1999 FORD CONTOUR relay

Driving
118
5. Push and hold the thumb button
and move the gearshift.
6. Remove the screwdriver when
the gearshift moves from the P
(Park) position.
Overriding the brake-shift
interlock feature
If it is necessary to use this
procedure to move the gearshift
lever, it is possible that a fuse has
blown and the vehicleÕs brakelamps
may not be working. Refer to Fuses
and relaysin the Roadside
emergencieschapter.
If you cannot move the gearshift
lever from P (Park) with the brake
pedal depressed:
1. Turn the ignition off and remove
the ignition key.
2. Apply the parking brake and the
brake pedal.
3. Insert a screwdriver or similar
item about 5 cm (2 inches) into the
square opening to the right of the
gearshift at the base of the console.
4. Rotate the screwdriver point
rearward.
22CDren 3/25/99 3:32 PM Page 118

Roadside emergencies
139
Even after a fuse is replaced, it will
continue to blow if the cause of the
overload is not identified and
corrected. If the fuse continues to
blow, have the vehicleÕs electrical
system checked by your dealer or a
qualified service technician.
To reset a circuit breaker, press the
reset button.
The passenger compartment fuse
panel is located on the driverÕs side
under the instrument panel. The
power distribution box is located
on the driverÕs side of the engine
compartment.
They contain the main fuses and
the main relays. The circuits
protected are identified by
numbers on the passenger
compartment fuse panel and inside
the cover on the power distribution
box.
FUSES AND RELAYS
If electrical components in the
vehicle are not working, a fuse may
have blown. Blown fuses are
identified by a broken wire. Check
the appropriate fuses before
replacing any electrical
components.
Always replace a fuse with
one that has the specified
amperage rating. Using a fuse with
higher amperage rating can cause
severe wire damage and could
start a fire.
23CREen 3/25/99 3:35 PM Page 139

Roadside emergencies
140
1
111213141516
R6R5R4R3R2
10
123456789
R1R7R8
R9R10
R11 D1
D2
17
18
4647
4849 5051 52
394041
424344
45
Power distribution box
To check or replace a fuse or a
relay, remove the cover of the fuse
box in the engine compartment by
releasing the latch (1) and lifting
up.
A blown fuse can be identified by a
break in the wire.
All fuses are a push fit.
Five reserve fuses with different
current ratings are attached to the
inside cover of the power
distribution box in case of
emergency fuse replacement.
Always replace the cover to
the Power Distribution Box
before reconnecting the battery or
refilling fluid reservoirs.
23CREen 3/25/99 3:35 PM Page 140

Roadside emergencies
141
Ampere
ratingCircuits protected
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
39
40
41
42
43
44
45
46
47
48
49
50
51
52Ñ
7.5
20
Ñ
Ñ
3
20
Ñ
15
Ñ
20
Ñ
20
7.5
7.5
7.5
7.5
7.5
Ñ
20*
20*
40*
Ñ
Ñ
60*
Ñ
Ñ
Ñ
60*
Ñ
60*
60*Not used
Alternator
Foglamps
Not used
Not used
EEC ignition module (memory)
Horn and hazard flasher warning system
Not used
Fuel pump
Not used
Ignition, Electronic Engine Control
Not used
HEGO sensor
ABS module
Low beam headlamp (passengerÕs side)
Low beam headlamp (driverÕs side)
High beam headlamp (passengerÕs side)
High beam headlamp (driverÕs side)
Not used
Ignition, light switch, central junction box
EEC relay
Central junction box (fuse 37 to blower relay)
Not used
Not used
Ignition
Not used
Not used
Not used
Engine cooling
not used
ABS
Central junction box (central timer module, rear
window defrost relay, fuses 24, 25, 27, 28, 34)Fuse
Power distribution box (engine compartment)
* Have these fuses replaced by your dealer or qualified technician.
23CREen 3/25/99 3:35 PM Page 141

Roadside emergencies
142
Power distribution box (engine compartment)
RelayCircuits switched
R 1
R 2
R 3
R 4
R 5
R 6
R 7
R 8
R 9
R 10
R 11
D1
D2
Passenger compartment fuse
panel
To check or change a fuse or a
relay, open the fuse box by pulling
down the lock release lever (1).
1
Fuel pump
EEC module
Air conditioning
Low beam
High beam
Horn
Starter solenoid
Engine cooling fan (high speed)
Engine cooling fan
Not used
Daytime running lights
Reverse voltage protection
Not used
23CREen 3/25/99 3:35 PM Page 142

