1998 OLDSMOBILE INTRIGUE radiator

What to Use
Use a mixture of one-half clean water (preferably
distilled) and one-half
DEX-COOL@ coolant which
won’t damage aluminum
parts. If you use this mixture,
you don’t need to add anything else.
Addlrlg only plain water to your cooling system
can be dangerous. Plain water, or some other
liquid like alcohol, can boil before the proper
coolant mixture will. Your vehicle’s coolant
warning system
is set for the proper coolant
mixture. With plain water or the wrong mixture,
your engine could get too hot but you wouldn’t
get the overheat warning. Your engine could
catch fire and you or others could be burned.
Use
a 50/50 mixture of clean water and
DEX-COOL@ coolant.
NOTICE:
If you use an improper coolant mixture, your
engine could overheat and be badly damaged.
The repair cost wouldn’t be covered by your
warranty. Too much water in the mixture can
freeze and crack the engine, radiator, heater core
and other parts.
If you have to add coolant more than four times a year,
have your retailer check your cooling system.
NOTICE:
If you use the proper coolant, you don’t have to
add extra inhibitors or additives which claim to
improve the system. These can be harmful.
6-22
ProCarManuals.com

Checking Coolant
The coolant recovery tank is located in the engine
compartment behind the headlamp on
the driver’s side.
When your engine is cold, the coolant level should be at
the COLD mark or a little higher. When your engine is
warm, the level should be up to
HOT mark. To check
the coolant level, remove the cap on the coolant
recovery tank and verify that the coolant level is up to
the COLD fill level on the hose attached to
the cap, or a
little higher.
&I If this low coolant
warning light comes on,
it means you’re low on
engine coolant.
Adding Coolant
If you need more coolant, add the proper DEX-COOL@
coolant mixture
at the coolant recovery tank, but be
careful not to spill it.
If the coolant recovery tank is completely empty, add
coolant to
the radiator. (See “Engine Overheating” in
the Index.)
6-23
ProCarManuals.com

'
A CAUTION: I
'hrning the radiator pressure cap when the
engine and radiator are hot can allow steam and
scalding liquids to blow out and burn you badly.
With the coolant recovery tank, you will almost
never have to add coolant at the radiator.
Never turn the radiator pressure cap
-- even a
little -- when the engine and radiator are hot.
You can be burned if
you spill coolant on hot
engine parts. Coolant contains ethylene glycol,
and it will burn if the engine parts are hot
enough. Don't spill coolant on
a hot engine.
Radiator Pressure Cap
NOTICE:
Your radiator cap is a 15 psi (105 kPa)
pressure-type cap and must be tightly installed
to
prevent coolant loss and possible engine damage
from overheating. Be sure the arrows
on the cap
line up with the overflow tube
on the radiator
filler neck.
When you replace your radiator pressure cap, an
AC@
cap is recommended.
Thermostat
Engine coolant temperature is controlled by a thermostat
in the engine coolant system.
The thermostat stops the
flow of coolant through the radiator until the coolant
reaches a preset temperature.
When you replace your thermostat, an
AC@ thermostat
is recommended.
6-24
ProCarManuals.com

Normal Maintenance
Replacement Parts
Air Cleaner Filter
3800 (Code K) ....................... A1208C
Passenger Compartment Air Filter .... 10406026
3800 (Code K) ...................... 690 CCA
3800 (Code K) ................. AC Type PF47
3800 (Code K) ...................... CV892C
3800 (Code K) ......................... RC27
3800 (Code K) ................ AC Type 4 1-921
Battery
Engine Oil Filter
PCV Valve
Radiator Cap
Spark Plugs
Gap: 0.060” (. 152 cm)
Windshield Wiper Blade Replacement
Length ..................... 20 inches (5 1 cm)
Type
................................... Pin
Air Conditioning Refrigerants
Not all air conditioning refrigerants are the same.
If the air conditioning system in your vehicle needs
refrigerant,
be sure the proper refrigerant is used.
If you’re not
sure, ask your retailer.
6-64
ProCarManuals.com

I Maintenance Schedule I
100,000 Miles (166 000 km)
Inspect spark plug wires.
0 Replace spark plugs.
0 Change automatic transaxle fluid and filter if the vehicle is mainly driven
An Emission Control Service.
An Emission Control Service.
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly reaches
90°F (32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, the fluid and
filter do not require changing.
150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system (or every 60 months since last service,
whichever occurs
first). See “Engine Coolant” in the Index for what to use.
Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test
the cooling system and pressure cap.
An Emission Control Service.
DATE
MILEAGE
ACTUAL I SERVICEDBY I
I DATE I
1 MILEAGE ACTUAL I SERVICEDBY: I
7-12
ProCarManuals.com

Part C: Periodic
Maintenance Inspections
Listed below are inspections and services which should be
performed at least twice a year (for instance, each spring
and fall).
You should let your retailer’s service department
or other qualiJied service center do these jobs. Make sure
any necessary repairs are completed at once.
Proper procedures to perform these services may be
found in a service manual. See “Service and Owner
Publications” in the Index.
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc. Clean and then
axle boot seals for damage, tears or
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. inspect
the drive
leakage. Replace
Inspect the body near
the exhaust system. Look for broken, damaged, missing
or
out-of-position parts as well as open seams, holes, loose
connections or other conditions which could cause a heat build-up in
the floor
pan or could let exhaust fumes into
the vehicle. See “Engine Exhaust” in the Index.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes, fittings
and clamps; replace as needed. Clean the outside
of the
radiator and air conditioning condenser.
To help ensure
proper operation, a pressure
test of the cooling system
and pressure cap
is recommended at least once a year.
Throttle System Inspection
Inspect the throttle system for interference or binding,
and for damaged or missing parts. Replace parts as
needed. Replace any components that have high effort
or excessive wear. Do not lubricate accelerator and
cruise control cables.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition. Inspect other brake parts,
including calipers, parking brake, etc. Check parking
brake adjustment. You may need to have your brakes
inspected more often if your driving habits
or conditions
result in frequent braking.
7-17
ProCarManuals.com

Mirrors ....................................... 2-43
Convex Outside
.............................. 2-46
Power Outside
............................... 2-46
MountainRoads
................................ 4-23
Multifunction Lever
............................. 2-3 1
Inside
Daymight Rearview
..................... 2-43
Net. Convenience
.............................. 2-48
Neutral. Automatic Transaxle
..................... 2-2 1
New Vehicle “Break-In” ......................... 2- 15
Nightvision
................................... 4-16
Normal Maintenance Replacment Parts
.............. 6-64
Odometer
.................................... 2-53
Odometer. Trip
................................. 2-54
Off-Road Recovery
............................. 4- 13
Oil. Engine
.................................... 6-11
Outside Mirrors
................................ 2-46
Overheating Engine
............................. 5 - 15
Owner Checks and Services
....................... 7- 13
Owner Publications. Ordering
................. 8-9. 8-10
Paint Spotting. Chemical ........................ 6-53
PARK (P)
Shifting Into
................................. 2-25
Shifting Out
of ............................... 2-27
PARK (P). Automatic Transaxle
................... 2-20
Parking AtNight
.................................... 2-14
Brake
...................................... 2-24
Brake Mechanism Check
....................... 7-16
Lots
....................................... 2-14 Over Things
That Burn
........................ 2-27
With a Trailer
................................ 4-36
Passenger Compartment Air Filter
.................. 6-17
Passing
....................................... 4-13
Passing with a Trailer
............................ 4-35
Passlock@
..................................... 2-14
Power Passenger
Position
.............................. 1 . 19
Periodic Maintenance Inspections
.................. 7-17
Accessory Outlets
............................ 2-48
DoorLocks
................................... 2-4
Outside Mirrors .............................. 2-46
Seats
........................................ 1-3
Steering
.................................... 4-11
Steering Fluid
................................ 6-25
Sunroof
..................................... 2-49
Windows
................................... 2-29
Howtocheck
............................... 6-25
WhattoUse
................................. 6-25
When to Check
............................... 6-25
PowerSunroof
................................. 2-49
Pregnancy, Use of Safety Belts
.................... 1-18
Problems on the Road ............................ 5-1
Programmable Automatic Power Door Locks .......... 2-6
Publications, Service and Owner
.................... 8-9
Radiator ..................................... 5-21
How to Add Coolant to the
..................... 5-21
Radiator Pressure Cap
......................... 6-24
Radio Reception
................................ 3-25
Radios .................................. 3-10, 3-14
Power
Steering
9-7
ProCarManuals.com