2000 HONDA S2000 service schedule

Use this schedule if your vehicle is MAINLY driven in any of the following Severe Conditions, or normally driven in Canada; otherwise use the Normal Schedule. Service at the indicated distance or time, whichever comes first. Do the items in A, B, C, D as required for each distance/time.
3,750 mi/6,000 km/6 mos Do items in A. 7,500 mi/12,000 km/- Do items in A, B. 11,250 mi/18,000 km/-
Do items in A. 15,000 mi/24,000 km/1 yr Do items in A, B, C. 18,750 mi/30,000 km/- Do items in A. 22,500 mi/36,000 km/1% yrs Do items_in_A,Jt .. ~--------· ---~~---26,250 mi/42,000 km/-Do items in A. 30,000 mi/48,000 km/2 vrs Do items in A, B, C, D. 33,750 mi/54,000 km/-
Do items in A. 37,500 mi/60,000 km/2'/z vrs
Do items in A, B. 41,250 mi/66,000 km/-
Do items in A. 45,000 mi/72,000 km/3 yrs DReplace brake fluid. DReplace coolant. Do items in A, B, C. 48,750 mi/78,000 km/- Do items in A. 52,500 mi/84,000 km/3'/z vrs Do items in A, B. 56,250 mi/90,000 km/-
Do items in A. 60,000 mi/96,000 km/4 vrs _Do items in A, B, C, D. 63,750 mi/102,000 km/-
Do items in A. 67,500 mi/108,000 km/41!2 yrs Do items in A, B. 71,250 mi/114,000 km/-
Do items in A. 75,000 mi/120,000 km/5 yrs ']Replace coolant. Do itefY!S_lll_ A,_B_,_(:, -~--~--78,750 mi/126,000 km/-
Do items in A.
Note: • Check engine oil and coolant at each fuel stop. • Check and adjust valve clearance, cold engine, if noisy.
·--~
··-
Severe Conditions:
A
B
c
Driving less than 5 mi (8 km) per trip or, in freezing
temperatures, driving less than 10 mi (16 km) per trip.
Driving in extremely hot (over 90°F/32°C) conditions.
Extensive idling or long periods of stop-and-go driving. Driving in mountainous conditions.
Drivin_gon muddy, dusty, or de-iced roads.
[]Replace enqine oil and filter. Dlnspect front and rear brakes. DC heck tire inflation and condition. Dlnspect tie rod ends, steering gear box and boots. Dlnspect suspension components. Dlnspect driveshaft boots. ORe place air cleaner element. ']Check parking brake adjustment. ']Lubricate all hinges, locks and latches. ']Replace rear differential fluid.
CONTINUED
Maintenance 151

Engine Oil
The oil container may also display
the
API Certification seal. Make sure
it says
"For Gasoline Engines."
158 Maintenance
The SAE numbers tell you the oil's
viscosity or weight. Select the
oil for
your car according to this chart.
60
. 10 20
" ~ c" ' -c '
AnlbielltTertlperature
An oil with a viscosity of lOW-30 is
preferred for improved fuel economy
and year-round protection in your
Honda.
You may use a 5W-40 oil if
the temperature in your area goes
below oaF (
-20°C).
Synthetic Oil
You may use a synthetic motor oil if
it meets the same requirements
given for conventional motor
oil:
energy conserving, a service
classification of
SJ, and the proper
weight as shown on the chart. When
using synthetic
oil, you must follow
the
oil and filter change intervals
given
in the maintenance schedule.
Additives
Your Honda does not need any oil
additives. Purchasing additives for
the engine or transmission will not
increase your car's performance or
longevity.
It only increases the cost
of operating your car.

Changing the Oil and Filter
Always change the oil and filter
according to the time and distance
(miles/kilometers) recommenda­
tions
in the maintenance schedule.
The oil and filter collect contami­
nants that can damage your engine
if
they are not removed regularly.
Changing the
oil and filter requires
special tools and access from
underneath
the car. The car should
be raised on a service station-type
hydraulic lift for this service.
Unless
you have the knowledge and proper
equipment, you should have this
maintenance done by a skilled
mechanic.
1. Run the engine until it reaches
normal operating temperature,
then shut it off.
2. Remove the engine oil fill cap.
Remove the
oil drain bolt from the
bottom of
the engine. Drain the oil
into an appropriate container.
Engine Oil
3. Remove the oil filter and let the
remaining
oil drain. A special
wrench (available from your
Honda dealer) is required to
remove the filter.
4. Install a new oil filter according to
instructions that come with it.
CONTINUED
Maintenance 159

