1998 PONTIAC FIREBIRD radiator

1
If this light comes on, it
means you’re
low on
5.7L Engine
Adding Coolant to the Recovery Tank
If you need more coolant, add the proper DEX-COOL@
coolant mixture at the coolant recovery tank, but only
when your engine is cool. If the tank is very low or
empty,
also add coolant to the radiator. See “Engine
Overheating’’
in the Index for information.
A CAUTION:
Thrning the radiator pressure cap when the
engine and radiator are hot can allow steam
and scalding liquids to blow out and burn you
badly. Never turn the pressure cap
-- even a
little -- when the engine and radiator are hot.
L
Add coolant mixture at the recovery tank, but be careful
not to spill it.
I /1 CAUTION:
You can be burned if you spill coolant on hot
engine parts. Coolant contains ethylene glycol,
and it will burn if the engine parts are hot
enough. Don’t spill coolant on a hot engine.
I

Radiator Pressure Cap (All Engines)
I NOTICE:
Your radiator cap is an 18 psi (124 kPa)
pressure-type cap and must be tightly installed to
prevent coolant loss and possible engine damage
from overheating. Be sure the arrows on the cap
line up with the overflow tube on the radiator
filler neck.
When you replace your radiator pressure cap, a GM cap
is recommended.
Thermostat
Engine coolant temperature is controlled by a thermostat
in the engine coolant system. The thermostat stops the
flow of coolant through the radiator until the coolant
reaches a preset temperature.
When you replace your thermostat, a GM thermostat
is
recommended.
Power Steering Fluid
The power steering fluid
reseivoir is locatei toward
the back
of the engine on
the driver’s side.
When to Check Power Steering Fluid
It is not necessary to regularly check power steering fluid
unless you suspect there is a leak in the system or you hear
an unusual noise. A fluid loss in this system could indicate
a problem. Have the system inspected
and repaired.
How To Check Power Steering Fluid
When the engine compartment is cool, wipe the cap and
the top of the reservoir clean, then unscrew the cap and
wipe the dipstick with a clean rag. Replace
the cap and
completely tighten it. Then remove the cap again and
look at the fluid level on the dipstick.
6-31

Vehicle Dimensions
Wheelbase ............ 101.1 inches (256.6 cm)
Front Tread
............. 60.7 inches (154.1 cm)
RearTread
............. 60.7inches(154.1 cm)
Length Firebird
/ Formula . . 193.5 inches (491.5 cm)
Length Trans Am ....... 193.9 inches (492.1 cm)
Width
............... 74.5 inches (1 89.3 cm)
Height.
.................. 52 inches (132.1cm)
Normal Maintenance Replacement Parts
Air Cleaner Filter VIN Engine Code
K .................. A1163C
VIN Engine Code G .................. A1163C
VIN Engine Code G
(with WS6 Option) .................. A1097C
Battery
................................ 75-60 Engine
Oil Filter
VIN Engine
Code K .................... PF47
VIN Engine Code
G .................... PF44
Fuel Filter
............................. GF578
PCV Valve
VIN Engine Code
K ............... CV892C
VIN Engine Code G ................. CV895C
Radiator Cap ......................... RC24
Spark Plug
VIN Engine Code
K .... 41-921 (0.060 inch Gap)
VIN Engine Code G .... 41-931 (0.060 inch Gap)
Air Conditioning Refrigerants
Not all air conditioning refrigerants are the same. If the
air conditioning system in your vehicle needs
refrigerant, be sure the proper refrigerant
is used. If
you’re not sure
ask your dealer.
6-70

I Short TripKity Maintenance Schedule I
150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system (or every 60 months since last service,
whichever occurs first).
See “Engine Coolant” in the Index for what to use.
Inspect hoses. Clean radiator, condenser, pressure cap and neck.\
Pressure test
cooling system and pressure cap.
An Emission Control Service.
7-21

150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system (or every 60 months since last service,
whichever occurs first). See “Engine Coolant” in the Index for what to use.
DATE 1
MILEAGE ACTUAL I SERVICED BY:
Inspect hoses. Clean radiator, condenser, pressure cap and neck.\
Pressure test I I I
the cooling system and pressure cap.
An Emission Control Service.
7-31

Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall). You should let your dealer’s service
department or other qualified service center do these
jobs. Make sure any necessary repairs are completed
at once.
Proper procedures to perform these services may be
found in a service manual. See “Service and Owner
Publications” in the Index.
Steering and Suspension Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing
parts, signs of
wear or lack of lubrication. Inspect the power steering
lines
and hoses for proper hook-up, binding, leaks.
cracks, chafing, etc.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which could
cause a heat build-up in the floor pan
or could let
exhaust fumes into the vehicle. See “Engine Exhaust”
in
the Index.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect a11 pipes,
fittings and clamps; replace as needed. Clean the outside
of the radiator
and air conditioning condenser. To help
ensure proper operation, a pressure test of the cooling
system and pressure cap is recommended at least once
a year.
7-36

Oil. Engine .................................... 6- 12
Oil Pressure Gage .............................. 2-88
Overdrive. Automatic Transmission ................ 2-32
Overheating Engine ............................. 5- 15
Owner Checks and Services ....................... 7-32
Owner Publications. Ordering ..................... 8- 12
paint Spotting. Chemical ........................ 6-60
PARK (P)
Automatic Transmission ....................... 2-30
Shifting Into ................................. 2-39
Shifting Out of ............................... 2-41
AtNight .................................... 2-13
Brake ...................................... 2-44
Brake Mechanism Check ....................... 7-35
Lots ....................................... 2-13
OverThingsThatBurn ........................ 2-42
With a Trailer ................................ 4-38
Parking Your Vehicle. Manual Transmission .......... 2-41
Passenger Position ......................... 1-22. 1-28
PASS-Key (8, II ................................. 2-17
Periodic Maintenance Inspections .................. 7-36
Pontiac Cares Information ......................... 8-2
Power
Antenna
Mast Care ............................ 3-22
DoorLocks ................................... 2-5
Option Fuses ................................ 6-63
Remote Control Mirror ........................ 2-57
Parking
Passing
....................................... 4-13
Retained Accessory ........................... 2-56
Six-WaySeat ................................. l-3
Steering .................................... 4-10
SteeringFluid ................................ 6-31
Windows ................................... 2-45
Pregnancy, Use of Safety Belts .................... 1-21
Problems on the Road ............................ 5-1
Publications, Service and Owner ................... 8-12
Radiator ................................ 5.21. 5.24
Radiator Pressure Cap ........................... 6-31
Radio Reception ................................ 3-20
Radios .......................... 3.7.3.8.3.11. 3.12
Rain. DrivingIn ................................ 4-17
Rear
RAP ......................................... 2-56
Axle ....................................... 6-27
Lamp Bulb Replacement ....................... 6-41
Seat Passengers .............................. 1-28
Sidemarker Bulb Replacement ................... 6-42
Towing ..................................... 5-13
Window Defogger ............................. 3-5
Rearview Mirror, Inside Daymight ................. 2-57
Reclining Front Seatbacks ......................... 1-5
Recommended Fluids and Lubricants ............... 7-38
Recovery Tank. Coolant .......................... 5-19
Refrigerants, Air Conditioning .................... 6-70