1999 VOLVO S80 ignition

Tail lights
1. Brake light
2. Back-up light
3. Direction indicator
4/5. Tail lights
6. Fog light (left side only)
All tail light bulbs are accessed from inside the trunk.
· Switch off the ignition and open the trunk.
· Fold the covering panel inward to access the bulbs. When replacing right tail light bulbs, access is made easier if you
pull out the cargo net in the trunk completely before folding down the panel.
The bulbs are located in two separate holders, an upper and a lower one. Each holder has a retaining catch.
To replace a bulb in the upper holder:
· Disconnect the wiring from the bulb holder.
· Press the retaining catch upward to release the lower part of the holder.
· Press the retaining catch downward to release the upper part of the holder.
· Replace the defective bulb.
· Press the bulb holder back into place.
· Reconnect the wiring.
· Fold up and close the covering panel.
To replace a bulb in the lower holder:
· Disconnect the wiring from the bulb holder.
· Press the retaining catch toward the outside of the car to release the holder.
· Replace the defective bulb.
· Press the bulb holder back into place.
· Reconnect the wiring.
· Fold up and close the covering panel.
pg.95 Replacing bulbs
Front fog lights (option)
CAUTION:
ProCarManuals.com

Avoid touching the glass on the bulb with your fingers.
· Switch off the ignition.
· Turn the bulb holder slightly counterclockwise to release it.
· Replace the bulb. The shape of the foot of the bulb corresponds to the shape of the bulb holder.
· Reinstall the bulb holder by turning it slightly clockwise. "TOP" on the holder should be upward.
Vanity mirror lights
· Carefully insert a screwdriver and pry out the lens.
· Pry out the bulb and replace it.
· Carefully press the lower edge of lens onto the four tabs and press the upper edge of the lens into place.
Door warning lights
All four doors are equipped with warning lights.
· Using your fingers (or a small piece of plastic or wood if necessary to avoid scratching the paint) press the lens
upward and pull it out.
· Replace the bulb.
· Press the lens back into place.
pg.96 Replacing bulbs
ProCarManuals.com

License plate lights
· Switch off the ignition.
· Loosen the screws with a torx screwdriver.
· Carefully pull out the lamp housing.
· Turn the bulb holder counterclockwise and pull it out.
· Pull out the defective bulb and insert a new one.
· Reinsert the bulb holder into the housing and turn it clockwise.
· Reinstall the housing and screw it in place.
Door step courtesy lights
The door step courtesy lights are located under the dash on the driver's and passenger's sides. To replace a bulb:
· Carefully insert a screwdriver and pry out the lens.
· Replace the defective bulb.
· Reinstall the lens.
Rear door step lights
· Carefully insert a screwdriver and pry out the lens.
· Disconnect the wiring from the lamp housing.
ProCarManuals.com

1 9 9 9
VOLVO S80
Chapter 9 - Specifications
pg.117 Specifications
Label information118
Dimensions and weights119
Engine/transmission specifications120
Oil/fluid specifications and volumes121
Fuel system, Distributor ignition system, Suspension122
Electrical system123
Volvo On Call, Service manuals124
pg.118 Label information
1 Vehicle Emission Control Information
Your Volvo is designed to meet all applicable emission standards, as evidenced by the certification label on the
underside of the hood. For further information regarding these regulations, please consult your Volvo retailer.
2 Vacuum hose routing
(underside of hood)
3 Loads and Tire Pressures
(on inside of fuel tank cover)
4 Model plate
Vehicle Identification Number (VIN). Codes for color and upholstery, etc. The plate is located in the engine
compartment, on the inside of the left front fender.
5 Vehicle Identification Number (VIN) *
The VIN plate is located on the top left surface of the dashboard. The VIN is also stamped on the right hand door
pillar.
6 Federal Motor Vehicle Safety Standards (FMVSS) specifications (USA) and Ministry of Transport (CMVSS)
ProCarManuals.com

Power steering fluid
ATF fluid.
Volume: 0.95 US qt (0.9 liter).
Brake fluid
DOT 4+
Volume: 0.64 US qt (0.6 liter)
Climate control system - refrigerant (R 134a)
Oil: PAG
Volume: 2.2 lbs (1000 g) R134a.
Fuel
Minimum octane requirement - AKI 87 (RON 91)
Volume (fuel tank): 21.1 US gals (80 liters)
Washer fluid reservoir
Volume: 4.7 US qts. (4.5 liters)
All specifications are subject to change without prior notice.
pg.122 Fuel system, Distributor ignition system, Suspension
Fuel system
The engine is equipped with a multiport fuel injection system.
Distributor ignition system
Firing order: 15-3-6-2-4
Distributor ignition setting: Not adjustable
Spark plugs: B 6284 T: P/N 271367-4 (or equivalent)
B 6304 S: P/N 272371-8 (or equivalent)
Spark plug gap: 0.028-0.032" (0.7-0.8 mm)
Tightening torque: 18.4 ft. lbs. (25 Nm)
Replacing spark plugs
The spark plugs should be changed every 30,000 miles (48,000 km). However, city driving or fast highway driving
may necessitate changing after 15,000 miles (24,000 km) of driving. When installing new plugs, be sure to fit the right
type and use correct torque. When changing the plugs, check that the suppressor connectors are in good condition.
Cracked or damaged connectors should be replaced. When changing the spark plugs, clean the terminals and the
ProCarManuals.com

rubber seals.
WARNING!
The distributor ignition system operates at very high voltages. Special safety precautions must be followed to
prevent injury. Always turn the ignition off when:
· Replacing distributor ignition components e.g. plugs, coil, etc.
· Do not touch any part of the distributor ignition system while the engine is running. This may result in unintended
movements and body injury.
Front suspension
Spring strut suspension with integrated shock absorbers and control arms linked to the support frame. Powerassisted
rack and pinion steering. Safety type steering column.
The alignment specifications apply to an unladen car but include fuel, coolant and spare wheel.
Toe-in measured on the wheel rims: 2.3 mm +/ 0.8 mm
Toe-in measured on tire sides: 2.8 +/ 0.9 mm
Rear suspension
Individual rear wheel suspension with longitudinal support arms, double link arms and track rods.
Toe-in measured on the tire sides: 1.9 mm +/ 1.9 mm
Vehicle loading
The tires on your Volvo should perform to specifications at all normal loads when inflated as recommended on the tire
information label. The label is located on the inside of the fuel tank cover. The label lists both tire and vehicle design
limits. Do not load your car beyond the load limits indicated. WARNING!
Improperly inflated tires will reduce tire life, adversely affect vehicle handling and can possibly lead to failure
resulting in loss of vehicle control without prior warning.
All specifications are subject to change without prior notice.
pg.123 Electrical system
Electrical system
12 Volt, negative ground.
Voltagecontrolled generator. Singlewire system with chassis and engine used as conductors. Grounded on chassis.
Battery
ProCarManuals.com

Backrests, rear seat - folding52
Battery75-76, 123
Battery maintenance114-115
Replacing the battery115
Ventilation hose115
Booster cushion13, 15
Booster cushion - integrated13
Brake failure warning light24
Brake fluid112, 121
Brake system16
Break-in period62
Bulbs (list)123
Bulbs - replacing92-98
C
Capacities (oils and fluids)117
, 121
Cargo net in trunk51
Catalytic converters - three-way78
Center console - switches27
Center head restraint - rear seat3
Central locking buttons55
Chains - winter driving81
Changing wheels84-85
Child booster cushion13, 15
Child restraint anchorages12
Child safety12-15
Child safety locks - rear doors60
Climate controls41-43
Climate system - general information44
Clock23
Cold weather driving76
Coolant76, 106, 121
Cooling system121
Cooling system - general information71
Courtesy light48
Courtesy lights (front) - replacing98
Courtesy lights - exterior54
Cruise control29
Cup holder - opening50
D
Dimensions119
Direction indicator bulbs (front)93
Direction indicators31
Distributor ignition system122
Door step courtesy lights - replacing96
ProCarManuals.com

Fuel filler cap63
Fuel gauge23
Fuel requirements62
Fuel system105, 122
Fuel tank cover4, 63
Fuel/emissions systems105
Fuses88-91
G
Gas cap63
Gasoline62
Gear indicator23
Gear ratios120
Geartronic (automatic transmission)67-68
Generator123
Generator warning light24
Glove compartment54
H
Hand brake34
Handling70
Hazard warning flashers33
Head restraint - center rear3
Head restraints, rear - folding27
Headlight bulbs - replacing92
Headlight wiper blades - replacing116
Headlights30
Heated front seats33
Heated rear window33
Heated sideview mirrors33
Heating41-43
Hoisting the car108
Hood - opening109
I
Ignition switch32
Immobilizer (start inhibitor)54, 64
Indicator lights24-25
Inflatable curtain (IC)9
Instrument illumination30
Instrument panel23
Instruments22
Integrated booster cushion13
Interior features - overview20
Interior lighting48
J
Jack51
, 84-85
ProCarManuals.com