6-speed Manual Transmission Fluid
Check the fluid level with the
transmission at normal operating
temperature and the car sitting on
level ground. Remove the
transmission filler bolt and carefully
feel inside the bolt hole with your
finger.
The fluid level should be up
to the edge of the bolt hole.
If it is
not, add Genuine Honda Manual
Transmission Fluid (MTF) until it
starts to run out of the hole. Reinstall
the filler bolt and tighten it securely.
168 Maintenance
If Honda MTF is not available, you
may use an
API service SG, SH or SJ
grade motor oil with a viscosity of
SAE lOW-30 or lOW-40 as a
temporary replacement. An
SG
grade is preferred, but an SH or SJ
grade may be used if SG is not
available. However, motor
oil does
not contain the proper additives and
continued use can cause stiffer
shifting. Replace as soon as
convenient.
The transmission should be drained
and refilled with new fluid according
to the time and distance recommen­
dations
in the maintenance schedule.

Check the fluid level with the
differential at normal operating
temperature and the vehicle sitting
onlevelground.Removethe
differential fluid filler bolt and
washer and carefully feel inside the
bolt hole with your finger.
The fluid
level should
be up to the edge of the
bolt hole.
If it is not, slowly add fluid
until it starts to run out of
the hole.
Use a SAE 90 viscosity hypoid gear
oil, API service classified GL5 or
GL6 only, in the differential.
Put a new washer on the filler bolt,
then reinstall the filler bolt. Tighten
it securely. Tightening torque:
33 lbf·ft (45 N·m, 4.6 kgf·m)
The differential should be drained
and refilled with new fluid according
to the time and distance
recommendations in the
maintenance schedule.
Differential Fluid
Maintenance 169

Index
Opening the Hood ......................... 118 Protecting Small Children .......... 26 Replacing Seat Belts After a
Opening the Trunk .......................... 66 Crash ............................................. 34
Operation in Foreign Countries
... 249 R Restraint, Child ................................ 19
Outside Mirrors ............................... 79 Rotation, Tire ................................. 188
Overheating, Engine ..................... 223 Radiator Overheating .................... 223
Oxygenated Fuels .......................... 248 Radio Sound System ........................ 94 s
Rear End Towing ........................... 238 p Rear Lights, Bulb Replacement ... 198 Safety Belts ......................................... 8
Rear
View Mirror ............................. 79 Safety Defects, Reporting ............. 258
Paint Touch-up ............................... 206 Reclining the Seat-backs ................. 68 Safety Labels, Location of .............. 40
Panel Brightness Control ............... 52 Recommended Shift Speeds ........ 134 Safety Messages ................................ ii
Parking Brake .................................. 80 Recovery Vehicle, Emergency Seat Belt, Additional Information .. 33
Parking Lights .................................. 51 Towing ........................................ 238 Lap/Shoulder Belt ....................... 33
PGM-FI System .............................. 251 Reminder Lights .............................. 43 Seat Belt Maintenance ................ 34
Polishing and Waxing ...................
205 Remote Transmitter ........................ 63 Seat Belt System Components ... 33
Power Replacement Information Seat Belts ............................................ 8
Door Locks ...................................
62 Air Cleaner ................................. 172 Cleaning ...................................... 207
Engine, Specifications ............... 244 Engine
Coolant.. ......................... 163 Maintenance ................................. 34
Mirrors .......................................... 79 Engine Oil and Filter ................. 159 Reminder Light and Beeper ....... 44
Windows ....................................... 69 Fuses ........................................... 232 System Components .................... 33
Pregnancy, Using Seat Belts .......... 17 Light Bulbs ................................. 194 Use During Pregnancy ................ 17
Protecting Adults ............................. 12 Schedule ..................................... 146 Seats, Adjusting the ......................... 68
Additional Safety Precautions .... 18 Spark Plugs ................................. 17 4
Serial Number ................................ 242
Advice for Pregnant Women ...... 17 Tires ............................................ 189 Service Intervals ............................ 146
Protecting Children .........................
19 Wiper Blades .............................. 180 Service Manual .............................. 259
Protecting Larger Children ........
29 Service Station Procedures .......... 117
VI