2000 FORD CONTOUR fuse box

Roadside emergencies
143 Even after a fuse is replaced, it will
continue to blow if the cause of the
overload is not identified and
corrected. If the fuse continues to
blow, have the vehicle’s electrical
system checked by your dealer or a
qualified service technician.
To reset a circuit breaker, press the
reset button.
The passenger compartment fuse
panel is located on the driver’s side
under the instrument panel. The
power distribution box is located
on the driver’s side of the engine
compartment.
They contain the main fuses and
the main relays. The circuits
protected are identified by
numbers on the passenger
compartment fuse panel and inside
the cover on the power distribution
box.
FUSES AND RELAYS
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire. Check
the appropriate fuses before
replacing any electrical
components.
Always replace a fuse with
one that has the specified
amperage rating. Using a fuse with
higher amperage rating can cause
severe wire damage and could
start a fire.
23CREen 17.6.99 11:11 Uhr Seite 143

Roadside emergencies
144
1
111213141516
R6R5R4R3R2
10
123456789
R1R7R8
R9R10
R11 D1
D2
17
18
4647
4849 5051 52
394041
424344
45
Power distribution box
To check or replace a fuse or a
relay, remove the cover of the fuse
box in the engine compartment by
releasing the latch (1) and lifting
up.
A blown fuse can be identified by a
break in the wire.
All fuses are a push fit.
Five reserve fuses with different
current ratings are located in the
power distribution box.
Always replace the cover to
the Power Distribution Box
before reconnecting the battery or
refilling fluid reservoirs.
23CREen 17.6.99 11:11 Uhr Seite 144

Roadside emergencies
145 Ampere
ratingCircuits protected
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
39
40
41
42
43
44
45
46
47
48
49
50
51
52—
7.5
20
—
—
3
20
—
15
—
20
—
20
7.5
7.5
7.5
7.5
7.5
—
20*
20*
40*
—
—
60*
—
—
—
60*
—
60*
60*Not used
Alternator
Foglamps
Not used
Not used
EEC ignition module (memory)
Horn and hazard flasher warning system
Not used
Fuel pump
Not used
Ignition, Electronic Engine Control
Not used
HEGO sensor
ABS module
Low beam headlamp (passenger’s side)
Low beam headlamp (driver’s side)
High beam headlamp (passenger’s side)
High beam headlamp (driver’s side)
Not used
Ignition, light switch, central junction box
EEC relay
Central junction box (fuse 37 to blower relay)
Not used
Not used
Ignition
Not used
Not used
Not used
Engine cooling
not used
ABS
Central junction box (central timer module, rear
window defrost relay, fuses 24, 25, 27, 28, 34) Fuse
Power distribution box (engine compartment)
* Have these fuses replaced by your dealer or qualified technician.
23CREen 17.6.99 11:11 Uhr Seite 145

Roadside emergencies
146
Power distribution box (engine compartment)
RelayCircuits switched
R 1
R 2
R 3
R 4
R 5
R 6
R 7
R 8
R 9
R 10
R 11
D1
D2
Passenger compartment fuse
panel
To check or change a fuse or a
relay, open the fuse box by pulling
down the lock release lever (1).
1
Fuel pump
EEC module
Air conditioning
Low beam
High beam
Horn
Starter solenoid
Engine cooling fan (high speed)
Engine cooling fan
Not used
Daytime running lights
Reverse voltage protection
Not used
23CREen 17.6.99 11:11 Uhr Seite 146

Roadside emergencies
147 A blown fuse can be identified by a
break in the wire.
All fuses are a push fit.
Five reserve fuses with different
current ratings are attached to the
inside cover of the power
distribution box in case of
emergency fuse replacement.
19 20 21R16 R15
R14 R12R13
22 23 24 25 26 27 28
29 30 31 32 33 34 35 36 37 38
D2
Passenger compartment fuse panel (below instrument panel)
Relay
Circuit switched
R 12
R 13
R 14
R 15
R 16
D 2Interior lighting
Rear window defrost
Heater blower motor
Wiper motor
Ignition
Reverse voltage protection
23CREen 17.6.99 11:11 Uhr Seite 147

