1999 CHEVROLET S10 radiator cap

Short Trip/City Scheduled Maintenance
yellowblue
7-28
100,000 Miles (166 000 km)

Inspect spark plug wires.
An Emission Control Service.

Replace spark plugs.
An Emission Control Service.

If you haven't used your vehicle under severe service conditions listed
previously and, therefore, haven't changed your automatic transmission
fluid, change both the fluid and filter. Manual transmission fluid doesn't
require change.

4.3L V6 Engine Only: Inspect Positive Crankcase Ventilation (PCV) valve.
An Emission Control Service.
150,000 Miles (240 000 km)

Drain, flush and refill cooling system (or every 60 months since last service,
whichever occurs first). See ªEngine Coolantº in the Index for what to use.
Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test
cooling system and pressure cap.
An Emission Control Service.
ACTUAL
SERVICED BY:MILEAGE
DATE
ACTUAL
SERVICED BY:MILEAGE
DATE

Long Trip/Highway Scheduled Maintenance
yellowblue
7-41
150,000 Miles (240 000 km)

Drain, flush and refill cooling system (or every 60 months since last service,
whichever occurs first). See ªEngine Coolantº in the Index for what to use.
Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test
the cooling system and pressure cap.
An Emission Control Service.ACTUAL
SERVICED BY:MILEAGE
DATE

yellowblue
7-46
Part C: Periodic
Maintenance Inspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall). You should let your dealer's
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a service manual. See ªService and Owner
Publicationsº in the Index.
Steering, Suspension and Front Drive
Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook
-up, binding, leaks,
cracks, chafing, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out
-of-position parts as well as open seams,
holes, loose connections or other conditions which could
cause a heat build
-up in the floor pan or could let
exhaust fumes into the vehicle. See ªEngine Exhaustº
in the Index.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes, fittings
and clamps; replace as needed. Clean the outside of the
radiator and air conditioning condenser. To help ensure
proper operation, a pressure test of the cooling system and
pressure cap is recommended at least once a year.

yellowblue
9-7
Night Vision 4-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Normal Maintenance Replacement Parts 6-70 . . . . . . . . . . . . .
Odometer 2-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Off-Road Driving 4-14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Off-Road Driving with Your Four-Wheel-Drive Vehicle 4-14
Off-Road Recovery 4-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil, Engine 6-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ordering Service and Owner Publications 8-12, 8-13 . . . . . . .
Outside Mirror
Convex 2
-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Heated 2-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual Adjust 2-45 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power Remote Control 2-45 . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating Engine 5-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Owner Checks and Services 7-42 . . . . . . . . . . . . . . . . . . . . . . .
Owner Publications, Ordering 8-12, 8-13 . . . . . . . . . . . . . . . .
Paint Spotting, Chemical 6-58 . . . . . . . . . . . . . . . . . . . . . . . .
Park
Automatic Transmission 2
-18 . . . . . . . . . . . . . . . . . . . . . . .
Shifting Into 2-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifting Out of 2-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parking
At Night 2
-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake 2-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake Mechanism Check 7-45 . . . . . . . . . . . . . . . . . . . . . . .
Lots 2-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
On Hills with a Trailer 4-53 . . . . . . . . . . . . . . . . . . . . . . . . .
Over Things That Burn 2-30 . . . . . . . . . . . . . . . . . . . . . . . .
With a Trailer 4-53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Your Vehicle, Manual Transmission 2-30 . . . . . . . . . . . . . .
Parts, Replacement 6-70 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Passing 4
-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Passlock
2-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Payload 4-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Periodic Maintenance Inspections 7-46 . . . . . . . . . . . . . . . . . .
Pickup Conversion to Chassis Cab 4-45 . . . . . . . . . . . . . . . . .
Power
Accessory Outlets 2
-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Locks 2-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Option Fuses 6-61 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Remote Control Mirror 2-45 . . . . . . . . . . . . . . . . . . . . . . . .
Steering 4-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering Fluid 6-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Windows 2-32 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pregnancy, Use of Safety Belts 1-19 . . . . . . . . . . . . . . . . . . . .
Problems on the Road 5-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Publications, Service and Owner 8-12, 8-13 . . . . . . . . . . . . . .
Radiator 5-16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radiator Pressure Cap 6-25 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radio Reception 3-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radios
AM
-FM Stereo 3-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cassette Tape Care 3-24 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cassette Tape Player 3-8, 3-11 . . . . . . . . . . . . . . . . . . . . . .
Compact Disc Player 3-15 . . . . . . . . . . . . . . . . . . . . . . . . . .
Compact Disc Player Care 3-25 . . . . . . . . . . . . . . . . . . . . . .
Remote Cassette Tape Player 3-19 . . . . . . . . . . . . . . . . . . . .
Theft-Deterrent Feature 3-21 . . . . . . . . . . . . . . . . . . . . . . . .
Rain, Driving 4-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
RAP 2-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear
Axle 6
-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat Passengers 1-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .