1999 CHEVROLET LUMINA engine

yellowblue
7-16
Ignition Transaxle Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to LOCK in each shift lever position.

The key should turn to LOCK only when the shift
lever is in PARK (P).

The key should come out only in LOCK.
Parking Brake and Automatic Transaxle PARK (P)
Mechanism Check
CAUTION:
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front of your vehicle in case
it begins to roll. Be ready to apply the regular
brake at once should the vehicle begin to move.
Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.

To check the parking brake's holding ability: With
the engine running and transaxle in NEUTRAL (N),
slowly remove foot pressure from the regular brake
pedal. Do this until the vehicle is held by the parking
brake only.

To check the PARK (P) mechanism's holding ability:
With the engine running, shift to PARK (P). Then
release all brakes.
Underbody Flushing Service
At least every spring, use plain water to flush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.

yellowblue
7-17
Part C: Periodic Maintenance
Inspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall). You should let your dealer's
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a service manual. See ªService and Owner
Publicationsº in the Index.
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook
-up, binding, leaks,
cracks, chafing, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out
-of-position parts as well as open seams,
holes, loose connections or other conditions which could
cause a heat build
-up in the floor pan or could let
exhaust fumes into the vehicle. See ªEngine Exhaustº in
the Index.

yellowblue
7-18 Engine Cooling System Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed. Clean the outside
of the radiator and air conditioning condenser. To help
ensure proper operation, a pressure test of the cooling
system and pressure cap is recommended at least once
a year.
Throttle System Inspection
Inspect the throttle system for interference or binding,
and for damaged or missing parts. Replace parts as
needed. Replace any components that have high effort
or excessive wear. Do not lubricate accelerator and
cruise control cables.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook
-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition. Also inspect drum brake linings
for wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc.
Check parking brake adjustment. You may need to have
your brakes inspected more often if your driving habits
or conditions result in frequent braking.

yellowblue
7-19
Part D: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from
your dealer.
USAGE
FLUID/LUBRICANT
Engine OilEngine Oil with the American
Petroleum Institute Certified For
Gasoline Engines ªStarburstº
symbol of the proper viscosity. To
determine the preferred viscosity
for your vehicle's engine, see
ªEngine Oilº in the Index.
Engine Coolant50/50 mixture of clean, drinkable
water and use only GM
Goodwrench

DEX-COOL
or
Havoline
DEX-COOL

Coolant. See ªEngine Coolantº in
the Index.
Hydraulic Brake
SystemDelco Supreme 11
Brake Fluid
(GM Part No. 12377967 or
equivalent DOT
-3 Brake Fluid).
USAGEFLUID/LUBRICANT
Windshield
Washer SolventGM Optikleen
Washer Solvent
(GM Part No. 1051515)
or equivalent.
Power Steering
SystemGM Power Steering Fluid (GM
Part No. 1052884
- 1 pint,
1050017
- 1 quart, or equivalent).
Automatic
TransaxleDEXRON
-III Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant,
Superlube
(GM Part
No. 12346241 or equivalent).
Hood Latch
Assembly,
Secondary Latch,
Pivots, Spring
Anchor and
Release PawlLubriplate
Lubricant Aerosol
(GM Part No. 12346293 or
equivalent) or lubricant meeting
requirements of NLGI # 2,
Category LB or GC
-LB.
Hood and Door
HingesMulti-Purpose Lubricant,
Superlube
(GM Part
No. 12346241 or equivalent).
Weatherstrip
ConditioningDielectric Silicone Grease (GM
Part No. 12345579 or equivalent).

