1999 CHEVROLET S10 parking brake

Long Trip/Highway Scheduled Maintenance
yellowblue
7-29
The services shown in this schedule up to 100,000 miles
(166 000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals. The services shown
at 150,000 miles (240 000 km) should be performed at
the same interval after 150,000 miles (240 000 km).
See ªOwner Checks and Servicesº and ªPeriodic
Maintenance Inspectionsº following.
Footnotes
 The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the
completion of the vehicle's useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.# Lubricate the front suspension, ball joints, steering
linkage, parking brake cable guides, propshaft splines,
universal joints and brake pedal springs.
+ A good time to check your brakes is during tire
rotation. See ªBrake System Inspectionº under ªPeriodic
Maintenance Inspectionsº in Part C of this schedule.
** Drive axle service (see ªRecommended Fluids and
Lubricantsº in the Index for proper lubricant to use):

Locking Differential -- Drain fluid and refill at first
engine oil change. At subsequent oil changes, check
fluid level and add fluid as needed.

Standard Differential
-- Check fluid level and add
fluid as needed at every engine oil change.

yellowblue
7-44
Starter Switch Check
CAUTION:
When you are doing this check, the vehicle could
move suddenly. If it does, you or others could be
injured. Follow the steps below.
1. Before you start, be sure you have enough room
around the vehicle.
2. Firmly apply both the parking brake (see ªParking
Brakeº in the Index if necessary) and the regular brake.
NOTE: Do not use the accelerator pedal, and be
ready to turn off the engine immediately if it starts.
3. On automatic transmission vehicles, try to start the
engine in each gear. The starter should work only in
PARK (P) or NEUTRAL (N). If the starter works in
any other position, your vehicle needs service.
On manual transmission vehicles, put the shift lever
in NEUTRAL (N), push the clutch down halfway
and try to start the engine. The starter should work
only when the clutch is pushed down all the way to
the floor. If the starter works when the clutch isn't
pushed all the way down, your vehicle needs service.Brake
-Transmission Shift Interlock (BTSI) Check
(Automatic Transmission)
CAUTION:
When you are doing this check, the vehicle could
move suddenly. If it does, you or others could be
injured. Follow the steps below.
1. Before you start, be sure you have enough room
around the vehicle. It should be parked on a
level surface.
2. Firmly apply the parking brake (see ªParking Brakeº
in the Index if necessary).
NOTE: Be ready to apply the regular brake
immediately if the vehicle begins to move.
3. With the engine off, turn the key to the RUN
position, but don't start the engine. Without applying
the regular brake, try to move the shift lever out of
PARK (P) with normal effort. If the shift lever
moves out of PARK (P), your vehicle's BTSI
needs service.

yellowblue
7-45
Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to LOCK in each shift lever position.

With an automatic transmission, the key should turn
to LOCK only when the shift lever is in PARK (P).

With a manual transmission, the key should turn to
LOCK only when you press the key release button.
On all vehicles, the key should come out only in LOCK.
Parking Brake and Automatic Transmission
PARK (P) Mechanism Check
CAUTION:
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front of your vehicle in case
it begins to roll. Be ready to apply the regular
brake at once should the vehicle begin to move.
Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.

To check the parking brake's holding ability:
With the engine running and transmission in
NEUTRAL (N), slowly remove foot pressure from
the regular brake pedal. Do this until the vehicle is
held by the parking brake only.

To check the PARK (P) mechanism's holding ability:
With the engine running, shift to PARK (P). Then
release all brakes.
Underbody Flushing Service
At least every spring, use plain water to flush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.

yellowblue
7-47 Throttle System Inspection
Inspect the throttle system for interference or binding,
and for damaged or missing parts. Replace parts as
needed. Replace any components that have high effort
or excessive wear. Do not lubricate accelerator and
cruise control cables.
Drive Axle Service
Check rear/front axle fluid level and add as needed.
Check constant velocity joints and axle seals for leaking.
Transfer Case (Four-Wheel Drive)
Inspection
Every 12 months or at oil change intervals, check front
axle and transfer case and add lubricant when necessary.
Check vent hose at transfer case for kinks and proper
installation. More frequent lubrication may be required
on off
-road use.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook
-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition. Also inspect drum brake linings
for wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc.
Check parking brake adjustment. You may need to have
your brakes inspected more often if your driving habits
or conditions result in frequent braking.

