1999 CHEVROLET CAVALIER maintenance

yellowblue
7-35
Part C: Periodic Maintenance
Inspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall). You should let your dealer's
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a service manual. See ªService and Owner
Publicationsº in the Index.
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook
-up, binding, leaks,
cracks, chafing, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out
-of-position parts as well as open seams,
holes, loose connections or other conditions which could
cause a heat build
-up in the floor pan or could let
exhaust fumes into the vehicle. See ªEngine Exhaustº in
the Index.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed. Clean the outside
of the radiator and air conditioning condenser. To help
ensure proper operation, a pressure test of the cooling
system and pressure cap is recommended at least once
a year.

yellowblue
7-36 Throttle System Inspection
Inspect the throttle system for interference or binding,
and for damaged or missing parts. Replace parts as
needed. Replace any components that have high effort
or excessive wear. Do not lubricate accelerator and
cruise control cables.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook
-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition. Also inspect drum brake linings
for wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc.
Check parking brake adjustment. You may need to have
your brakes inspected more often if your driving habits
or conditions result in frequent braking.
Caliper/Knuckle Maintenance Inspection
If you operate your vehicle in a highly corrosive
environment, as indicated by the shaded areas on the
map following this text, your vehicle may require
additional brake service. Refer to the appropriate GM
Service Bulletin for the proper caliper inspection
procedure. As necessary, caliper pins and knuckle brake pad abutments should be lubricated at every other tire
rotation. Also, see your GM dealer's service department
or qualified service center for additional information.
X±02±0078±V

yellowblue
7-39
Part E: Maintenance Record
After the scheduled services are performed, record the
date, odometer reading and who performed the service
in the boxes provided after the maintenance interval.Any additional information from ªOwner Checks and
Servicesº or ªPeriodic Maintenanceº can be added on
the following record pages. Also, you should retain all
maintenance receipts. Your owner information portfolio
is a convenient place to store them.
Maintenance Record
DATEODOMETER
READINGSERVICED BYMAINTENANCE PERFORMED

yellowblue
7-40
Maintenance Record
DATEODOMETER
READINGSERVICED BYMAINTENANCE PERFORMED

yellowblue
8-12
CURRENT PUBLICATIONS FOR 1999 CHEVROLET
SERVICE MANUALS
Service Manuals have the diagnosis and repair information
on engines, transmission, axle, suspension, brakes,
electrical, steering, body, etc.
RETAIL SELL PRICE: $90.00
TRANSMISSION, TRANSAXLE, TRANSFER CASE
UNIT REPAIR MANUAL
This manual provides information on unit repair service
procedures, adjustments and specifications for the
1999 GM transmissions, transaxles and transfer cases.
RETAIL SELL PRICE: $50.00
SERVICE BULLETINS
Service Bulletins give technical service information needed
to knowledgeably service General Motors cars and trucks.
Each bulletin contains instructions to assist in the
diagnosis and service of your vehicle.OWNER'S INFORMATION
Owner publications are written directly for Owners and
intended to provide basic operational information about the
vehicle. The owner's manual will include the Maintenance
Schedule for all models.
In-Portfolio: Includes a Portfolio, Owner's Manual and
Warranty Booklet.
RETAIL SELL PRICE: $15.00
Without Portfolio: Owner's Manual only.
RETAIL SELL PRICE: $10.00
CURRENT & PAST MODEL ORDER FORMS
Service Publications are available for current and past
model GM vehicles. To request an order form, please
specify year and model name of the vehicle.
PLEASE COMPLETE THE ORDER FORM SHOWN ON
THE FOLLOWING PAGE AND MAIL TO:
Helm, Incorporated
P.O. Box 07130
Detroit, MI 48207OR ORDER TOLL FREE: 1-800-551-4123
Monday-Friday 8:00 AM ± 6:00 PM Eastern Time
For Credit Card Orders Only (VISA±MasterCard±Discover)
1999 CHEVROLET SERVICE PUBLICATIONS ORDERING INFORMATION
The following publications covering the operation and servicing of your vehicle can be purchased by filling out
the Service Publication Order Form in this book and mailing it in with your check, money order,
or credit card information to Helm, Incorporated (address below.)

yellowblue
9-7
Interior 2-44 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Low Coolant Warning 2-70 . . . . . . . . . . . . . . . . . . . . . . . . .
Oil Pressure 2-73 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Passlock
Warning 2-74 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belt Reminder 1-8, 2-65 . . . . . . . . . . . . . . . . . . . . . .
Up-Shift 2-27, 2-74 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Loading Your Vehicle 4-32 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Locks
Door 2
-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition Transaxle Check 7-33 . . . . . . . . . . . . . . . . . . . . . . .
Key Lock Cylinder Service 7-32 . . . . . . . . . . . . . . . . . . . . .
Power Door 2-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Door Security 2-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Loss of Control 4-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Low Coolant Warning Light 2-70 . . . . . . . . . . . . . . . . . . . . . .
Lowering the Convertible Top Manually 2-57 . . . . . . . . . . . . .
Lowering Your Convertible Top 2-50 . . . . . . . . . . . . . . . . . . .
Lubricants and Fluids 7-37 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lubrication Service, Body 7-32 . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance, Normal Replacement Parts 6-63 . . . . . . . . . . .
Maintenance Record 7-39 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance Schedule 7-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Long Trip/Highway Definition 7-6 . . . . . . . . . . . . . . . . . . .
Long Trip/Highway Intervals 7-6 . . . . . . . . . . . . . . . . . . . . .
Owner Checks and Services 7-30 . . . . . . . . . . . . . . . . . . . . .
Periodic Maintenance Inspections 7-35 . . . . . . . . . . . . . . . .
Recommended Fluids and Lubricants 7-37 . . . . . . . . . . . . .
Scheduled Maintenance Services 7-4 . . . . . . . . . . . . . . . . . . Short Trip/City Definition 7
-5 . . . . . . . . . . . . . . . . . . . . . . .
Short Trip/City Intervals 7-5 . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance, Underbody 6-55 . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance When Trailer Towing 4-41 . . . . . . . . . . . . . . . . .
Malfunction Indicator Lamp 2-70 . . . . . . . . . . . . . . . . . . . . . .
Manual Front Seat 1-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual Lumbar Support 1-3 . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual Remote Control Mirror 2-46 . . . . . . . . . . . . . . . . . . . .
Manual Transaxle 2-16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Check 7-31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid 6-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gear Positions 2-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation 2-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifting 2-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starting Your Engine 2-16 . . . . . . . . . . . . . . . . . . . . . . . . . .
Methanol 6-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mirrors
Convex Outside 2
-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inside Day/Night Rearview 2-46 . . . . . . . . . . . . . . . . . . . . .
Manual Remote Control 2-46 . . . . . . . . . . . . . . . . . . . . . . . .
Power Remote Control 2-46 . . . . . . . . . . . . . . . . . . . . . . . . .
Mobility Program 8-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mountain Roads 4-24 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Multifunction Lever 2-35 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Neutral, Automatic Transaxle 2-22 . . . . . . . . . . . . . . . . . . . .
Neutral, Manual Transaxle 2-26 . . . . . . . . . . . . . . . . . . . . . . . .
New Vehicle ªBreak-Inº 2-13 . . . . . . . . . . . . . . . . . . . . . . . . .
Night Vision 4-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

yellowblue
9-8
Odometer 2-64 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Odometer, Trip 2-64 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Off-Road Recovery 4-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil, Engine 6-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil Pressure Light 2-73 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Overdrive, Automatic Transaxle 2-24 . . . . . . . . . . . . . . . . . . .
Overheating Engine 5-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Owner Checks and Services 7-30 . . . . . . . . . . . . . . . . . . . . . . .
Owner Publications, Ordering 8-11, 8-12 . . . . . . . . . . . . . . . .
Paint Spotting, Chemical 6-55 . . . . . . . . . . . . . . . . . . . . . . . .
Park
Automatic Transaxle 2
-21 . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifting Into 2-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifting Out of 2-31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parking
At Night 2
-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake 2-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake Mechanism Check 7-34 . . . . . . . . . . . . . . . . . . . . . . .
Lots 2-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Over Things That Burn 2-32 . . . . . . . . . . . . . . . . . . . . . . . .
With a Trailer 4-40 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Your Vehicle, Manual Transaxle 2-31 . . . . . . . . . . . . . . . . .
Passenger Position 1-23, 1-29, 1-36 . . . . . . . . . . . . . . . . . . . .
Passing 4-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
With a Trailer 4-38 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Passlock
2-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Warning Light 2-74 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Periodic Maintenance Inspections 7-35 . . . . . . . . . . . . . . . . . . Power
Door Locks 2
-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Option Fuses 6-58 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Remote Control Mirror 2-46 . . . . . . . . . . . . . . . . . . . . . . . .
Steering 4-10, 6-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering Fluid 6-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Windows 2-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power Outlet 2-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pregnancy, Use of Safety Belts 1-22 . . . . . . . . . . . . . . . . . . . .
Problems on the Road 5-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Publications, Service and Owner 8-11, 8-12 . . . . . . . . . . . . . .
Radio Reception 3-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radios
AM
-FM Stereo 3-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
AM-FM Stereo with Cassette Tape 3-9 . . . . . . . . . . . . . . . .
AM-FM Stereo with Cassette Tape and ATC 3-11 . . . . . . .
AM-FM Stereo with Compact Disc and ATC 3-16 . . . . . . .
Rain, Driving In 4-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Raising the Convertible Top Manually 2-57 . . . . . . . . . . . . . .
Raising Your Convertible Top 2-56 . . . . . . . . . . . . . . . . . . . . .
Rear
Door Security Locks 2
-5 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside Seat Position 1-30 . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belt Comfort Guides 1-33 . . . . . . . . . . . . . . . . . . . . .
Seat Passengers 1-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Window Defogger 3-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Turn Signal Bulb Replacement 6-38 . . . . . . . . . . . . . . . .
Rearview Mirror 2-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

yellowblue
9-9
Reclining Front Seatbacks 1-4 . . . . . . . . . . . . . . . . . . . . . . . . .
Recreational Vehicle Towing 4-29 . . . . . . . . . . . . . . . . . . . . . .
Refrigerants, Air Conditioning 6-63 . . . . . . . . . . . . . . . . . . . .
Remote Keyless Entry System 2-6 . . . . . . . . . . . . . . . . . . . . . .
Remote Trunk Release 2-11 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Removing the Boot 2-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacement
Bulbs 6
-62 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parts 6-63 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheel 6-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing Safety Belts 1-55 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reporting Safety Defects 8-10 . . . . . . . . . . . . . . . . . . . . . . . . .
Restraints
Checking 1
-55 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Child 1-40 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Head 1-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing Parts After a Crash 1-55 . . . . . . . . . . . . . . . . . . .
System Check 7-31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reverse, Automatic Transaxle 2-22 . . . . . . . . . . . . . . . . . . . . .
Reverse, Manual Transaxle 2-27 . . . . . . . . . . . . . . . . . . . . . . .
Right Front Passenger Position 1-23 . . . . . . . . . . . . . . . . . . . .
Roadside Assistance 8-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Roadside Assistance, Canadian 8-7 . . . . . . . . . . . . . . . . . . . . .
Rocking Your Vehicle 5-31 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rotation, Tires 6-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belt Extender 1-55 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belts 1-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adults 1-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Care 6-51 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Center Rear Passenger Position 1-36 . . . . . . . . . . . . . . . . . . Children 1
-37 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Driver Position 1-14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Extender 1-55 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
How to Wear Properly 1-13 . . . . . . . . . . . . . . . . . . . . . . . . .
Incorrect Usage 1-18, 1-19, 1-20, 1-21, 1-53, 1-54 . . . . .
Lap Belt 1-36 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lap-Shoulder 1-14, 1-30 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Larger Children 1-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Passenger Position 1-23, 1-29, 1-36 . . . . . . . . . . . . . . . . . .
Questions and Answers 1-12 . . . . . . . . . . . . . . . . . . . . . . . .
Rear Comfort Guides 1-33 . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Seat Outside Passenger Positions 1-30 . . . . . . . . . . . .
Rear Seat Passengers 1-29 . . . . . . . . . . . . . . . . . . . . . . . . . .
Reminder Light 1-8, 2-65 . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing After a Crash 1-55 . . . . . . . . . . . . . . . . . . . . . . . .
Right Front Passenger Position 1-23 . . . . . . . . . . . . . . . . . .
Shoulder Belt Height Adjuster 1-17 . . . . . . . . . . . . . . . . . . .
Smaller Children and Babies 1-37 . . . . . . . . . . . . . . . . . . . .
Use During Pregnancy 1-22 . . . . . . . . . . . . . . . . . . . . . . . . .
Why They Work 1-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Chains 4-38 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Defects, Reporting 8-10 . . . . . . . . . . . . . . . . . . . . . . . .
Safety Warnings and Symbols vi. . . . . . . . . . . . . . . . . . . . . . .
Scheduled Maintenance Services 7
-4 . . . . . . . . . . . . . . . . . . . .
Seatback
Latches 1
-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reclining Front 1-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seats
Easy Entry 1
-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual Front 1-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual Lumbar Support 1-3 . . . . . . . . . . . . . . . . . . . . . . . .
Rear 1-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .