1998 VOLKSWAGEN BORA battery

Downloaded from www.Manualslib.com manuals search engine 01-215


V.A.G 1551 print-out
Possible cause
Repair
01276
ABS hydraulic pump -
V64-
Electrical malfunction in
current circuit
1)
Battery positive fuse faulty- Check fuses


Open circuit, short to positive
or ground in the wiring - Check wiring and
connections using wiring
diagram
- Perform electrical check
Page 01
-288

Hydraulic pump -V64- faulty
Repair Manual, Brake
System, Repair Group 45
Replace ABS hydraulic unit
-N55-
1) This DTC is only recognized above 20 km/h (13 mph) (carry out test drive).
Стр. 57из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine
01-293


Contact
Wiring connection to component ...
1
Voltage supply fr om battery +
2
Connector T16/7, K wire
3

Longitudinal acceleration sens or -G251- sensor wire(4MOTION vehicles only)
Vacant (4MOTION vehicles with ESP-sensor unit -G419, vehicles from 11.01)
4
Voltage supply from igni tion/starter switch
5

Longitudinal acceleration se nsor -G251- Ground(4MOTION vehicles only)
Vacant (4MOTION vehicles with ESP-sensor unit -G419- , vehicles from 11.01)
6

Sensor for transverse acceleration -G200-
Voltage supply for ESP-sensor unit -G419-, vehicles from 02.02
7

Longitudinal acceleration se nsor -G251- voltage supply(4MOTION vehicles
only)
Vacant (4MOTION vehicles with ESP-sensor unit -G419- , vehicles from 11.01)
8
Vehicles with navi gation system only
9
Coding bridge to contact 12 (vehicle s with ABS/EDL/ASR/ESP 4MOTION
only)
10
Vehicles with navi gation system only
11
Data bus wire Wiring diagrams
12
Coding bridge to contact 9 (vehicles with ABS/EDL/ASR/ESP 4MOTION only)
Coding bridge to contact 38 (vehicles with ABS/EDL/ASR/ESP front wheel
drive only)
Стр. 6 из 38
Electrical check of Mark 60
Volkswagen Technical Site: http://v olkswagen.msk.ru http://vwts.info http://vwts.ru
огромный архив документации по автомобилям Volkswagen, Skoda, Seat, Audi

Downloaded from www.Manualslib.com manuals search engine 01-295


Contact
Wiring connection to component ...
27
Vacant
28
Vacant
29

Vacant
Data bus wire for ESP-sensor unit -G419-
30
Vacant
31
Vacant
32
Voltage supply from battery +
33
Right front ABS wheel speed sensor -G45-
34
Right front ABS wheel speed sensor -G45-
35
Vacant
36
Left rear ABS wheel speed sensor -G46-
37
Left rear ABS wheel speed sensor -G46-
38

Coding bridge to contact 12 (vehicles with ABS/EDL/ASR/ESP front wheel
drive only)
Coding bridge to contact 14 (vehicles with ABS and ABS/EDL/ASR front wheel
drive only)
Стр. 8из 38 Electrical check of Mark 60

Downloaded from www.Manualslib.com manuals search engine 01-301


Switch to measuring range:
Voltage measurement (20 V =)
Test
step V.A.G
1598
sockets Item tested
Test
conditions
- Additional
operations Specification
Measures for
deviations from
specification
3 4 + 47 Voltage supply
(ignition/starter
switch) to ABS
Control Module
(w/EDL) -J104-
Ignition
switched
on 10.0 - 14.5 V
Electrical Wiring
Diagrams,
Troubleshooting &
Component
Locations binder - Check wiring using
wiring diagram
4 47 + 41 Function of brake
light switch -F- Ignition
switched
off
Brake
pedal not
depressed
0.0 - 0.5 V - Check brake light
switch -F- and read
measured value
block Page 01-
240 , Display group
number 003

- Depress
brake pedal Approx.
battery
voltage
Repair Manual,
Brake System,
Repair Group 46;
Brake pedal -
Assembly overview;
Adjusting brake light
switch
Electrical Wiring
Diagrams,
Troubleshooting &
Component
Locations binder - Adjusting brake
light switch
- Check wiring using
wiring diagram
Стр. 14из 38 Electrical check of Mark 60