1999 CADILLAC CATERA engine

yellowblue
6-56 Power Distribution Fuse Block
This fuse block is attached to the engine compartment
relay center located on top of the battery. Simply lift the
lid to open. If you have any questions about the power
distribution fuse block, consult your dealer.
Note: If a power loss has occurred, such as
disconnecting the battery or removing the MaxiFuses in
the power distribution fuse block, there are steps that
must be followed to calibrate the Electronic Throttle
Control (ETC). If these steps are not done, the engine
will not run properly. For information regarding these
steps, see ªBatteryº earlier in this section.
Fuses and Circuit Breakers
The wiring circuits in your vehicle are protected from
short circuits by a combination of fuses and circuit
breakers. This greatly reduces the chance of fires caused
by electrical problems.
Look at the silver
-colored band inside the fuse. If the
band is broken or melted, replace the fuse. Be sure you
replace a bad fuse with a new one of the identical size
and rating.
If you ever have a problem on the road and don't have a
spare fuse, you can borrow one that has the same
amperage. Pick some feature of your vehicle that you
can get along without
-- like the radio or cigarette
lighter
-- and use its fuse, if it is the correct amperage.
Replace it as soon as you can.
There are two fuse blocks in your vehicle: the
instrument panel fuse block and the engine compartment
relay center.

yellowblue
6-61
Engine Compartment Relay Center
The relay center is located next to the battery on the
driver's side of the engine. Lift the cover to access.
Fuse/Relay Usage
1 Secondary Air Injection Pump
(Relay K12)
2 Fan Control (Relay K67)
3 Auxiliary Water Pump (Relay K22)
4 Windshield Wiper Motor (Relay K8)
5 A/C Compressor Relay (K60)

yellowblue
6-62
Fuse/Relay Usage
6 Fan Control Relay (K87)
7 Fan Control Relay (K26)
8 Fuse 50
9 Fan Control Relay (K28)
10 Engine Controls Power Relay (K43)
12 Fuse 40
15 Fuse 52
16 Connector C110
17 Coolant Fan Test Connector
Fan Control
18 Fuse 42 (A), Fuse 49 (B)
19 Fan Control Relay (K52)
20 Fuel Pump Relay (K44)
29 Fuse 43Replacement Bulbs
Application Bulb Number
Composite Headlamps
Inner High Beam 90512338. . . . . . . . . . . . . . . . . . .
Outer Low Beam 90512338. . . . . . . . . . . . . . . . . . .
Front Turn Signal Lamp 90487485. . . . . . . . . . . . . . .
Rear Turn Signal Lamp and Taillamp 90002521. . . .
Capacities and Specifications
The following approximate capacities are given in
English and metric conversions. Please refer to
ªRecommended Fluids and Lubricantsº in the
Maintenance Schedule booklet for more information.
Transmission 7.0 quarts (6.6 L). . . . . . . . . . . . . . . . .
Engine Crankcase
Oil Change With Filter 6.0 quarts (5.75 L). . . . . . .
Engine Cooling System 10.57 quarts (10.0 L). . . . . .
Fuel Tank 16.0 gallons (60.56 L). . . . . . . . . . . . . . . . .
R
-134a Refrigerant 2.09 lbs. (0.95 kg). . . . . . . . . . . .
NOTE: All capacities are approximate. When adding, be
sure to fill to the approximate level, as recommended in
this manual. Recheck fluid level after filling.

yellowblue
6-63 Wheel Bolt Torque
80 lb-ft (110 N´m)
Engine Specifications
Displacement 181 cubic inches (2 962 cc). . . . . . . . .
Type 3.0 L DOHC V6. . . . . . . . . . . . . . . . . . . . . . . . .
VIN Engine Code R. . . . . . . . . . . . . . . . . . . . . . . . . . .
Horsepower 200 (bhp) @ 6000 rpm. . . . . . . . . . . . . .
149 (kW) @ 6000 rpm
Torque 192 (lb
-ft) @ 3600 rpm . . . . . . . . . . . . . . . . .
260 (N´m) @ 3600 rpm
Firing Order 1
-2-3-4-5-6 . . . . . . . . . . . . . . . . . . . . . .
Thermostat Starts To Open 198
F (92
C) . . . . . . . . .
Air Conditioning Refrigerants
Not all air conditioning refrigerants are the same.
If the air conditioning system in your vehicle needs
refrigerant, be sure the proper refrigerant is used.
If you're not sure, ask your dealer.
Normal Maintenance
Replacement Parts
Air Filter Element 90509318. . . . . . . . . . . . . . . . . . .
Fuel Filter Element 90542540. . . . . . . . . . . . . . . . . .
Engine Oil Filter 25010792. . . . . . . . . . . . . . . . . . . .
Passenger's Compartment Air Filter 90510338. . . . .
Spark Plugs 90541059 (Bosch Plug = FLR9LTE). . .
Thermostat 90502201. . . . . . . . . . . . . . . . . . . . . . . . .
Windshield Wiper Blades 9118382 (RH). . . . . . . . . . .
9118381 (LH)
Vehicle Dimensions
Wheel Base 107.5 inches (273.0 cm). . . . . . . . . . . . .
Length 194.0 inches (492.8 cm). . . . . . . . . . . . . . . . .
Height 56.4 inches (143.2 cm). . . . . . . . . . . . . . . . . . .
Width 70.3 inches (178.6 cm). . . . . . . . . . . . . . . . . . .
Front Tread 59.3 inches (150.6 cm). . . . . . . . . . . . . . .
Rear Tread 59.8 inches (152.0 cm). . . . . . . . . . . . . . .

yellowblue
7-12
CURRENT PUBLICATIONS FOR 1999 CADILLAC
SERVICE MANUALS
Service Manuals have the diagnosis and repair information
on engines, transmission, axle, suspension, brakes,
electrical, steering, body, etc.
RETAIL SELL PRICE: $90.00
TRANSMISSION, TRANSAXLE, TRANSFER CASE
UNIT REPAIR MANUAL
This manual provides information on unit repair service
procedures, adjustments and specifications for the
1999 GM transmissions, transaxles and transfer cases.
RETAIL SELL PRICE: $50.00
SERVICE BULLETINS
Service Bulletins give technical service information needed
to knowledgeably service General Motors cars and trucks.
Each bulletin contains instructions to assist in the
diagnosis and service of your vehicle.OWNER'S INFORMATION
Owner publications are written directly for Owners and
intended to provide basic operational information about
the vehicle.
Owner's Manual.
RETAIL SELL PRICE: $15.00
CURRENT & PAST MODEL ORDER FORMS
Service Publications are available for current and past
model GM vehicles. To request an order form, please
specify year and model name of the vehicle.
PLEASE COMPLETE THE ORDER FORM SHOWN ON
THE FOLLOWING PAGE AND MAIL TO:
Helm, Incorporated
P.O. Box 07130
Detroit, MI 48207OR ORDER TOLL FREE: 1-800-551-4123
Monday-Friday 8:00 AM ± 6:00 PM Eastern Time
For Credit Card Orders Only (VISA±MasterCard±Discover)
1999 CADILLAC SERVICE PUBLICATIONS ORDERING INFORMATION
The following publications covering the operation and servicing of your vehicle can be purchased by filling out
the Service Publication Order Form in this book and mailing it in with your check, money order,
or credit card information to Helm, Incorporated (address below.)

8-yellowblue
8-1
Section 8 Index
A
dding Equipment to the Outside of Your Vehicle 6-3 . . . . .
Add-On Electrical Equipment 6-55 . . . . . . . . . . . . . . . . . . . . .
Aiming, Headlamps 6-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Bag 1-24 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
How Does it Restrain 1-30 . . . . . . . . . . . . . . . . . . . . . . . . . .
How the Systems Work 1-27 . . . . . . . . . . . . . . . . . . . . . . . .
Location 1-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Readiness Light 1-27, 2-64 . . . . . . . . . . . . . . . . . . . . . . . . .
Servicing 1-32 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
What Makes it Inflate 1-30 . . . . . . . . . . . . . . . . . . . . . . . . . .
What Will You See After it Inflates 1-30 . . . . . . . . . . . . . . .
When Should it Inflate 1-29 . . . . . . . . . . . . . . . . . . . . . . . . .
Air Cleaner/Filter, Engine 6-15 . . . . . . . . . . . . . . . . . . . . . . . .
Air Conditioning 3-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Conditioning Refrigerants 6-63 . . . . . . . . . . . . . . . . . . . . .
Alarm, Theft-Deterrent 2-13 . . . . . . . . . . . . . . . . . . . . . . . . . .
Alignment and Balance, Tire 6-44 . . . . . . . . . . . . . . . . . . . . . .
Aluminum Wheels, Cleaning 6-51 . . . . . . . . . . . . . . . . . . . . . .
Antenna, Heated Backlite 3-31 . . . . . . . . . . . . . . . . . . . . . . . .
Antifreeze 6-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Anti-Lock
Brake System Warning Light 2-67, 4-7 . . . . . . . . . . . . . . . .
Brakes (ABS) 4-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Anti-Lockout Feature 2-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Anti-Pinch Feature 2-33, 2-54 . . . . . . . . . . . . . . . . . . . . . . . . . Appearance Care 6
-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Appearance Care Chart 6-53 . . . . . . . . . . . . . . . . . . . . . . . . . .
Arbitration Program (Step Three) 7-3 . . . . . . . . . . . . . . . . . . .
Ashtrays and Cigarette Lighter 2-50 . . . . . . . . . . . . . . . . . . . .
Assist Handles 2-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Audio Sound Equipment, Adding 3-29 . . . . . . . . . . . . . . . . . .
Audio Steering Wheel Controls 3-27 . . . . . . . . . . . . . . . . . . . .
Audio Systems 3-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Automatic Door Locks 2-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Automatic Operation (Climate Controls) 3-3 . . . . . . . . . . . . . .
Automatic Transmission
Fluid 6
-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation 2-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifting 2-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starting Your Engine 2-18 . . . . . . . . . . . . . . . . . . . . . . . . . .
Warning Light 2-76 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Axle, Rear 6-19 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery 6-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump Starting 5-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacement, Remote Keyless Entry 2-9 . . . . . . . . . . . . . . .
Warnings 5-3, 5-4, 5-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Better Business Bureau (BBB) Mediation (Step Three) 7-3 . . . .
Blade Replacement, Windshield Wipers 6-36 . . . . . . . . . . . . .
Blizzard 4-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

yellowblue
8-2
Brake
Adjustment 6-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid 6-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Master Cylinder 6-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pad Wear Indicator Light 2-76 . . . . . . . . . . . . . . . . . . . . . . .
Parking 2-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pedal Travel 6-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing System Parts 6-29 . . . . . . . . . . . . . . . . . . . . . . . .
System Warning Light 2-66 . . . . . . . . . . . . . . . . . . . . . . . . .
To Shift Light 2-73 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transmission Shift Interlock (BTSI) 2-28 . . . . . . . . . . . . . .
Wear 6-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brakes 6-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Anti-Lock 4-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Trailer 4-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Braking 4-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Braking in Emergencies 4-10 . . . . . . . . . . . . . . . . . . . . . . . . . .
Break-In, New Vehicle 2-16 . . . . . . . . . . . . . . . . . . . . . . . . . .
Brightness Control 2-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bulb Replacement 6-30 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Capacities and Specifications 6-62 . . . . . . . . . . . . . . . . . . . .
Carbon Monoxide 2-11, 2-30, 2-31, 4-28 . . . . . . . . . . . . . . .
Care of Your Cassette Tape Player 3-29 . . . . . . . . . . . . . . . . . .
Care of Your Compact Disc Player 3-31 . . . . . . . . . . . . . . . . .
Care of Your Compact Discs 3-30 . . . . . . . . . . . . . . . . . . . . . .
Carpet Cleaning 6-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cassette Tape Player Errors 3-11, 3-19 . . . . . . . . . . . . . . . . . .
CD Adapter Kits 3-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
CD Changer 3-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Cellular Telephone 2
-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Center Console Storage Area 2-50 . . . . . . . . . . . . . . . . . . . . . .
Center High-Mounted Stoplamp (CHMSL),
Bulb Replacement 6-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Central Door Unlocking System 2-4 . . . . . . . . . . . . . . . . . . . .
Certification Label 4-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Chains, Safety 4-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Chains, Tire 6-45 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Changing a Flat Tire 5-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Charging System Indicator Light 2-65 . . . . . . . . . . . . . . . . . . .
Check Engine Light 2-70 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Check Oil Light 2-73 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking Things Under the Hood 6-8 . . . . . . . . . . . . . . . . . . .
Checking Your Restraint Systems 1-52 . . . . . . . . . . . . . . . . . .
Chemical Paint Spotting 6-52 . . . . . . . . . . . . . . . . . . . . . . . . . .
Child Restraints 1-39 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Securing in a Rear Seat Position 1-44 . . . . . . . . . . . . . . . . .
Securing in the Right Front Seat Position 1-46 . . . . . . . . . .
Top Strap 1-44 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Where to Put 1-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Children (Safety Belts) 1-36 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Chrome-Plated Wheels, Cleaning 6-51 . . . . . . . . . . . . . . . . . .
Cigarette Lighter 2-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cleaner, Air 6-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cleaning
Aluminum or Chrome
-Plated Wheels 6-51 . . . . . . . . . . . . .
Exterior Lamps/Lenses 6-50 . . . . . . . . . . . . . . . . . . . . . . . .
Fabric/Carpet 6-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Glass Surfaces 6-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inside of Your Vehicle 6-46 . . . . . . . . . . . . . . . . . . . . . . . . .
Interior Plastic Components 6-48 . . . . . . . . . . . . . . . . . . . . .

