1999 TOYOTA AVENSIS air suspension

INTRODUCTION
PREPARATION
SERVICE SPECIFICATIONS
DIAGNOSTICS
E251 MANUAL TRANSAXLE
SUSPENSION AND AXLE
BRAKE
STEERING
SUPPLEMENTAL RESTRAINT SYSTEM
BODY ELECTRICAL
BODY
AIR CONDITIONING
ALPHABETICAL INDEX

IN040–02
B02394
Front
JACK POSITION
PANTOGRAPH JACK POSITION
SUPPORT POSITIONFront
RearFront center member
Rear suspension member
CAUTION : When jacking–up the rear and front, make sure the car is not
carrying any extra weight.
Safety stand and swing arm type lift
– INTRODUCTIONREPAIR INSTRUCTIONS
IN–7
VEHICLE LIFT AND SUPPORT LOCATIONS

IN044–07
IN–34
– INTRODUCTIONTERMS
TERMS
ABBREVIATIONS USED IN THIS MANUAL
AbbreviationsMeaning
ABSAnti–Lock Brake System
A/CAir Conditioner
ACAlternating Current
ACCAccessory
ACISAcoustic Control Induction System
ACSDAutomatic Cold Start Device
A.D.D.Automatic Disconnecting Differential
AHCActive Height Control Suspension
ALRAutomatic Locking Retractor
ALTAlternator
AMPAmplifier
ANTAntenna
APPROX.Approximately
A/TAutomatic Transmission (Transaxle)
AT FAutomatic Transmission Fluid
AUTOAutomatic
BACSBoost Altitude Compensation System
BATBattery
B/LBi–Level
BVSVBimetallic Vacuum Switching Valve
CBCircuit Breaker
CDCompact Disc
CHChannel
CKDComplete Knock Down
COMB.Combination
CPECoupe
CRSChild Restraint System
CTRCenter
DCDirect Current
DIFF.Differential
DIFF. LOCKDifferential Lock
DLCData Link Connector
DSPDigital Signal Processor
DTCDiagnostic Trouble Code
ECTElectronic Control Transmission
ECUElectronic Control Unit
EDUElectronic Driving Unit
EFIElectronic Fuel Injection
E/GEngine
EGRExhaust Gas Recirculation
ELREmergency Locking Retractor
E–VRVElectronic Vacuum Regulating Valve

– INTRODUCTIONTERMS
IN–35
FFFront–Engine Front–Wheel–Drive
FIPGFormed In Place Gasket
FLFusible Link
FrFront
FRFront–Engine Rear–Wheel–Drive
FWDFront–Wheel–Drive
GNDGround
H/BHatchback
HIHigh
HIDHigh Intensity Discharge (Head Lamp)
HTHard Top
HWSHeated Windshield System
IACIdle Air Control
IFSIndependent Front Suspension
IGIgnition
INTIntermittent
I/PInstrument Panel
IRSIndependent Rear Suspension
J/BJunction Block
J/CJunction Connector
LANLocal Area Network
LBLiftback
LCDLiquid Crystal Display
LEDLight Emitting Diode
LHLeft–Hand
LHDLeft–Hand Drive
LOLow
LSDLimited Slip Differential
LSP & PVLoad Sensing Proportioning And Bypass Valve
LSPVLoad Sensing Proportioning Valve
MAPManifold Absolute Pressure
MAX.Maximum
MICMicrophone
MILMalfunction Indicator Lamp
MIN.Minimum
MPMultipurpose
MPIMultipoint Electronic Fuel Injection
MPXMultiplex Communication System
M/TManual Transmission
NNeutral
No.Number
O2SOxygen Sensor
O/DOverdrive
OPTOption
P & BVProportioning And Bypass Valve
PCSPower Control System

PREPARATION
MANUAL TRANSAXLE (E251) PP–1. . . . . . . . . . . . .
SUSPENSION AND AXLE PP–6. . . . . . . . . . . . . . . .
BRAKE PP–11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
STEERING PP–12. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SUPPLEMENTAL RESTRAINT SYSTEM PP–16. . .
BODY ELECTRICAL PP–19. . . . . . . . . . . . . . . . . . . . .
BODY PP–20. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
AIR CONDITIONING PP–22. . . . . . . . . . . . . . . . . . . . .
REFER TO AVENSIS/CORONA REPAIR MANUAL FOR
CHASSIS AND BODY (Pub. No. RM599E)
NOTE: The above pages contain only the points which differ
from the above listed manual.

SERVICE SPECIFICATIONS
STANDARD BOLT SS–1. . . . . . . . . . . . . . . . . . . . . . . .
MANUAL TRANSAXLE (E251) SS–4. . . . . . . . . . . . .
SUSPENSION AND AXLE SS–9. . . . . . . . . . . . . . . .
BRAKE SS–11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
STEERING SS–13. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SUPPLEMENTAL RESTRAINT SYSTEM SS–15. . .
BODY ELECTRICAL SS–16. . . . . . . . . . . . . . . . . . . . .
BODY SS–18. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
AIR CONDITIONING SS–19. . . . . . . . . . . . . . . . . . . . .
REFER TO AVENSIS/CORONA REPAIR MANUAL FOR
CHASSIS AND BODY (Pub. No. RM599E)
NOTE: The above pages contain only the points which differ
from the above listed manual.

SUSPENSION AND AXLE
FRONT DRIVE SHAFT SA–1. . . . . . . . . . . . . . . . . . .
REFER TO AVENSIS/CORONA REPAIR MANUAL FOR
CHASSIS AND BODY (Pub. No. RM599E)
NOTE: The above pages contain only the points which differ
from the above listed manual.

ID–3ALPHABETICAL INDEX (S – W)
Page
SUPPLEMENTAL RESTRAINT SYSTEM
(SERVICE SPECIFICATIONS) SS–15. . . . . . . . . . . . . . . . . .
SUSPENSION AND AXLE (PREPARATION) PP–6. . . . . . . . .
SUSPENSION AND AXLE
(SERVICE SPECIFICATIONS) SS–9. . . . . . . . . . . . . . . . . .
T
TERMINALS OF ECU
(SUPPLEMENTAL RESTRAINT SYSTEM)
(DIAGNOSTICS) DI–6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TERMS IN–34. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING (E251) MX–1. . . . . . . . . . . . . . . . . . . . .
V
VACUUM PUMP (1CD–FTV) BR–2. . . . . . . . . . . . . . . . . . . . . .
VEHICLE IDENTIFICATION AND ENGINE SERIAL
NUMBER (IDENTIFICATION INFORMATION) IN–3. . . . .
VEHICLE LIFT AND SUPPORT LOCATIONS
(REPAIR INSTRUCTIONS) IN–7. . . . . . . . . . . . . . . . . . . . .
W
WATER TEMPERATURE SWITCH (1CD–FTV) AC–36. . . . . . .
WINDSHIELD BO–3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
WIRE HARNESS AND CONNECTOR RS–39. . . . . . . . . . . . . .