2000 HONDA CIVIC steering

6. Install the new SRS unit.
NOTE: Do not reuse a torx bolt that has red
threads. Replace the bolt with a new one.
)
7.
TORX BOLTS9.8 N.m l'1.0 kg{.m, 7.2 lbf.ft}Use a Torx T30 bit.
Connect the SRS main harness l8P connector to the
SRS uniu push it into posjtion until it clicks.
Install the SRS unit covers (ri9ht and left). Make
sure the covers snap together in the middle.
8.
TORX BOLTS9.8 N.m 11.0 kgf.m, 7.2 lbf.ft)U3e . Torx T30 bit.
SRS MAIN HARNESS
)(l
9.
10.
't2.
Reconnect the driver's aibag 2P connector to the
cable reel 2P connector, then reinstall the access
panel on the steering wheel.
Reconnect the tront passenger's airbag connector
to the SRS main harness.
Reconnect the battery positive cable, then the nega
tive cable.
After installing the SRS unit, confirm proper system
operation: Turn the ignition switch ON (ll); the SRS
indicator light should come on for about six seconds
and then go oif.
11.
24-77
.-

Ground-to-Components I ndex
f.,lONOTE: All ground wires are BLK unless otherwise noted.
GroundPageComponents or Circuit Grounded
Battery (BLKYEL)
Steering pump bracket
t+-rg ITransmission housing
l
G101
(-1)
G101
(-2)
14-2
and
14-3
ano
14-1
Powertrain or engine control module (PG1 and pG2 are BLK: LG1 and LG2 are
BRN/BLK), EGR control solenoid valve (CW, EGR valve and lift sensor (Dt6yS enginewith M,/T), Engine coolant temperature switch, pGM-Fl main relay, power steeringpressure switch (USA), Primary HO2S (D16Y5 engine with l\/,/T), Vehicle speed sensor,VTEC pressure switch (D16Y5/D16Y8 engines), CKF sensor (BRN/BLK), Transmission
control module (CYf) (Pc1 is BLK: LG1 is BRN/BLK)
Shielding betvveen the PCM or ECM and these components (all have BRN/BLK wires):
CKF sensor, TDC/CKP/CYP sensor. Primary and secondary heated oxygen sensors.
Knock sensor (CWDl6YB engine), Mainshaft speed sensor (AiT except CVT),
I Countershaft speed sensor (A/T except CVf)
Shielding between the TCM and these components (CVT) (all have BRN/BLK wires):
Drive pulley speed sensor, Driven pulley speed sensor, Secondary gear shaft
speed sensor
Powertrain or engine control module (PG1 and pG2 are BLK; LG1 and LGz are
BRN/BLK), EGR control solenoid valve (D16Y5 engine), EGR valve (Dt685), Engine
coolant temperature switch, Fuel pressure regulator shut-off solenoid valve (D1685),
PGM-FI main relay, Power steering pressure switch (USA), Vehicle speed sensor, VTECpressure switch (All except D16Y7 engine), CKF sensor (A

except 81642) (BRN/BLK)
Shielding between the PCM or ECM and these components (all have BRN/BLK wires):
CKF sensor, TDC/CKP/CYP sensor, Primary and secondary heated oxygen sensors,
Knock sensor (All except D16Y7 engine), i/ainshaft speed sensor (Arf except CW),
Countershaft speed sensor (A,/T except CVf), Drive pulley speed sensor (CW), Drivenpulley speed sensor (CVT), Secondary gear shaft speed sensor (CVf)
I Badiator fan motor, Right front parking/turn signat tight, Right headtight
G20214-4I Cruise control actuator, Left front parking/turn signal lights, Left headlight, Rear window
I washer motor, Windshield washer motor, Washer fluid level switch (,99-'00 Canada)
G401| +-o
and
14-7
Accessory power socket, Brake fluid level switch, Clutch interlock switch (M/T), Clutchswitch (lillT with cruise/D16Y5 engine with MfD, Combination wiper switch (Z wires),
Cruise control main switch, Cruise control unit, Dash lights brightness controller, Data
link connector, Daytime running lights control unit (Canada), Gauge assembly, Horn('96-'97 models), Integrated control unit, Interlock control unit (ArI), Keyless door lock
control unit ('99-'00 models with keyless), Moonroof close and open relays, Moonroof
switch, Park pin switch (A/r), Power window relay, Rear window defogger relay, Rear
window defogger switch ('96-'98 models), Steering lock, Stereo radio tuner (,96-,98
USA: LX, EX, and HX), Turn signal/hazard relay, Windshield wiper motor.....plus
everything grounded through G402
6-6

I
t
I
UNDER-HOODFUSE/RELAY BOXFUSE 52HO3 ,9IO? LTt3a
FUSE 53SATAAD10A
T102PHOTO 9l--
S€e PowerDistrib$ion,page 10-13.
WHT/REDT101PI1oIO 25
I
IJ
I
I
FUSEofiro{{oa
ALTEBNATORPage 22
nI
I
t
--1 UNDER.
sFUSE 55IIEATER MOTONatla
r^-::r BLowER| t,omacl I MoToR
i lF5:ftL--J or 50-1Ptaofo9
FUSE 55(co{DEtsER fAx}204
FUSE 57cooutag FAr204
r^-::I RADIATOR
l*"*!F*x.L--J paoro p
HOODFUSE/NELAYBOX
UNDER-DASHFUSE/RELAY BOXPHO|O 58
FUSE 19AACK UPLlalni75A
FUS€ 15ALIIFI.IATORsF sErson7.5A
\
I
I
If
r--1 coN- r--11'/C COM-lContactt DENSER I Contactl PFESSOR
i i[f*, i iFLug"L--J Page 63 L--J Page 62
To Fus€ l, 2, and 6,see oaos lGl3. STEERINGLOCK
\
l,ut-a--- ---------J
gLXTYEI
FUSE 23(sRs)1(rA
Phofo 10
See PowerDistribdion,pagos 10€and 10-7.
FUSE 3tm w|PEain wAsr{ER}10A
PHOTO 10
See PowerDistribution,page 10-6.
FUSE 24(P,ry AEUn(s/n QELAY)
FUSE 13FU€L PUIIP(sns uRrT)15A
See PowerDisaibution,page 10-3.
FUSE 14{cFrrsE corrtRoL}{rcYLESS)
c913I
I
FUSE9 ,
FUSE 12IURI{UCHTS7,trA
) | , i ]si"ii:-' r|r::::---'--- J/--_-r
i::{;iil i i".ii.l ,#,;:|'-
i-:'ff1tu;.,,, i *=ft;;***
See Powsr Distribution,pages 10-2 and 10-3.
* = '99-'00 models with D16Y7/D16YB
Sea PowerDistribuiion,page 10-4.
:! iii'^': i i lB1%"f;
i L-=r -','lo' i !.---i..-^- ii orsrnrauron i i DtsrRtBUroR :' Page 20 Page 20 or 20'1 '
%[-#
I pHOfO 44 PHO|O 44
1Gl

Ground Distributioh (conrd)
)
- G401
NOTE:
To G402on page14-5.
WINOSHIELOWIPERMOTORPage 91-1
DAYTIMERUNNINGLIGHTS
99.!rRoL cLUrcHuNr I swtTcH:?99^ Pases 23-5and 34-3vtEw 66 PHA|A 55
I
I
INJECTORCONTROLMODULEPage 25-1
I
I
3
. Wires shown without color codes are black.
o On Coupe and Sedan models, G401 is represented by ring terminals.
tl
tl
INTER.LOCK6611p99 PARKUN|T PINpaoe j38 SWITCHor ige_t Page 138PHoro6s of 138-1vtEw 26 PHOfO /7r-1 r-'t
tttl
CLUTCHINTER-LOCKSWITCHPage 21-2
ll
ll
ttl
rll
I
Itttl
'Ll;
I
n
t
M/T with 01685Cruise/D16Y5enginewith M/T
BRAKEFLUIDLEVELswtTcHPage 71ot 71-1
tl
tl
DOOR LOCK .CONTROLSTEERINGLOCKPage /3
tl
tl
UNITPage 130-12 ;
ttl
tt:
models
RNte 40
I
I
(
I
I czor
l'i1l?,
'97 mo
HORNPage 4
I
I
NFnl
s 9c.Plv'
BLK/RED
t
IJ;--
',f-l
DATA LINKCONNECTOR(DLC)Pages 23-4,24-4,25 4,44-1, and 47
30
14-6
G401

- Gl, G2, G3, and G403
BATTERY
tl
tl
ABSPUMPMOTORSTEERINGPUMPBRACKET
I
I
TRANS-MtsstoN
I
I
PagePHOTO
I
44-5
I
IJ
I
I
T3PHOTO 20
I
I
r4Ptlofo 13
IL
BFI{
1
PHO|O 20G3PHOTO 13
c360
!. c403G1
- G751, G771, and G801
CONDENSERFANi,OTORPage
,l
I
I
I
SRS UNITPage 47PHO|OT0vtEw 51
I
tlL------J
17
c753
G751
GFY (20)OTGFNGFY (r9)or GFN
!. G801
14-13