9-yellowblue
9-1
Section 9 Index
A
ccessory Power Outlets 2-49 . . . . . . . . . . . . . . . . . . . . . . . .
Adding Equipment to the Outside of Your Vehicle 6-3 . . . . . .
Adding Sound Equipment 3-23 . . . . . . . . . . . . . . . . . . . . . . . .
Add-On Equipment 4-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Bag 1-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adding Equipment 1-30 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
How Does it Restrain 1-25 . . . . . . . . . . . . . . . . . . . . . . . . . .
How it Works 1-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Location 1-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Readiness Light 1-22, 2-56 . . . . . . . . . . . . . . . . . . . . . . . . .
Servicing 1-30 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
What Makes it Inflate 1-24 . . . . . . . . . . . . . . . . . . . . . . . . . .
What Will You See After it Inflates 1-25 . . . . . . . . . . . . . . .
When Should it Inflate 1-24 . . . . . . . . . . . . . . . . . . . . . . . . .
Air Bag Off Light 1-28, 2-56 . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Bag Off Switch 1-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Bag System 1-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Cleaner 6-16, 6-70 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Conditioning 3-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Conditioning Refrigerants 6-69 . . . . . . . . . . . . . . . . . . . . .
Alignment and Balance, Tire 6-49 . . . . . . . . . . . . . . . . . . . . . .
Aluminum Wheels, Cleaning 6-56 . . . . . . . . . . . . . . . . . . . . . .
Antenna, Fixed 3-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Anti-Lock Brake System Warning Light 2-60, 4-7 . . . . . . . . .
Anti-Lock Brakes 4-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Appearance Care 6-51 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Appearance Care and Materials 6-59 . . . . . . . . . . . . . . . . . . . . Arbitration Program 8
-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Armrest, Storage 2-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ashtrays 2-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Audio System Tips 3-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Audio Systems 3-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Automatic Headlamp System 2-41 . . . . . . . . . . . . . . . . . . . . . .
Automatic Transmission
Check 7
-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid 6-17, 6-68, 7-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation 2-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Park Mechanism Check 7-45 . . . . . . . . . . . . . . . . . . . . . . . .
Shifting 2-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Axle
Front 6
-24 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear 6-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery 6-35 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Charge Light 2-58 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump Starting 5-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacement, Keyless Entry 2-7 . . . . . . . . . . . . . . . . . . . . .
Run-Down Protection 2-44 . . . . . . . . . . . . . . . . . . . . . . . . .
Warnings 5-3, 5-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
BBB Auto Line 8-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Better Business Bureau Mediation 8-4 . . . . . . . . . . . . . . . . . . .
Brake Fluid 6-31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake, Parking 2-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake System Warning Light 2-60 . . . . . . . . . . . . . . . . . . . . . .

yellowblue
9-7
Night Vision 4-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Normal Maintenance Replacement Parts 6-70 . . . . . . . . . . . . .
Odometer 2-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Off-Road Driving 4-14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Off-Road Driving with Your Four-Wheel-Drive Vehicle 4-14
Off-Road Recovery 4-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil, Engine 6-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ordering Service and Owner Publications 8-12, 8-13 . . . . . . .
Outside Mirror
Convex 2
-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Heated 2-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual Adjust 2-45 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power Remote Control 2-45 . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating Engine 5-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Owner Checks and Services 7-42 . . . . . . . . . . . . . . . . . . . . . . .
Owner Publications, Ordering 8-12, 8-13 . . . . . . . . . . . . . . . .
Paint Spotting, Chemical 6-58 . . . . . . . . . . . . . . . . . . . . . . . .
Park
Automatic Transmission 2
-18 . . . . . . . . . . . . . . . . . . . . . . .
Shifting Into 2-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifting Out of 2-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parking
At Night 2
-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake 2-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake Mechanism Check 7-45 . . . . . . . . . . . . . . . . . . . . . . .
Lots 2-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
On Hills with a Trailer 4-53 . . . . . . . . . . . . . . . . . . . . . . . . .
Over Things That Burn 2-30 . . . . . . . . . . . . . . . . . . . . . . . .
With a Trailer 4-53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Your Vehicle, Manual Transmission 2-30 . . . . . . . . . . . . . .
Parts, Replacement 6-70 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Passing 4
-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Passlock
2-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Payload 4-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Periodic Maintenance Inspections 7-46 . . . . . . . . . . . . . . . . . .
Pickup Conversion to Chassis Cab 4-45 . . . . . . . . . . . . . . . . .
Power
Accessory Outlets 2
-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Locks 2-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Option Fuses 6-61 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Remote Control Mirror 2-45 . . . . . . . . . . . . . . . . . . . . . . . .
Steering 4-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering Fluid 6-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Windows 2-32 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pregnancy, Use of Safety Belts 1-19 . . . . . . . . . . . . . . . . . . . .
Problems on the Road 5-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Publications, Service and Owner 8-12, 8-13 . . . . . . . . . . . . . .
Radiator 5-16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radiator Pressure Cap 6-25 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radio Reception 3-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radios
AM
-FM Stereo 3-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cassette Tape Care 3-24 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cassette Tape Player 3-8, 3-11 . . . . . . . . . . . . . . . . . . . . . .
Compact Disc Player 3-15 . . . . . . . . . . . . . . . . . . . . . . . . . .
Compact Disc Player Care 3-25 . . . . . . . . . . . . . . . . . . . . . .
Remote Cassette Tape Player 3-19 . . . . . . . . . . . . . . . . . . . .
Theft-Deterrent Feature 3-21 . . . . . . . . . . . . . . . . . . . . . . . .
Rain, Driving 4-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
RAP 2-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear
Axle 6
-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat Passengers 1-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

yellowblue
9-9
Signaling Turns 2-35 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Skidding 4-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sliding Rear Windows 2-34 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Spare Tire 5-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Specifications and Capacities 6-67, 6-68 . . . . . . . . . . . . . . . . .
Speech Impaired, Customer Assistance 8-4 . . . . . . . . . . . . . . .
Speedometer 2-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Stains, Cleaning 6-53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starter Switch Check 7-44 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starting Your Engine 2-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steam 5-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering
In Emergencies 4
-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power 4-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering Wheel, Tilt 2-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Storage Compartments 2-46 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Storage, Vehicle 6-35 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Stuck: In Sand, Mud, Ice or Snow 5-32 . . . . . . . . . . . . . . . . . .
Sun Visors 2-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Symbols, Vehicle v. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tachometer 2-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tailgate 2-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lubrication Service 7-43 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Taillamp Bulb Replacement 6-40 . . . . . . . . . . . . . . . . . . . . . . .
Tape Player Care 3-24, 7-42 . . . . . . . . . . . . . . . . . . . . . . . . . .
Theft 2-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Theft-Deterrent Feature 2-10 . . . . . . . . . . . . . . . . . . . . . . . . . .
THEFTLOCK
3-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Thermostat 6-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Third Gear
Automatic Transmission 2
-20 . . . . . . . . . . . . . . . . . . . . . . .
Manual Transmission 2-22 . . . . . . . . . . . . . . . . . . . . . . . . . . Tilt Steering Wheel 2
-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Time, Setting 3-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tire Chains 6-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tire Loading 4-40 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tires 6-41
Alignment and Balance 6-49 . . . . . . . . . . . . . . . . . . . . . . . .
Buying New 6-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Changing a Flat 5-19 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cleaning 6-57 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inflation 6-44 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inflation Check 7-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inspection and Rotation 6-45 . . . . . . . . . . . . . . . . . . . . . . . .
Pressure 6-44 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Spare 5-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Temperature 6-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Traction 6-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Treadwear 6-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Uniform Quality Grading 6-48 . . . . . . . . . . . . . . . . . . . . . . .
Wear Indicators 6-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheel Replacement 6-49 . . . . . . . . . . . . . . . . . . . . . . . . . . .
When It's Time for New 6-46 . . . . . . . . . . . . . . . . . . . . . . .
Top Strap 1-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Torque Lock 2-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Torque, Wheel Nut 5-28, 6-67 . . . . . . . . . . . . . . . . . . . . . . . . .
Towing a Trailer 4-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Towing, Recreational Vehicle 4-39 . . . . . . . . . . . . . . . . . . . . .
Towing Your Vehicle 5-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Trailer
Brakes 4
-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Driving on Grades 4-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Driving with a Trailer 4-51 . . . . . . . . . . . . . . . . . . . . . . . . . .
Hitches 4-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance When Towing 4-54 . . . . . . . . . . . . . . . . . . . . .
Parking on Hills 4-53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .