2000 HONDA CIVIC 123

MEASUREMENTSTANDARD INFWIEngine oilCapacityf (uS qt, lmp qt)
Inner-to outer rotor radial clearancePump body-to outer rotor radialclearancePump body to-rotor axial clearance
4.8 (5.1, 4.2) for eng;ne overhaul4.0 (4.2, 3.5) for oil change, ;ncludin3.7 (3.9.3 3)for dil .h,nde '^,irh^,,rg oilfilter
Oil pump0.04 - 0.16 {0.002 - 0.006)0.10 - 0.19 (0.004-0.007)0.02 0.07 10.001 ,0.003)
0.20 (0.008)
0.20 {0.008)0 15 {O OO6iRelief valvePressure setting 176"F (80.C)kPa (kgflcm,, psi) at;dteat 3,000 rpm70 (0.7, 10) min.340 (3.5,50) min.
Standards and Service Limits
Engine Lubrication (B16A2 engine) (cont,d) - Section 8
Cooling - Section 10
L,
L.
MEASUREMENTSTANOARO {NEW)RadratorCoolant capacity t 1US qt, tmp qt)including engine, heater, cooling line andreservotr
Beservoir capacity:0.4 f {0.42 US qt, 0.35 lmp qt)
81642 engine5.0 {5.3, 4.4) for overhaul4.5 (4.8, 4.0) for cootant changeD16Y5, D16Y7, D16Y8 engines:M/T: 4.2 (4.4, 3.7)for overhaul3.1 (3.3, 2.7) for coolant changeA"/T: 016Y74.1 (4.3, 3.6) for overhaul3.0 (3.2, 2.6) for cootant changeDl6Y84.3 {4.5, 3.8)for overhaul3.2 (3.3, 2.8) for cootant changeCW: 4.3 (4.5,3.8)for overhaul3.2 (3.3, 2.8)for cootant chanqeRadiator capOpeningpressure kPa(kgl/cm,,psi)
Start to open .F (.C)Fully open "F ('C)Valve lift at fulty open
93 123 (0.95- 1.25, 14 18)
169 - 176 (76 80)194 (90)
8.0 (0.31)min.
196 - 203 191 95)Subtract 5 - 15 {3 - 8) from actual ,,ON,, temperature
Thermostat
Cooling fanThermoswilch 'ON" temperature F r.C,Thermoswitch "OFF' lemperature .F ( C)
L
3-6
L,

Design Specifications
ITEMMETRICENGLISHNOTEDII/IENSIONS Overall Length2 door Coupe/4 door Sedan (,96 98)('99,'00)2 door Hatchback (,96, ,97)
('98 - 00)OverallwidthOverall height 2 door Coupe/2 door Hatchback4-door SedanWheelbase
I Track FronvRearGround ClearanceSeatiog Capacity
4,445 mm4,450 mm4,170 mm4,180 mm1,705 mm1,375 mm1,390 mm2,620 mm1,475/1,415 mm150 mm
175.0 in115.2 in164.2 in164.6 in67.1 in54.1 in54.7 in103.1 in58.1/58.15.9 in
WEIGHT (USA)Gross Vehicle Weight Raring (GVWR)2 door Coupe HX M/T, DX M/THX CVI ('96)HX CVT ('97,'98)HX CVT ('99}DX A,/T (96 98,DX A"/T ('99, '00)
EXSi2 door Hatchbacl CX. DX r'96, 97,cx, DX ('98)cx (,99, ,00)
DXM/Ti'99,00iDX A/T ( 99, 00,4 door Sedan DX, LX, DX-VEX
3,290 tbs3,320 tbs3,330 tbs3,360 rbs3,290 rbs3,310 tbs3,440 tbs3,480 tbs3,285 tbs3,290 tbs3,290 tbs3,290 tbs3,330lbs3,330 tbs3,460 tbsWEIGHT (CANADA)Gross Vehicle Weight Bating (GVWR)2-door Coupe DX ('96)DX ('97 00)DX-Gsi 1,96)si ('97 - 00)siR2 door Hatchback CX, CX,G ('96)cx, cx,G 1,97)cx-G (,98)
cx ('98 00)DX M/T, SE M/IDX A,/T, SE A,/T4 door Sedan LX, LX VEX M/IEX A/T
1,500 ks1,510 kg1,510 kg1,560 kg1,570 kg1,590 ks1,495 kg1,505 kg1,510 ks1,510 ks1,510 kg1,530 kg1,510 kg1,510 ks1,540 ksENGINEType
Cylinder ArrangementBore and Stroke D16Y5, D16Y7, Dt6y8B 1642DisplacementD16Y5, D16Y7, Dl6Y881642Compression Ratio D16Y5, D16y7D16Y8816A2Valve TrainLubrication SystemOil Pump Displacement at 6,800 engine rprnD16Y5, D,l6Y7, D16Y881642Water Pump Displacementat 6,000 engine rpm 016Y5, D16Y7, D16y8816A2Fuel Required D16Y5, D16Y7, D16y8
816A2
Water-cooled, 4-stroke SOHC*1, SOHCVTEC"', SOHC WEC.E'3, DOHC VTEC{gasoline engineInline 4 cylinder, transverse2.95 x 3.54 in3.19 x 3.05 in97.0 cu-in97.3 cu in9.49.610.2Belt driven, 4 valve per cylinderForced and wet sump, trochoid pump
33.4 f (35.3 US qt, 29.4 lmp qt)/minute43.8 | (46.3 US qt, 38.6 lmp qt)/minute
125 { {132 US qt, 110 lmp qt}/minute140 f {148 US qt, 123 lmp qt}/minuteUNLEADED gasoline with 86 PumpOctane Number or higherPremium UNLEADED gasoline 91 PumpOctane Number or higher
75.0 x 90.0 mm81.0 x 77.4 mm1,590 cm31,595 cm3
*1: D16Y7*': D16Y8*3: D16Y5*': 816A2
STARTEBType/MakeNormal OutputNominalVohageHour RatingDirection of Rotation
Gear reduction/MITSUBA1.0 kw, 1.2 kw12V30 secondsClockwise as viewed from gear end
5-Z.V
-