yellowblue
8-3
Leather 6-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside of the Windshield and Wiper Blades 6-48 . . . . . . .
Outside of Your Vehicle 6-49 . . . . . . . . . . . . . . . . . . . . . . . .
Speaker Covers 6-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tires 6-51 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Top of the Instrument Panel 6-47 . . . . . . . . . . . . . . . . . . . . .
Vinyl 6-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheels 6-51 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Climate Control System 3-2 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Clock, Setting the 3-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cluster, Instrument Panel 2-62 . . . . . . . . . . . . . . . . . . . . . . . . .
Comfort Controls 3-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Comfort Controls and Audio Systems 3-1 . . . . . . . . . . . . . . . .
Compact Disc Changer Errors 3-26 . . . . . . . . . . . . . . . . . . . . .
Compartments, Storage 2-49 . . . . . . . . . . . . . . . . . . . . . . . . . .
Console Shift Lever 2-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Console Storage 2-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Control of a Vehicle 4-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Convenience Net 2-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Convex Outside Mirror 2-49 . . . . . . . . . . . . . . . . . . . . . . . . . .
Coolant 6-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adding 6-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking 6-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Heater, Engine 2-19 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
How to Add to the Coolant Surge Tank 5-13 . . . . . . . . . . . .
Surge Tank 5-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
What to Use 6-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cooling System 5-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cornering Lamps 2-44 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Courtesy Transportation 7-8 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cruise Control 2-37 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cruise Control Light 2-74 . . . . . . . . . . . . . . . . . . . . . . . . . . . . Customer Assistance
Information 7
-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Offices 7-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Text Telephone (TTY) Users 7-3 . . . . . . . . . . . . . . . . . . . . .
Customer Satisfaction Procedure 7-2 . . . . . . . . . . . . . . . . . . . .
Damage, Finish 6-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Damage, Sheet Metal 6-51 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Daytime Running Lamps (DRL) 2-42 . . . . . . . . . . . . . . . . . . .
Dead Battery 5-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Defects, Reporting Safety 7-10, 7-11 . . . . . . . . . . . . . . . . . . .
Defensive Driving 4-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Defogger, Rear Window 3-7 . . . . . . . . . . . . . . . . . . . . . . . . . .
Defrosting 3-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dimensions, Vehicle 6-63 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dolby Noise Reduction 3-13, 3-20 . . . . . . . . . . . . . . . . . . . . .
Door
Central Unlocking System 2
-4 . . . . . . . . . . . . . . . . . . . . . . .
Locks 2-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DRIVE (D), Automatic Transmission 2-23 . . . . . . . . . . . . . . .
Driver Position 1-16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Driver's Side Instrument Panel Fuse Block 6-57 . . . . . . . . . . .
Driver's Side Temperature Knob 3-2 . . . . . . . . . . . . . . . . . . . .
Driving
City 4
-19 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Defensive 4-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Drunken 4-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Freeway 4-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
In a Blizzard 4-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
In Foreign Countries 6-5 . . . . . . . . . . . . . . . . . . . . . . . . . . .
In Rain and on Wet Roads 4-17 . . . . . . . . . . . . . . . . . . . . . .