1998 Mercury Villager engine coolant

Use specially formulated windshield washer fluid rather than
plain water, because specially formulated washer fluids contain
additives that dissolve road grime. For safety reasons,
washer fluids containing an appropriate antifreeze such as
methanol should be used in freezing weather (temperatures below
32É F [0É C]). State or local regulations on Volatile Organic
Compounds (VOCs) may restrict use of the most common
antifreeze, methanol. Washer fluids containing non-methanol
antifreeze agents should be used only if they provide cold weather
protection without damaging the vehicle's paint finish, wiper
blades, and windshield washer system.
Engine Coolant
Checking the Engine Coolant
NOTE: Be sure to read and understandPrecautions When
Servicing Your Vehicleat the beginning of this chapter.
Your vehicle's engine coolant protects the engine from overheating
in the summer and from freezing in the winter. Check the level
of the engine coolant at least once a month, but preferably each time
you stop for fuel. Simply check the coolant reservoir, located in
the engine compartment. The coolant should stay between the MIN
and MAX marks. It will be closer to MAX when the engine is
warm and closer to MIN when the engine is cold. To locate the
coolant reservoir, see the diagram of your vehicle's engine
underEngine Compartmentin theCapacities and Specifications
chapter.
Maintenance and Care
285

Adding Engine Coolant
WARNING
Do not put engine coolant in the container for the
windshield washer fluid.
When the engine is cool, add a 50/50 mixture of engine coolant
and water to the engine coolant recovery reservoir Ð DO
NOT ADD DIRECTLY TO THE RADIATOR. Add straight water
only in an emergency, but you should replace it with a 50/50
mixture of coolant and distilled water as soon as possible.
Engine coolant recovery reservoir
286

Check the coolant level in the coolant recovery reservoir the next
few times you drive the vehicle. If necessary, add enough of a
50/50 mixture of coolant and water to bring the liquid level to the
fill line on the reservoir.
WARNING
Never remove the coolant recovery cap while the engine is
running or hot.
If you must remove the coolant recovery cap, follow these steps
to avoid personal injury caused by escaping steam or engine
coolant:
1. Before you remove the cap, turn the engine off and let it cool.
2. When the engine is cool, wrap a thick cloth around the
cap. Slowly turn cap counterclockwise to the first stop.
3. Step back while the pressure releases.
4. When you are sure that all the pressure has been released, use
the cloth to press the cap down, turn it counterclockwise, and
remove it.
Use Ford Premium Engine Coolant E2FZ-19549-AA (in Canada,
Motorcraft CXC-8-B) or an equivalent premium engine coolant that
meets Ford Specification ESE-M97B44-A. Ford Premium Engine
Coolant is an optimized formula that will protect all metals and
rubber elastomers used in Ford cooling systems for 4 years or
50,000 miles (80,000 km).
Do not use alcohol or methanol antifreeze or any engine coolants
mixed with alcohol or methanol antifreeze. Do not use
supplemental coolant additives in your vehicle. These additives
may harm your engine cooling system.The use of an improper coolant
may void the warranty of your vehicle's engine cooling system.
Maintenance and Care
287

Recycled Engine Coolant
Ford Motor Company recommends that Ford and
Lincoln-Mercury dealers use recycled engine coolant produced by
Ford-approved processes. Not all coolant recycling processes
produce coolant which meets Ford specification ESE-M97B44-A,
and use of such coolant may harm engine and cooling
system components.
Always dispose of used automotive fluids in a responsible
manner. Follow your community's regulations and standards for
recycling and disposing of automotive fluids.
Coolant Refill Capacity
To find out how much fluid your vehicle's cooling system can
hold, seeRefill capacities for fluidsin the Index.
Have your dealer check the engine cooling system for leaks if
you have to add more than a quart (liter) of engine coolant per
month.
Severe Winter Climate
If you drive in extremely cold climates (less than -34É F [-36É C]),
it may be necessary to increase the coolant concentration
above 50%. Refer to the chart on the coolant container to ensure
the coolant concentration in your vehicle is such that the
coolant will not freeze at the temperature level in which you
drive during winter months. Never increase the engine coolant
concentration above 60%. Leave a 50/50 mixture of engine coolant
and water in your vehicle year-round in non-extreme climates.
Checking hoses
Inspect all engine and heater system hoses for deterioration, leaks
and loose clamps before adding or replacing engine coolant.
Make whatever repairs or replacements are necessary using
Motorcraft parts or their equivalents.
288

Engine Coolant Drain and Flush
To have your engine coolant drained, see your Ford or
Lincoln-Mercury dealer or refer to the procedure in the Service
Manual.
Power Steering Fluid
Check the level of the power steering fluid at least twice a year
(i.e., every Spring and Fall).
Checking and Adding Power Steering Fluid
1. Start the engine and let it run until the power steering fluid
reaches normal operating temperature. The power steering
fluid will be at the right temperature when the engine coolant
temperature gauge in the instrument cluster is near the
center of the NORMAL operating temperature range.
2. While the engine idles, turn the steering wheel back and forth
several times. Make sure that the cap assembly is installed at
this time.
3. Then turn the engine off.
4. Check the fluid level in the power steering fluid reservoir.
Maintenance and Care
289

Engine Compartment
Your vehicle has a 3.0 liter EFI, V-6 engine. The following
illustration will show a diagram of your engine and where you
can find items that you should service regularly.
1. Automatic Transmission Fluid Dipstick
2. Engine Coolant Reservoir
3. Brake Fluid Reservoir
4. Air Filter
5. Battery
6. Engine Compartment Fuse and Relay Box
7. Radiator Cap
8. Engine Oil Filler Cap
9. Engine Oil Dipstick
10. Windshield Washer Fluid Reservoir
11. Engine Compartment Relay Box
12. Power Steering Fluid Reservoir
Capacities and Specifications
341

A
Accessory position on the ignition..............86
Air bag supplemental restraint system...........144
and child safety seats..................153
description.....................144, 146
driver air bag....................144, 146
indicator light.......................11
operation........................146
passenger air bag....................146
service and information labels..............146
tone generator....................149, 149
Air cleaner filter
location.........................341
Alcohol
in fuel..........................310
Antenna, radio (see Electronic sound system).......29,84
Antifreeze (see Engine coolant)...............285
Anti-lock brake system (ABS)
description........................215
noise...........................215
see also Brake......................215
warninig light.......................9
Anti-theft lug nuts and key.................261
Anti-theft system
triggering........................116
Appeals (see Dispute settlement board)...........348
Assistance (see Customer assistance)............345
Audio system (see Electronic sound system).........29
Automatic transaxle
driving with.......................221
fluid, adding....................291, 292
fluid, checking......................291
fluid, specification....................339
Index
373

Controls
mirrors..........................109
Convenience kit in cargo area................255
Coolant (see Engine coolant)................285
checking and adding...................285
drain and flush.....................289
preparing for storage...................335
specifications.......................339
temperature gauge...................18,23
warnings.........................285
Cooling fan.........................276
Customer Assistance Centre, Ford of Canada........352
D
Daytime running light system................78
Defrost
rear window.......................75
windshield........................56
Dipstick..........................281
automatic transaxle fluid.................291
engine oil........................281
power steering fluid.................289, 289
Disabled vehicle (see Towing)................272
Dispute Settlement Board..................348
Doors............................97
door ajar warning light..................15
lubricant specifications..................339
Driving under special conditions
heavy load........................226
towing a trailer.....................227
Index
377