Roadside emergencies
149
Fuse rating
7.5 amp
10 amp
15 amp
20 amp
30 amp
30 amp fuse link
40 amp
60 amp fuse link
80 amp fuse link
100 amp fuse linkColor
brown
red
light blue
yellow
light green
pink
orange
yellow
black
blue
Relay
R 18
R 20
R 21
R 22
R 23
R 24
R 25
R 26
R 32
“One touch” switch
(driver’s window)
Not used
Not used
Foglamps
Turn signals
Panic alarm –
driver’s side
Panic alarm –
right-hand side
Not used
Hego heater controlDriver’s door
—
—
Wire shield on instrument panel
Steering column
Door lock module bracket
Door lock module bracket
—
Near PCM-Module
Circuits switchedLocation Standard fuse amperage ratings
and colors
3 amp violet
Auxiliary relays (outside of fuse boxes)
23CREen 17.6.99 11:11 Uhr Seite 149

Index
245 LPage
Lamps
bulb replacement specification
chart . . . . . . . . . . . . . . . . . . . . .212
daytime running light system . .23
flashing the lamps . . . . . . . . . . .57
foglamps . . . . . . . . . . . . . .23, 208
hazard flashers . . . . . . . . .56, 141
headlamps . . . . . . . . . . . . . . . . .22
high beams . . . . . . . . . . . . . . . . .57
high-mounted brake lamp . . . .210
instrument panel, dimming . . .25
interior lamps . . . . . . . . . . . . . .62
reading lamps . . . . . . . . . . . . . .62
replacing bulbs . . . . . . . . . . . .206
rear lamps . . . . . . . . . . . . . . . .209
Lights, warning and indicator
air bag . . . . . . . . . . . . . . . . . . . .15
anti-lock brakes (ABS) . . . . . . .17
brake . . . . . . . . . . . . . . . . . . . . .16
charging system . . . . . . . . . . . . .9
check engine . . . . . . . . . . . . . . .12
engine oil pressure . . . . . . . . . .18
high beam . . . . . . . . . . . . . . . . . .9
low coolant . . . . . . . . . . . . . . . .11
low fuel . . . . . . . . . . . . . . . . . . .15
overdrive off . . . . . . . . . . . . . . .11
safety belt . . . . . . . . . . . . . . . . . .9
testing the warning lights . . . . .19
turn signal indicator . . . . . . . . . .8
Load limits . . . . . . . . . . . . . . . . .130
Lubricant specifications . . . . . .225
Luggage compartment . . . . . . . .66
M
Maintenance (see Servicing)
Manual transaxle
backing up (reverse) . . . . . . . .129
clutch . . . . . . . . . . . . . . . . . . . .127
fluid, capacity . . . . . . . . . . . . .224
shift speeds . . . . . . . . . . . . . . .128MPage
Mileage, calculating fuel
economy . . . . . . . . . . . . . . . . . . .201
Mirrors
side view mirrors (power) . . . .25
Motorcraft parts . . . . . . . . . . . .223
N
National Highway Traffic Safety
Administration . . . . . . . . . . . . . .241
O
Octane rating . . . . . . . . . . . . . . .199
Odometer . . . . . . . . . . . . . . . . . . .20
Oil (see Engine oil)
Oil filter . . . . . . . . . . . . . . .170, 223
On-board diagnostic
(OBD II) system . . . . . . . . . . . .205
Overdrive . . . . . . . . . . . . . . .11, 124
Overhead controls . . . . . . . . . . . .62
P
Panel dimmer control . . . . . . . . .25
Panic alarm, remote entry sytem 69
Parking brake . . . . . . . . . . . . . .118
Parts (see Motorcraft parts) . . .223
Passenger compartment
air filter (see Cabin air filter)
Passive Anti-Theft
System (PATS) . . . . . . . . . . . . . .71
Power distribution box
(see Fuses)
Power door locks . . . . . . . . . . . . .64
Power features
mirrors . . . . . . . . . . . . . . . . . . . .25
seats . . . . . . . . . . . . . . . . . . . . . .75
sunroof . . . . . . . . . . . . . . . . . . . .63
windows . . . . . . . . . . . . . . . . . . .64
Power steering
fluid, checking and adding . . .178
fluid, refill capacity . . . . . . . . .224
fluid, specification . . . . . . . . . .225
4CInden 17.6.99 11:32 Uhr Seite 245