Page 27 of 65
20-152
If LED does not light up:
Electrical Wiring Diagrams, Troubleshooting & Component Locations
If wiring is OK:
Repair Manual, Fuel Injection & Ignition, Repair Group 24 - Check electrical wiring from terminal 3 via fuse for fuel pump relay for
open circuit. - Repair wiring as necessary.
- Check fuel pump relay:
Pa
ge 27 of 65 EVAP s
ystem, servicin
g
11/18/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE04.20.5
Page 56 of 65
20-176
EVAP system leak detection circuit,
schematic diagram (vehicles with 1.8 ltr.
turbo engine)
Repair Manual, 1.8 Liter 4-Cyl. 5V Turbo Fuel
Injection & Ignition, Repair Group 24 1 -
Check valve
Location (light/dark side): as shown in
illustration
2 -
EVAP canister purge regulator valve -N80-Location: in engine compartmentChecking
3 -
Bleed line
From EVAP canister purge regulator valve
-N80-
LocationRight side under floor panFront-wheel drive: on floor pan in area of
fuel tank All-wheel drive: on fuel tank in area of fuel
tank
Pa
ge 56 of 65 EVAP s
ystem, servicin
g
11/18/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE04.20.5
Page 60 of 65
20-180
EVAP system leak detection circuit,
schematic diagram (vehicles with 2.8 ltr.
engine)
Repair Manual, 2.8 Liter V6 5V Fuel Injection &
Ignition, Repair Group 24 1 -
Throttle actuator control module -J338-
2 -
EVAP canister purge regulator valve -N80-Location: in engine compartmentChecking:
3 -
Bleed line
From EVAP canister to EVAP canister
purge regulator valve -N80-
LocationOn right side under floor panVehicles with front-wheel drive: mounted
on floor pan in area of fuel tank Vehicles with all-wheel drive: mounted on
fuel tank
Pa
ge 60 of 65 EVAP s
ystem, servicin
g
11/18/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE04.20.5
Page 63 of 65
20-183
EVAP system leak detection circuit,
schematic diagram (vehicles with 2.7 ltr.
turbo engine)
Repair Manual, 2.7 Liter V6 5V BiTurbo Fuel
Injection & Ignition, Engine Code(s): APB, Repair Group 24
1 -
To air intake before both turbo chargers
2 -
Check valve Installation position: Arrow at housing
indicates flow-through direction.
3 -
Evaporative Emission (EVAP) canister
purge regulator valve -N80- Location: On right side of engine
compartment Checking:
4 -
Vent line
From EVAP canister to EVAP canister
purge valve regulator valve -N80 Installation position: On right side on
vehicle under-side. Attached to fuel tank.
Pa
ge 63 of 65 EVAP s
ystem, servicin
g
11/18/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE04.20.5