Connecting Rod Bearings
Clearance
Remove the connecting rod cap and bearing half
Clean the crankshaft rod iournal and bearing half
with a clean shop towel.
Place plastigage across the rod journal.
Reinstall the bearing half and cap, and torque the nuts.
Torque
Bl6A2 engine:
40 N.m (4.1 kgl.m, 30 lbf'ft)
Dr6Y5, D16Y7, D16Y8 enginss:
31 N'm (3.2 kgf.m, 23 lbf ftl
NOTE| Do not rotate the crankshaft during inspection.
Remove the rod cap and bearing half and measure
the widest part of the plastigage.
Connecting Rod Bearing-to.Journal Oil Glearance:
816A2 engine:
Standard lNewl: 0.032 - 0.050 mm
10.0013 - 0.0020 in)
Service Limit: 0.06 mm 10.002 inl
D16Y5, D16Y7, D16Y8 engines:
Standard lNew): 0.020 - 0.038 mm
(0.0008 - 0.0015 in)
Service Limit 0.05 mm 10.002 inl
'1.
4.
lf the plastigage measures too wide or too narrow'
remove the upper half of the bearing, install a new,
complete bearing with the same color code (select
the color as shown in the right column), and
recheck the clearance.
CAUTION: Do not lile, shim, or scrape the bearings
or the caps to adiust clgarance.
lf the plastigage shows the clearance is still incorrect.
try the next larger or smaller bearing (the color listed
above or below that one), and check clearance again.
NOTE: lf the Droper clearance cannot be obtained
by using the appropriate larger or smaller bearings,
replace the crankshaft and start over.
PLASTIGAGE STRIP
\
7.
7-11
Selection
CAUTION: lf the codes are indecipherable because of
an accumulation of dirt and dust, do not sclub them
with a wile brush or scraper. Clean them only with sol-
vent or detergent,
Connecting Rod Code Location
Numbers have been stamped on the side of each con
necting rod as a code for the size of the big end Use
them, and the letters stamped on the crankshaft (codes
for rod journal size), to choose the correct bearlngs
Half of number ls
stamped on bearingcap and the otherhalf is stamped onrod.
Bearing ldentilication
Color code is on theedge ofthe bearing.
lfA--;T] |
lle"'tt l;llcorlll ll
I lD;;ilril |l-l
Larger brg end bore
Smaller Smallerrod bearlngjournal (thicker)
---------------- Smallerbearing{thrcker)
RedPinkGreen
PinkGreen
GreenErownBlack
GreenBrownBlackBlue
1234
Connecting Rod Journal Code Locations (Lettels)

Cap Testing
1. Remove the radiator cap, wet its seal with engine
coolant, then install it on the pressure tester'
RADIATOR PR€SSURE TESTER(CommerciallY available)
RAOIATOR
(for 32 mm neck' low Pro{ile)
Apply a pressure of 93 - 123 kPa (0.95 - 'l 25 kgflcm''
14 - 18 psi).
Check for a drop in Pressure.
lf the pressure drops, replace the cap
I
t
ADAPTOR
Testing
LWait until the engine is cool, then carefully remove
the radiator cap and fill the radiator with engine
coolant to the top of the tiller neck
Attach the pressure tester to the radiator and apply
a pressure of 93 - '123 kPa (0.95 - 1.25 kgflcm', 14 -
18 psil.
RADIATOR PRESSURE
TESTER
lCommerciallY available)
ADAPTOR(for 32 mm neck, low Profile)
Inspect for engine coolant leaks and a drop In pres-
sure.
Remove the tester and reinstall the radiator cap
NOTE: Check for engine oil in the coolant and/or
coolant in the engine oil.
10-9

c1t7
r'ffi]
f'TBLir-llO BLX,YEI Il6lEtu^tHr__-l
c125
ffi
16lwrrin+o' tliSlcFN/BLK I16T8LK^'Er-- l
-.,IBaK,r /Hr. I
c141*'
___l:t_
l-lrl
I ' LT GRNA/VHT I
f€,]-BLK,rEf-__l
cl16c1t5cl11
c128.'
ffi
1618r-uf/EL-_]
161-cfl,avHr -l
cl45rrc
Ft_
l-,T,ITd
t_-Ttli I
c127*'
fr
IFFEc'--__l
ftlwHn-'_l
-c,1*
t-El-rl1 I 2l 3l
l.l
'ul
16lvvrrr/BtK---.llglcnN/BrK, IlO YEvBru I16r lsrK' IET- --
f+plr-, -_l
c118"
ffi
trl-clrl---]latl IBLU, I
c126*'
ffi
fOTwHn-_-llOlREo. I
:.trn
.EL
[tT,l.l
v
I i wHl/8tK IlETc RNi BLF--l
ET-YtrrrruBiu-__-l
q]54't
r,f,"|
I i IBLK4/VHT IlOlsLK I
IO LGRN/RED I
c112
fr
c120
tdl cnN/YEt--l
NOTE: . Different wires with the same color have been given a number suffix to distinguish them (for example, YEUBLK'
and YEUBLIC are not the same).
. O: Belated to Fuel and Emissions System'
. - Connector with male terminals (double outline): View from terminal side
- Connector with female terminals (single outlins): View from wire side {cont'd}
c121*'
ffi
c123
ffi
c1a0rt
fr
l6lgrf,---_-lIOIREB I
c13!,.f
E
c122
iYEUGFNoBLU5REO!8L(,
YEL'98tu
510BLK/YEL
c351
1 1-55

c114
ffi
c109
r'ff;t
Flo-'u Il! veugLx' I
ftFwatu;'--l
c123
ffi
cl18 {A/T}
F lrl
IOIGFN' I
16l Barr-- - l
cl17
r'ftr
fdl'.,c---_ll? BLKtEt Ib]-Br.-^^,Hr-_-l
cl24 (A/Tl
fr
lTlzRN,tsril I
l6l-YtL, ---l
lolFED/wHr I
fd-cRN/8tK'_]l
cl28lA/T)
F l,l
IC ISLU/YEL I
161-Grr.,*1/Hl I
Gt54*,
F1Eh
l'l3LlJ
l6ElKl,,/Hr-l
I6TBLK -_l
IO LGRN/ RED I
Different wires with the same color have been given a number suffix to distinguish them (for example, YEUBLK1
and YEUBLK' are not the same).
O: Related to Fuel and Emissions System.
- Connector with male terminals (double outline): View from terminal side
- Connector with female terminals (single outline): View from wire side
c141r16
ffi
lO LT GBN,.VVHT I
161-BIK/YEL-_--l
c121 |AFI
ffi
16lwHr--llOlREp I
cl26 (A/Tl
fr
fol;nrr-_-llOlREo. I
c125
ffi
l3l.l
lTltHr/R$' -l
loiiED/vEr--lbfBaK/vEL- l
f!]BLX,1,,iHT'-l
NOTE: o
aL
tYEUGNN8LU5oBEF
@CRN:BIK3YELl9BLU
5108LX]"/E!
1 1-59

cl17
l1 2l3l
|6l;LKr-----llOlELK,^/EL II tlsLU^/vHl ll
c112
t1l2l
121+'
F-il1 2l
c120r3
l1l2l3l1lffill5l6l7lEl
l6TE"^r"". 1ItT"Eu I
Clitl
fr
l6lir cFlr/wnT IITIBL/./YEL I]l
c147r3
fr
l6FEDl.ryxF_lfdvi Hr. - l
l6EnNta, --.l
Different wires with the same color have been given a number suffix to distinguish them (for example, YEUBLKT
and YEUBLK' are not the same).
o: Related to Fuel and Emissions System- Connector with male terminals (double outline): View from terminal side
- Connector with female terminals (single outline): View from wire side
c351
(cont'd)
11-67
18BLK
oYEUELKIBLK'
YEVBLK]BLKI
YEUBLKIELKI
oYEUELKI0,ALKI
oYEVBLK'(9BLK'YEVBLKIBLKJ
c123
l1 2l
m
FiiTwHr. --l
l€ cnN,,srr, Ilt|sLKrEllllolTlx,wH-r' ll
c140
A
w
16lBLLliBLa--lI6ELK' --_l
c122
a
v
IoFED //Hr--l
1olcnlriBirc I
c145.3
t./t2ts allffil5lcl7l8l
C35/a'1
f,ftf
16l BLK/wHr I16lgl( I-l
16lGBNinEo l
J.YEUGFNoBLU'aREDl.11ALKIoYEL'5t08LK/YEL
c118*'
l1 2l
c125
rffil
trtr
Iij wHri FEDi_lI a IGFN/BLK, I
I9 BLK,ryEL I
l6ELK,wHr I
c143*3
ffi
ldElK ^i Hrr_l
trlwirmEp, I
c126r' C.127.' c128r'
ffiffiffi
ffi;F---- FlREo,-___l El;*lvr.ll,IRFD' I lr lwHr' I lerlcRN/wHrr I
c144*3 c145'3
_,q. ,---t
/-----f 11 2l
lr t2 3J
\-/
I J IWHr/BLK I l(1-]l68N, I
|-|cFN,RLr<, I l6tFtj--reDtsLu ]
FIYEUR.I --1
c352
1l5l Lr/H-1-_rtoltrl l5l0 /it El
it]GRN/BLK]
o@PNI(BLKGRN/YEL3(,(9PNVBLU
2GRN6BLX'EL13 WHT/BLKoi,9oaL&a€D

c l16cl10c115
Different wires with the same color have b6en given a number suffix to distinguish them (for example, YEUBLKl
and YEUBLK'are not the same).
O: Related to Fuel and Emissions System.
c123
ffi
c11a
@
cl20
..+, 1
l+'.1'+:l
c109
r'ft]
flofr-N _-l
ItIYEUBLK, IIEIBLvBLU' I
c141
ffi
16T Lr cRN^/v-H;l
161-BrxtEL-__l
c11E tA/Tl
l- l,l
lOlGBN, I
f6lBr-r,--l
clr7
F1ftr
@fBLK-_-lI a BLKTYEL I
|ol-Balro/Hl -l
c121lAtfl
l- lrl
McnN/BLK' I
f4tEr-- __-l
c125
rfrr
Etr
I t lwHri REo' IItrIRED/YEL, _-l
blBLK Ea -l
ftl BLK^tHi'l
- Connector with male terminals (double outlinel: View from terminal side
- Connector with female terminals (single outlin€): View from wire side
NOTE: .
a
a(cont'd)
11-71
o8TK?YEL.!lGBN/8TKI2BLICYELoGffN/8TK1BLK/YEL@GNN/aLK?
(tBLfiELoGRN/BLKBLK/YEI12BLKJ^/EL!3GRN/BLX'8LK/YELGRN/BLK'
c128 (A/Tl
_El-
I'l ,l
IOIBLUryEI' I
161-crNalrHr' -l
(xlsarr
Ftr.T
l6ELffiHr-]
tr18!( -___-l
lglcRN/REp I
c12t l[lTl
ffi
EIWHF
_l
l(?lREp, I
c126 lA/Tl
fr
EIwHI-__-ll€) lFEp5 I
c352c351