Roadside emergencies
143
A blown fuse can be identified by a
break in the wire.
All fuses are a push fit.
Five reserve fuses with different
current ratings are attached to the
inside cover of the power
distribution box in case of
emergency fuse replacement.
19 20 21R16 R15
R14 R12R13
22 23 24 25 26 27 28
29 30 31 32 33 34 35 36 37 38
D2
Passenger compartment fuse panel (below instrument panel)
Relay
Circuit switched
R 12
R 13
R 14
R 15
R 16
D 2Interior lighting
Rear window defrost
Heater blower motor
Wiper motor
Ignition
Reverse voltage protection
23CREen 3/25/99 3:35 PM Page 143

Roadside emergencies
145
Fuse rating
7.5 amp
10 amp
15 amp
20 amp
30 amp
30 amp fuse link
40 amp
60 amp fuse link
80 amp fuse link
100 amp fuse linkColor
brown
red
light blue
yellow
light green
pink
orange
yellow
black
blue
Relay
R 18
R 20
R 21
R 22
R 23
R 24
R 25
R 26ÒOne touchÓ switch
(driverÕs window)
Not used
Not used
Foglamps
Turn signals
Panic alarm Ð
driverÕs side
Panic alarm Ð
right-hand side
Not usedDriverÕs door
Ñ
Ñ
Module bracket
Steering column
Door lock module bracket
Door lock module bracket
Ñ
Circuits switchedLocation
Standard fuse amperage ratings
and colors
3 amp violet
Auxiliary relays (outside of fuse boxes)
23CREen 3/25/99 3:35 PM Page 145

Index
240
MPage
Maintenance (see Servicing)
Manual transaxle
backing up (reverse) . . . . . . . .125
clutch . . . . . . . . . . . . . . . . . . . .123
fluid, capacity . . . . . . . . . . . . .218
shift speeds . . . . . . . . . . . . . . .124
Mileage, calculating fuel
economy . . . . . . . . . . . . . . . . . . .195
Mirrors
side view mirrors (power) . . . .23
Motorcraft parts . . . . . . . . . . . .217
N
National Highway Traffic Safety
Administration . . . . . . . . . . . . . .235
O
Octane rating . . . . . . . . . . . . . . .193
Odometer . . . . . . . . . . . . . . . . . . .19
Oil (see Engine oil)
Oil filter . . . . . . . . . . . . . . .165, 217
On-board diagnostic (OBD II)
system . . . . . . . . . . . . . . . . . . . .198
Overdrive . . . . . . . . . . . . . . . .9, 120
Overhead controls . . . . . . . . . . . .61
P
Panel dimmer control . . . . . . . . .22
Panic alarm, remote entry sytem 67
Parking brake . . . . . . . . . . . . . .114
Parts (see Motorcraft parts) . . .217
Passenger compartment
air filter (see Cabin air filter) . .181
Passive Anti-Theft
System (PATS) . . . . . . . . . . . . . .69
PPage
Power distribution box
(see Fuses)
Power door locks . . . . . . . . . . . . .62
Power features
mirrors . . . . . . . . . . . . . . . . . . . .23
seats . . . . . . . . . . . . . . . . . . . . . .73
sunroof . . . . . . . . . . . . . . . . . . . .61
windows . . . . . . . . . . . . . . . . . . .62
Power steering
fluid, checking and adding . . .173
fluid, refill capacity . . . . . . . . .218
fluid, specification . . . . . . . . . .219
R
Radio (see Audio system) . . . . . .32
Rear window defroster . . . . . . . .22
Refill capacities for fluids . . . . .218
Relays . . . . . . . . . . . . . . . . . . . . .139
Remote control
luggage compartment . . . . . . . .64
Remote entry system
locking/unlocking doors . . . . . .66
opening the trunk . . . . . . . . . . .67
panic alarm . . . . . . . . . . . . . . . .67
replacing the batteries . . . . . . .67
replacement/additional
transmitters . . . . . . . . . . . . . . . .68
Repairing paint chips . . . . . . . .212
Reporting safety defects . . . . . .235
Restraints, safety . . . . . . . . . . . . .75
Rotating the tires . . . . . . . . . . . .185
4CInden 3/25/99 3:55 PM Page 240