1999 BMW 318is air mass meter




44 162078308546
1210.20-00
27K6300
ENGINE CONTROL
MODULE RELAY
T6151
CYL. 1 IGNITION
COIL
T6153
CYL. 3 IGNITION
COIL
S2
IGNITION SWITCH
1210.20-03
31Y6101
CYL. 1 FUEL
INJECTION VALVE
Y6102
CYL. 2 FUEL
INJECTION VALVE
Y6103
CYL. 3 FUEL
INJECTION VALVE
Y6104
CYL. 4 FUEL
INJECTION VALVE 1210.20-01
26
1210.20-02
RXD
TXD 87
88
R6252
THROTTLE
POSITION
SENSOR 1210.20-05
B6205
INTAKE AIR
TEMPERATURE
SENSOR 1210.20-05
B6203
CRANKSHAFT
POSITION/RPM
SENSOR 1210.20-04
B62001
OXYGEN SENSOR
(IN FRONT OF
CATALYTIC
CONVERTER) 1210.20-04
Y6120
EVAPORATIVE
EMISSION VALVE 1210.20-01
61
A8500
TRANSMISSION
CONTROL MODULE
(EGS) 1210.20-06A6000
ENGINE CONTROL
MODULE (DME)
49
2250
23T6152
CYL. 2 IGNITION
COIL
T6154
CYL. 4 IGNITION
COIL 1210.20-03
X6000

X6000
862853X6000
54
A8500
TRANSMISSION
CONTROL MODULE
(EGS) 1210.20-00
11
1210.20-08
A115
AUTOMATIC
CLIMATE CONTROL
MODULE
1210.20-08
B8y
PRESSURE
SWITCH
1210.20-06
S36y
DOUBLE
TEMPERATURE
SWITCH
68
1210.20-05
K21
NORMAL SPEED
RELAY
57
G6430
B+ JUMP START
JUNCTION POINT0670.2
58Y199
CARBON
CANISTER VALVE
Y6131
INTAKE AIR RES-
ONANCE CHANGE-
OVER VALVE
Y6263
FUEL CHANGE-
OVER VALVE 1210.20-09
Y6130
IDLE SPEED
CONTROL VALVE 1210.20-01
29 X60002



B6209
HALL EFFECT CAM-
SHAFT SENSOR 1210.20-04
B6217
HOT FILM AIR
MASS METER
45
1210.20-06
1721
M2
FUEL PUMP
Y6133
AIR PUMPK6301w
FUEL PUMP RELAY
K6304
SECONDARY AIR
PUMP RELAY
1210.20-041210.20-09
56
K6326
UNLOADER RELAY,
TERMINAL 15 1210.20-02
1210.20-05
A836
ELECTRONIC
IMMOBILIZER
CONTROL MODULE
(EWS II)
10838
A2w
INSTRUMENT
CLUSTER
4280
F165AP90
FRONT POWER
DISTRIBUTION BOX 1210.20-08
36K19
COMPRESSOR
CONTROL RELAY
1210.20-08
191
B6240
KNOCK SENSOR 1210.20-05
40707174
B6232
ENGINE COOLANT
TEMPERATURE
SENSOR 1210.20-05
34 55679
A52
SLIP CONTROL
MODULE
(ABS/ASC) 1210.20-06
323
G6430
B+ JUMP START
JUNCTION POINT0670.2
SPARK PLUGS1210.20-07 1210.20-06
463
G6430
B+ JUMP START
JUNCTION POINT0670.2
1210.20-05
60
DATA LINK
0670.5
77
B62002
OXYGEN SENSOR
(BEHIND
CATALYTIC
CONVERTER) 1210.20-04
B9508
PRESSURE
SWITCH
X6000
D100
DATA LINK
CONNECTOR
1210.20-01
1210.20-09

Y6163
SECONDARY AIR
PUMP VALVE
66 651210.20-04
72
B72
FUEL TANK
PRESSURE
SENSOR 1210.20-05
69
1210.20 ENGINE CONTROL SYSTEM (DME M5.2, 4–CYLINDER M44)