yellowblue
8-12
CURRENT PUBLICATIONS FOR 1999 CHEVROLET
SERVICE MANUALS
Service Manuals have the diagnosis and repair information
on engines, transmission, axle, suspension, brakes,
electrical, steering, body, etc.
RETAIL SELL PRICE: $90.00
TRANSMISSION, TRANSAXLE, TRANSFER CASE
UNIT REPAIR MANUAL
This manual provides information on unit repair service
procedures, adjustments and specifications for the
1999 GM transmissions, transaxles and transfer cases.
RETAIL SELL PRICE: $50.00
SERVICE BULLETINS
Service Bulletins give technical service information needed
to knowledgeably service General Motors cars and trucks.
Each bulletin contains instructions to assist in the
diagnosis and service of your vehicle.OWNER'S INFORMATION
Owner publications are written directly for Owners and
intended to provide basic operational information about the
vehicle. The owner's manual will include the Maintenance
Schedule for all models.
In-Portfolio: Includes a Portfolio, Owner's Manual and
Warranty Booklet.
RETAIL SELL PRICE: $15.00
Without Portfolio: Owner's Manual only.
RETAIL SELL PRICE: $10.00
CURRENT & PAST MODEL ORDER FORMS
Service Publications are available for current and past
model GM vehicles. To request an order form, please
specify year and model name of the vehicle.
PLEASE COMPLETE THE ORDER FORM SHOWN ON
THE FOLLOWING PAGE AND MAIL TO:
Helm, Incorporated
P.O. Box 07130
Detroit, MI 48207OR ORDER TOLL FREE: 1-800-551-4123
Monday-Friday 8:00 AM ± 6:00 PM Eastern Time
For Credit Card Orders Only (VISA±MasterCard±Discover)
1999 CHEVROLET SERVICE PUBLICATIONS ORDERING INFORMATION
The following publications covering the operation and servicing of your vehicle can be purchased by filling out
the Service Publication Order Form in this book and mailing it in with your check, money order,
or credit card information to Helm, Incorporated (address below.)

yellowblue
9-3
Cleaning 6-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum Wheels 6-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exterior Lamps/Lenses 6-51 . . . . . . . . . . . . . . . . . . . . . . . .
Fabric 6-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fabric Protection 6-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Glass Surfaces 6-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inside of Your Vehicle 6-47 . . . . . . . . . . . . . . . . . . . . . . . . .
Instrument Panel 6-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Interior Plastic Components 6-49 . . . . . . . . . . . . . . . . . . . . .
Leather 6-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside of Your Vehicle 6-51 . . . . . . . . . . . . . . . . . . . . . . . .
Special Problems 6-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Stains 6-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tires 6-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Vinyl 6-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheels 6-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Windshield and Wiper Blades 6-50 . . . . . . . . . . . . . . . . . . .
Climate Control System 3-2 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Clock, for Systems with Automatic Tone Control,
Setting the 3
-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Clock, for Systems without Automatic Tone Control,
Setting the 3
-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Comfort Controls 3-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Compact Disc Player
Care 3
-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Errors 3-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Compact Spare Tire 5-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Console Storage 2-41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Control of a Vehicle 4-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Convenience Net 2-41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Convex Outside Mirror 2
-40 . . . . . . . . . . . . . . . . . . . . . . . . . .
Coolant 6-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adding 6-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bleed Valves 5-19 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking 6-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Heater, Engine 2-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radiator 5-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Recovery Tank 5-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
What to Use 6-24 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
When Trailer Towing 4-40 . . . . . . . . . . . . . . . . . . . . . . . . . .
Cooling System 5-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Courtesy Lamps 2-37 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Courtesy Transportation 8-8 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cruise Control 2-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cupholders 2-40, 2-41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Customer Assistance
for Text Telephone Users 8
-4 . . . . . . . . . . . . . . . . . . . . . . . .
Information 8-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Offices 8-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Customer Satisfaction Procedure 8-2 . . . . . . . . . . . . . . . . . . . .
Damage
Finish 6-53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sheet Metal 6-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Daytime Running Lamps 2-36 . . . . . . . . . . . . . . . . . . . . . . . . .
Dead Battery 5-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Defects, Reporting Safety 8-10 . . . . . . . . . . . . . . . . . . . . . . . .
Defensive Driving 4-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

yellowblue
9-4
Defogger, Rear Window 3-4 . . . . . . . . . . . . . . . . . . . . . . . . . .
Defogging 3-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Defrosting 3-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dimensions, Vehicle 6-65 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dolby B Noise Reduction 3-11 . . . . . . . . . . . . . . . . . . . . . . . .
Dome Lamp Bulb Replacement 6-38 . . . . . . . . . . . . . . . . . . . .
Door Locks 2-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Drive Position, Automatic Transaxle 2-21 . . . . . . . . . . . . . . . .
Driver Position 1-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Driving
City 4
-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Defensive 4-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Drunken 4-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Freeway 4-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
In a Blizzard 4-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
In Foreign Countries 6-5 . . . . . . . . . . . . . . . . . . . . . . . . . . .
In the Rain 4-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Night 4-16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
On Curves 4-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
On Grades While Towing a Trailer 4-39 . . . . . . . . . . . . . . .
On Hill and Mountain Roads 4-24 . . . . . . . . . . . . . . . . . . . .
On Snow or Ice 4-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Through Water 4-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wet Roads 4-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Winter 4-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
With a Trailer 4-37 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Drunken Driving 4-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electrical Equipment
Adding 2-15, 2-16, 2-44, 3-20, 6-55 . . . . . . . . . . . . . . . . . .
Engine 6-10, 6-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Coolant 6-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Coolant Heater 2-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Coolant Level Check 7-13 . . . . . . . . . . . . . . . . . . . . . . . . . .
Coolant Temperature Gage 2-56 . . . . . . . . . . . . . . . . . . . . .
Coolant Temperature Light 2-55 . . . . . . . . . . . . . . . . . . . . .
Exhaust 2-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Identification 6-55 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil Level Check 7-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating 5-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Running While Parked 2-28 . . . . . . . . . . . . . . . . . . . . . . . . .
Specifications 6-64 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starting Your V6 2-15, 2-16 . . . . . . . . . . . . . . . . . . . . . . . .
Engine Air Cleaner/Filter 6-18 . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Cooling When Trailer Towing 4-40 . . . . . . . . . . . . . . .
Engine Oil 6-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adding 6-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Additives 6-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking 6-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Used 6-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
What Kind to Use 6-14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
When to Change 6-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ethanol 6-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exhaust, Engine 2-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exterior Lamps 2-36 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

yellowblue
9-5
Fabric
Cleaning 6-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Protection 6-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Features and Controls 2-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Filling
A Portable Container 6
-7 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Your Tank 6-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Filter, Engine Air Cleaner 6-18 . . . . . . . . . . . . . . . . . . . . . . . .
Filter, Engine Oil 6-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Finish
Care 6
-51 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Damage 6-53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
First Gear, Automatic Transaxle 2-22 . . . . . . . . . . . . . . . . . . .
Flashers, Hazard Warning 5-2 . . . . . . . . . . . . . . . . . . . . . . . . .
Flat Tire, Changing 5-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Floor Mats 2-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluids and Lubricants 7-19 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Foreign Countries, Fuel 6-5 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Four-Way Manual Front Seat 1-3 . . . . . . . . . . . . . . . . . . . . . .
French Language Manual ii. . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Parking Bulb Replacement 6
-34 . . . . . . . . . . . . . . . . . . .
Front Turn Signal Bulb Replacement 6-34 . . . . . . . . . . . . . . . .
Fuel 6-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Canadian 6-3, 6-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Filling a Portable Container 6-7 . . . . . . . . . . . . . . . . . . . . . .
Filling Your Tank 6-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gage 2-62 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
In Foreign Countries 6-5 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuses and Circuit Breakers 6-56 . . . . . . . . . . . . . . . . . . . . . . .
Gages
Engine Coolant Temperature 2-56 . . . . . . . . . . . . . . . . . . . .
Fuel 2-62 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GAWR 4-31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gear Positions, Automatic Transaxle 2-18 . . . . . . . . . . . . . . . .
Glove Box 2-40 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GM Mobility Program for Persons with Disabilities 8-5 . . . . .
GM Vehicle Care/Appearance Materials 6-54 . . . . . . . . . . . . .
Gross Axle Weight Rating (GAWR) 4-31 . . . . . . . . . . . . . . . .
Gross Vehicle Weight Rating (GVWR) 4-31 . . . . . . . . . . . . . .
Guide en Fran†ais ii. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GVWR 4
-31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Halogen Bulbs 6-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hazard Warning Flashers 5-2 . . . . . . . . . . . . . . . . . . . . . . . . . .
Head Restraints 1-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Headlamps 2-36 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bulb Replacement 6-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
High/Low Beam Changer 2-31 . . . . . . . . . . . . . . . . . . . . . .
On Reminder 2-36 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wiring 6-56 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hearing Damage 3-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hearing Impaired, Customer Assistance 8-4 . . . . . . . . . . . . . .
Heating 3-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
High-Beam Headlamps 2-31 . . . . . . . . . . . . . . . . . . . . . . . . . .
Highway Hypnosis 4-24 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hill and Mountain Roads 4-24 . . . . . . . . . . . . . . . . . . . . . . . . .
Hitches, Trailer 4-36 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .