior vents at the
bottom of the windshield. Keep
these vents clear of leaves and other
debris.For the climate control system to
provide heating and cooling, the
engine must be running.
The automatic climate control
system in your Honda picks the
proper combination of air condi-
tioning, heating, and ventilation to
maintain the interior temperature
you select. The system also adjusts
the fan speed and air flow levels.
The direction of air f low f rom the
vents in the center and each side of
the dashboard is adjustable.
To adjust the air flow from the
center vent, move the tab up-and-
down and side-to-side.
On the driver’s-side vent, move the
vent up-and-down and move the tab
side-to-side. On the passenger’s-side
vent, move the tab up-and-down and
move the vent side-to-side.
Thesideventscanbeopenedand
closed with the dials underneath
them.
Climat e Cont rol Syst em
Comf ort and Convenience Feat ures
90
CCEENNTTEERRVVEENNTTSSDDRRIIVVEERR’’SS--SSIIDDEEVVEENNTT

When you set the temperature to its
lower limit (60°F/18°C) or its upper
limit (90°F/32°C), the system runs
at f ull cooling or heating only. It does
not regulate the interior temperature.
When the temperature is set
between the lower and upper limits,
the system regulates the interior
temperature to the set value.In cold weather, the fan will not
come on automatically until the car
has been driven f or a short time and
the heater starts to develop warm air.
To put the Automatic Climate
Control in f ully-automatic mode,
press the AUTO button and set the
desired temperature by turning the
temperature control dial. You will
see AUTO in the system’s display.
The light above the button
also shows you which mode,
Recirculation or Fresh Air, is
selected.
When the system is in f ully
automatic mode, the auto idle stop
f unction will not be activated.
The system automatically selects the
proper mix of conditioned and/or
heated air that will, as quickly as
possible, raise or lower the interior
temperature f rom its current level to
the set temperature.
Fully-automatic Operation
Climat e Cont rol Syst em
Comf ort and Convenience Feat ures
Auto Button
92
AAUUTTOOBBUUTTTTOONNOOFFFFBBUUTTTTOONN
MMOODDEEBBUUTTTTOONN
FFAANNSSPPEEEEDDBBUUTTTTOONN
EECCOONNBBUUTTTTOONN
TTEEMMPPEERRAATTUURREECCOONNTTRROOLLDDIIAALL

The manual transmission is syn-
chronizedinallforwardgearsfor
smooth operation. It has a lockout so
you cannot shift directly from Fifth
to Reverse. When shif ting up or
down,makesureyoupushtheclutch
pedal down all the way, shift to the
next gear, and let the pedal up
gradually. When you are not shif ting,
do not rest your f oot on the clutch
pedal. This can cause your clutch to
wear out faster.Come to a full stop before you shift
into Reverse. You can damage the
transmission by trying to shift into
Reverse with the car moving. Push
down the clutch pedal, and pause f or
a f ew seconds bef ore shif ting into
Reverse, or shif t into one of the
f orward gears f or a moment. This
stops the gears so they won’t ‘‘grind.’’
When slowing down, you can get
extra braking f rom the engine by
shifting to a lower gear. This extra
braking can help you maintain a safe
speed and prevent your brakes f rom
overheating while going down a
steep hill. Bef ore downshif ting,
make sure the vehicle speed is low
enough that you will not activate the
engine speed limiter in the lower
gear. Make sure the engine speed
will not go into the tachometer’s red
zone in the lower gear bef ore
downshif ting.
5-speed Manual T ransmission
Driving
136 Rapid slowing or speeding-up
can cause loss of control on
slippery surfaces. If you crash,
you can be injured.
Use extra care when driving on
slippery surfaces.

µµ µµ
The belts should have the f ollowing
‘‘play’’ or def lection.
With Air Conditioning System
Without Air Conditioning System
If you see signs of wear or looseness,
have your dealer adjust or replace
the belts.
Check the tension of each belt by
pushingonitwithyourthumb
midway between the pulleys.
Check the condition of the drive belt.
Examine the edges of each belt for
cracks or fraying.
The dust and pollen f ilter removes
pollen and dust f rom the outside air
the heating and cooling system
brings into the interior. It should be
replaced according to the time and
distance recommendations in the
maintenance schedule.
This f ilter should be replaced every
30,000 miles (48,000 km) under
normal conditions. It should be
replaced every 15,000 miles (24,000
km) if you drive primarily in urban
areas that have high concentrations
of soot in the air f rom industry and
diesel-powered vehicles. Replace it
more of ten if air f low f rom the
climate control system becomes less
than usual. Have the dust and pollen
f ilter replaced by your Honda dealer.
Maint enance
Drive Belt
Dust and Pollen Filter
Dust and Pollen Filter, Drive Belt
191
CCOOMMPPRREESSSSOORRBBEELLTT 0.30 0.41 in (7.5 10.5 mm)
0.33 0.43 in (8.5 11.0 mm)

Your car can overheat f or several
reasons, such as lack of coolant or a
mechanical problem. The only
indication may be the temperature
gauge climbing to or above the red
mark. Or you may see steam or
spray coming f rom under the hood.
In either case, you should take
immediate action.
The pointer of your car’s tempera-
ture gauge should stay in the mid-
range under most conditions. It may
go higher if you are driving up a long
steep hill on a very hot day. If it
climbs to the red mark, you should
determine the reason.
Keep the ends of the jumper cables
away from each other and any metal
on the car until all are disconnected.
Otherwise, you may cause an
electrical short.
If you do not see steam or spray,
leave the engine running and
watch the temperature gauge. If
the high heat is due to overloading
(climbing a long, steep hill on a
hot day with the A/C running, f or
example), the engine should start
to cool down almost immediately.
If it does, wait until the tempera-
ture gauge comes down to the mid-
point then continue driving.
If you see steam and/or spray
coming f rom under the hood, turn
of f the engine.
Saf ely pull to the side of the road.
Put the transmission in Neutral or
Park, and set the parking brake.
Turn of f the heating and cooling
system and all other accessories.
Turn on the hazard warning
indicators.
1. 2. 3.
If Your Engine Overheats
T aking Care of t he Unexpect ed
226 Steam and spray from an
overheated engine can
seriously scald you.
Do not open the hood if steam
is coming out.
Driving with the temperature gauge
pointer at the red mark can cause
serious damage to your engine.

CONT INUED
.....
Charging System Indicator . 229
..................
Checking the Fuses . 233
.....
Low Oil Pressure Indicator . 228
...
Malf unction Indicator Lamp . 230
..................
Overheated Engine . 227
...........................
Emergency Brake . 79
......................
Emergency Flashers . 65
......................
Emergency Towing . 239
.......................
Emissions Controls . 250 Engine
............................................
Belts . 191
....
Coolant Temperature Gauge . 58
Malf unction Indicator
................................
Lamp . 48, 230
..............
Oil, What Kind to Use . 167
...............................
Overheating . 227
............................
Specif ications . 244
.......................................
Starting . 135
..........
Engine Speed Limiter . 139, 143
......................
Ethanol in Gasoline . 248
.
Evaporative Emissions Controls . 250
...............................
Exhaust Fumes . 40
Expectant Mothers, Use of Seat
........................................
Belts by . 17
..................
Exterior, Cleaning the . 208 ............................
Fabric, Cleaning . 211
.....................................
Fan, Interior . 84
Features, Comfort and
................................
Convenience . 83
....................
Filling the Fuel Tank . 121
Filter
.........................
Dust and Pollen . 191
...............................................
Oil . 167
5-speed Manual Transmission ...............
Checking Fluid Level . 180
................................
Shif ting the . 136
.............
Flashers, Hazard Warning . 65
...................
Flat Tire, Changing a . 217
Fluids
Automatic Transmission .....................................
(CVT) . 178
..........................................
Brake . 181
.........................................
Clutch . 181
..............
Manual Transmission . 180
..................
Windshield Washer . 177
FM Stereo Radio ...................................
Reception . 112
.....
Foreign Countries, Driving in . 249
..........................
Four-way Flashers . 65 .................................................
Fuel . 126
......................
Fill Door and Cap . 121
...........................................
Gauge . 58
................
Octane Requirement . 120
...............................
Oxygenated . 248
........................
Reserve Indicator . 58
........................
Tank, Filling the . 121
.....................
Fuses, Checking the . 233
...............
Gas Mileage, Improving . 126
..........................................
Gasohol . 248
.........................................
Gasoline . 120
...............
Fuel Reserve Indicator . 48
...........................................
Gauge . 50
................
Octane Requirement . 120
........................
Tank, Filling the . 121
................
Gas Station Procedures . 121
Index
F
G
III

GaugesEngine Coolant ...........................
Temperature . 58
...............................................
Fuel . 58
...............................
Speedometer . 50
.................................
Tachometer . 58
Gearshif t Lever Positions
Automatic Transmission .....................................
(CVT) . 140
5-speed Manual .........................
Transmission . 136
..............................
Glass Cleaning . 212
........................................
Glove Box . 80
.............
Halogen Headlight Bulbs . 200
Hatch
.................................
Opening the . 71
...................
Open Monitor Light . 47
..............
Hazard Warning Flashers . 65
Headlights
............
Daytime Running Lights . 62
..................
High Beam Indicator . 47
........................
Reminder Beeper . 61
........
Replacing Halogen Bulbs . 200 ...................................
Turning on . 63
.............................................
Heating . 84
.............
High Altitude, Starting at . 135
.................
High-Low Beam Switch . 61
....................................
Hood Latch . 184
.......................
Hood, Opening the . 122
....................................................
Horn . 3
...........................
Hydraulic Clutch . 181
.................................
Hydroplaning . 151
...
Identif ication Number, Vehicle . 242
Ignition
..............................................
Keys . 67
...........................................
Switch . 69
............
Timing Control System . 251
.........
Important Safety Precautions . 6
.........
Indicators, Instrument Panel . 45
Inf ant Seats
..........
Tether Anchorage Points . 41
...................
Inf lation, Proper Tire . 192
.........................
Normal Driving . 193
...................................
Inside Mirror . 78
.............................
Inspection, Tire . 194
............................
Instrument Panel . 45 ........
Instrument Panel Brightness . 62
...........................
Interior Cleaning . 211
...................................
Interior Light . 82
........................................
Introduction . i
........................
Jacking up the Car . 217
.......................................
Jack, Tire . 217
................................
Jump Starting . 224
..................................................
Keys . 67
.......................
Label, Certif ication . 242
.................
Lane Change, Signaling . 63
..........................
Lap/Shoulder Belt . 34
....................
Lif etime Fuel Mileage . 55
Lights
....................
Bulb Replacement . 203
.......................................
Indicator . 47
.........................................
Parking . 46
..................................
Turn Signal . 63
Index
H I J K L
IV

CONT INUED
.....................................
Load Limit . 131
......
LOCK (Ignition Key Position) . 69
Locks
............................
Fuel Fill Door . 121
............................................
Hatch . 71
........................
Low Coolant Level . 125
.........................
Low Fuel Indicator . 58
...
Lower Gear, Downshif ting to a . 139
...
Lubricant Specif ications Chart . 244
.........................................
Luggage . 130
..................................
Maintenance . 153
...
Owner Maintenance Checks . 165
........................................
Record . 154
......................
Required Indicator . 59
..........................................
Saf ety . 154
....................................
Schedule . 156
.
Malf unction Indicator Lamp . 48, 230
...................
Manual Transmission . 136
........
Manual Transmission Fluid . 180
...............................
Meters, Gauges . 50
...................
Methanol in Gasoline . 248
..........................
Mirrors, Adjusting . 78 ..................
New Vehicle Break-in . 120
..................
NOTICE, Explanation of . ii
...............
Numbers, Identif ication . 242
...
Octane Requirement, Gasoline . 120
.........................................
Odometer . 50
...............................
Odometer, Trip . 51
Oil
........................
Change, How to . 169
......................
Change, When to . 158
......................
Checking Engine . 124
Selecting Proper Viscosity
......................................
Chart . 168
...........
ON (Ignition Key Position) . 70
Onboard Ref ueling Vapor
....................................
Recovery . 250
.........................
Opening the Hatch . 71
..
Operation in Foreign Countries . 249
..............................
Outside Mirrors . 78
....................
Overheating, Engine . 227
.......
Owner Maintenance Checks . 165
.........................
Oxygenated Fuels . 248 ..............................
Paint Touch-up . 210
..............
Panel Brightness Control . 62
...........................................
Parking . 147
.................................
Parking Brake . 79
Parking Brake and Brake
.................
System Indicator . 46, 232
..
Parking Over Things that Burn . 252
.............................
PGM-FI System . 251
..................
Polishing and Waxing . 210
............
Pre-Drive Saf ety Checklist . 11
.........
Pregnancy, Using Seat Belts . 17
............................
Protecting Adults . 12
...
Additional Safety Precautions . 18
.....
Advice f or Pregnant Women . 17
........................
Protecting Children . 19
.......
Protecting Larger Children . 29
.........
Protecting Small Children . 26
Using Child Seats with
.....................................
Tethers . 33
Index
M N O
P
V