lgnition System
- All Dl685 engines; All '99-'00 Models except Dl6Y5 with M/T
NOTE: For Service Check Connector details, see page 24-4 (except D1685) or 25-4 (D1685).
STEERINGLOCKPOWERTRAIN
lm- sii.- s*- iffffiEgr
I '8f", '3#n '3#n | (Pcn' or EcM)
L------ -----J Wro 86
',L_I__J,
!l---+--l !
'i---
j----i'
fl '","?siii,xl
I I I
i*n"'."
-"1 "-l '-l *"-^lr";J
I I I ='i.{i31i",,-
All except D1685D1685
gLK.Yer t
u l9f#'
fi
"*1,[
F,*';.,
!'T-f*-'i"i! {F+ Distdbution,
LJ_gg'n'_
i.x,r
9'x*"
-.t
iF--Hs-,mT-l
ll pase lGi. I
l( FUsEe I
!Lig::___J
.I UNDER-I DASH
a FUSE/
! RELAY- BOX
1 Y C419 UNDER-^,ol',lill,l?"u' rlir?IA) RELAYBOX
.t0
BLKI/EL
10(D16Y7/D16Y8 s)
c101
PHO|O 142 lA1685)vlEw 2a
c120
vtEw 29OFN/ALULT BLU orALU/GRN
BLU,^VEL
c120
vtEw 29
ELKWHT/BLU
7
FED
c21c9
ALK
c30
;;--;;---o;;;lSensor Sonsor Sensor I
POWERTRAINor ENGINECONTROLMODULE(PCM or ECM)
ground ground gtound
L ------ -----J PHoro 36
Sec!l|dary
Sparh Plugs
20-2

PGM-FI (All '9G'98 Models except D16B5; '99100 D16Y5 with MfI)
1@
i-l-,;;*--
L--LT-:
UNDER-HOODFUSE/RELAYBOX
'f 9;u;, '11 ,c,i"',3,wHT'REo I rrEt3' see Powar wHr/cFN I vrF 2/
aaa4 Distdbution, ll wxTcnr See power
wnineo I page 1S10. art Distibution,
r I ,r"ro"" ! Page 10-13
DATA LINK , ICONI€CTOR (DLC) (With Cruise Controt i) |vtEw 48 rrF.t BRAKE SWtTCh
" ""f ":T
-C-l*
ffif{"s1 ** ".,*.-,lf,1i
Fi3:{i'r'rs35:
,""oL.rr. I *-l I
oauwxr
l
ffi;"i;ii" I t------j F=Ln&1?i,inars'.rqr
i
-----=ffi, o"n,n", I H ;,?fl:&'"
,, L----- --------=J ",., u+ lfii?iif.21 F----- - L'gitr! ^o
. 1z I irlot,b asTTELU I cRNu/Hr I v/EW )eIcel ouJl
inpWortsut
(K"UNB 18KSW)Data B.akeswitchinput
wEcvalveconkol
, WEGI orgssure: h,vitch inputinoutrPbPs
Ag
GRN/YEL
wEcPRESSUREswtTcH
POWER STEERINGPRESSURE (PSP)SWITCH
I ALK
Sg€ GroundDistribltion,page 14,
iu,**,"L_jFiF,""*l
*.u_-ig:-l
d'Gr01
23-4
PHO|O 123 IClr|)

PGM-FI (All '9$"q) Models except D16Y5 with M/T and D1685) (cont'd)
@@
i-l;;--
----1-:::=*"---l
!,8,:"ff
| )'rEnsuorr ( tu seo Power I hEiiY
'r9,1%, 'r F,1%,wHr/FEo I v/El/v 34 'HT/FED s€e power w111,6s1 | vtew zz
a 1 oistribution, ll wrlcnr See power
wrr neo I pa$iGio. OF+ DstnbJtron.
t I tn"to"n ! Pa9o 1s13'
oAra LINK z llCONN-ECTOR (DLC) (with cruise controt 4) A
vtEw 48 t?e1 BRAKE SWTTCH
isT-rrT ltf !1.l'".e'.l;'[3J:5:
""[ ":T-:"C-l:.Frd*Fl
lll,
"""f "",T
""U]-t-.,-t-..*.",,""*^i:# [*iu'r;i:;r.';
'""o1""1 ""l
l ;f=:&ri'n"*,,.,0r
[
.---+_s,:.;-,
"*,**il [ff'ftrs,llr,
*,.!. ^* IA2r |' A32 A
: {r(LlN€) €KSW} |I Data Braksfleu.rt} ft svyl IData Braksinpuv switch Ioutput inpd \\' wEC VTEC PSP
I PHaro 123lcvr) D16y5/Dr6y8/ : : PHoro 123lcw)
---'- ei6A2'"noin"i ---- "--- usA
;
L
Dr€ssure vaNesrlitoh input conkol(Vnr) 0rs)
*{
---
"::l
fTlxlE8,u,. I
lc-- ll#il?i,",,*, I
"il
II see crouno
! Fi"frW """,*f,f,',11,r,",.*,
-'l
I
""""iJ,,.lff*u"'"
yi qr;;;i6;;o,E.6A',
: PHOTO 33
sYvltctlinDut
---u-r----
can I
s I crer
"Tl t#ffl","
I-'I-I POWER STEERINGI ' I PRESSURE (PSP)
lc_.ltg+I9i
,
f ff&G{lfd Drsribution,
""L----i
F*i,""," I.----a- -r*ro_*
|"," I vtEw 39
Lr----J
: PHATO 33
\
I
I
pag€ 142.
24-4