Pin Assignments





E = Input, A = Output, M = Ground
X6000
Pin Type Description/Function Connection
89
MOxygen sensor heating groundOxygen sensor (behind catalytic converter)
90AActivate valveIdle speed control valve
91AActivate valveCyl. 1 fuel injection valve
92AActivate valveCyl. 4 fuel injection valve
93Not used
94MGround, fuel injection valve output stagesGround point
95Not used
96A“Check engine” indicator controlInstrument cluster
97Not used
98EDrive away protection signalElectronic immobilizer control module
(EWS II)
99EActivate A/CPressure switch
100Not used
101Not used
102Not used
103Not used
104EIntake air temperatureIntake air temperature sensor
105MGroundHot film air mass meter
106Not used
107EOxygen sensor signalOxygen sensor (in front of catalytic
converter)
108ECrankshaft position/RPMCrankshaft position/RPM sensor
109ECamshaft positionHall effect camshaft sensor
11 0ACyl. 3 ignition coil controlCyl. 3 ignition coil
111ACyl. 4 ignition coil controlCyl. 4 ignition coil
11 2Not used
11 3Not used
11 4EBattery voltageB+ jump start junction point
11 5AEngine control module relay controlEngine control module relay, terminal 85
11 6MGround for electronics and shielding of
sensorsGround point




Pin Assignments





E = Input, A = Output, M = GroundPin ConnectionDescription/Function Type
11 7
AIdle speed control valve controlIdle speed control valve
11 8MOxygen sensor heating groundOxygen sensor (in front of catalytic
converter)
11 9AActivate valveCyl. 3 fuel injection valve
120AActivate valveCyl. 2 fuel injection valve
121Not used
122MGround, remaning output stages (except for
ingnition and fuel injection valves)Ground point
123Not used
124AA/C compressor cut-outCompressor control relay
125Not used
126Not used
127Not used
128ECyl. 3-4 knock sensorKnock sensor
129Not used
130ETI-measurement signal (fuel consumption)Instrument cluster
131Not used
132EThrottle positionThrottle position sensor
133ESignal inputHot film air mass meter
134MSensor groundOxygen sensors
135Not used
136Not used
137ACyl. 1 ignition coil controlCyl. 1 ignition coil
138ACyl. 2 ignition coil controlCyl. 2 ignition coil
139Not used
140Not used
141AComponent supply +Throttle position sensor
142EBattery voltage from engine control module
relayEngine control module relay, terminal 87
143MGround, ignitionGround point
144EIgnition switch, terminal 15Ignition switch, terminal 15
145AActivate auxiliary fanNormal speed relay
146AActivate valveIntake air resonance change over valve








ENGINE CONTROL SYSTEM (DME M5.2, 4–CYLINDER M44)
34
86
X600068
S36y
DOUBLE
TEMPERATURE
SWITCH X11379
.35 GEA8500
TRANSMISSION
CONTROL MODULE
(EGS)
55
6
1210.20-00
X8500
8685
.35 SW
85 X6000
A6000
ENGINE CONTROL
MODULE (DME)
3
2.5 BR 2.5 BR
.35 SW/GN 2.5 BR
2 X20
.5 BRA52
SLIP CONTROL
MODULE
(ABS/ASC)
1 .5 GE
.5 WS/GR/GE
.35 SW .35 GE
79
X7845
X7846
1X62174
45
2
17
3 X6217
1.5 RT/WS
.5 GR/VI .5 GR/BL

+–
X203
.5 GR/VI
X6454
CAN LOW CAN HIGH
GROUND
DISTRIBUTION
0670.4CAN LOW CAN HIGH
GROUND
DISTRIBUTION
0670.4
CAN HIGH CAN LOW
.35 GE .35 SW B6217
HOT FILM AIR
MASS METER
8
A2w
INSTRUMENT
CLUSTER X16
16 .5 GR
1
.5 GR
42
X17
13 .5 GN/RTX6031
3
.5 GN/RT
313131
9
28
1.5 BR
.75 BR/RT
31
X11706 7 37




COMPONENT LOCATION CHART







COMP.8500.0 7100.0LOCATION DESCRIPTION


B21 . .

ON–BOARD COMPUTER TEMPERATURE
SENSOR . . . . . . . . . . . . . . . . . . . . . . . . . . . .
front RH side of engine compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

20-1


B25y . FUEL TANK SENSOR II . . . . . . . . . . . . . . . . . top of fuel tank

B72 . .
FUEL TANK PRESSURE SENSOR . . . . . . . .
RH rear wheel well behind trim panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
14-1

B78 . .

DRIVER’S SIDE IMPACT SENSOR . . . . . . .

in lower LH B–pillar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

39-2


B79 . . PASSENGER’S SIDE IMPACT SENSOR . . . in lower RH B–pillar
B6203 CRANKSHAFT POSITION/RPM SENSOR . front of engine below . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10-3

B6204
CAMSHAFT POSITION SENSOR
(CYLINDER IDENTIFICATION) . . . . . . . . .
front of engine below intake manifold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

12-2



B6204
CAMSHAFT POSITION SENSOR
(CYLINDER IDENTIFICATION) . . . . . . . . .
front of engine below intake manifold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

11-1


B6205 INTAKE AIR TEMPERATURE SENSOR . . . front LH side of engine compartment (318i) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18-2

B6205
INTAKE AIR TEMPERATURE SENSOR . . .
LH side of engine near oil level stick . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
36-3

B6207 HOT FILM AIR MASS METER . . . . . . . . . . . . LH side of engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12-1
B6209 HALL EFFECT CAMSHAFT SENSOR . . . . . front of engine (318i)
B6217 HOT FILM AIR MASS METER . . . . . . . . . . . . top front of engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18-2
B6231 OIL PRESSURE SWITCH . . . . . . . . . . . . . . . . front of engine below intake manifold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-1

B6231
OIL PRESSURE SWITCH . . . . . . . . . . . . . . . .
front of engine below intake manifold (318i) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
17-1



B6232

ENGINE COOLANT TEMPERATURE
SENSOR . . . . . . . . . . . . . . . . . . . . . . . . . . . .
front of engine below intake manifold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
11-3



B6232

ENGINE COOLANT TEMPERATURE
SENSOR . . . . . . . . . . . . . . . . . . . . . . . . . . . .
front of engine below intake manifold (318i) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
17-2



B6236

ENGINE COOLANT TEMPERATURE
SENSOR . . . . . . . . . . . . . . . . . . . . . . . . . . . .
front of engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
11-3




COMPONENT LOCATION VIEWS







B6207
HOT FILM AIR
MASS METER
Y6101
CYL. 1 FUEL
INJECTION VALVE B6204
CAMSHAFT
POSITION SENSOR
(CYLINDER
IDENTIFICATION)
X6275
Y6102
CYL. 2 FUEL
INJECTION VALVE
Y6103
CYL. 3 FUEL
INJECTION VALVEY6104
CYL. 4 FUEL
INJECTION VALVE
Y6105
CYL. 5 FUEL
INJECTION VALVE
Y6106
CYL. 6 FUEL
INJECTION VALVE X6207
X6252X10094





Y6275
VARIABLE CAM-
SHAFT CONTROL
VALVE 1X10239




COMPONENT LOCATION VIEWS







M9
AUXILIARY FAN
MOTOR
B18
BRAKE FLUID
LEVEL SWITCH B6205
INTAKE AIR
TEMPERATURE
SENSOR
S123
ABS PEDAL TRAV-
EL SENSOR
X20
X69X111X1162
S63
ENGINE COOLANT
LEVEL SWITCH
X82
X112


318i
B6217
HOT FILM AIR
MASS METERX70
X6205X6217
M25
CRUISE CONTROL
ACTUATOR
(TEMPOMAT)