1998 Mercury Villager check engine light

Trailer Towing Tips
Before starting on a trip, practice turning, stopping and backing
in an area away from heavy traffic. Get to know the ªfeelº of
the vehicle/trailer combination.
Practice backing up. Back up very slowly, with someone outside
at the rear of your trailer to guide you. Place your hand at
the bottom of the steering wheel and move it in the direction you
want the rear of the trailer to swing. Slight movement of the
steering wheel results in a much larger movement of the rear of
the trailer.
When turning, drive slightly beyond the normal turning point so
the trailer wheels will clear curbs or other obstructions.
Allow more room for stopping with a trailer attached. Trailer
brakes should be applied first, whether manually or automatically
controlled, when approaching a stop.
For an easy-to-operate vehicle/trailer combination, the trailer
tongue load should be approximately 10-15% of the loaded trailer
weight.
Make a thorough check of your equipment before starting out on
the road. After you have traveled about 50 miles (80 km), stop
in a protected area and double-check your hitch and electrical
connections. Also check trailer wheel lug nuts for tightness.
When stopped in traffic for long periods of time in hot weather,
place the gearshift selector lever in Park (P) to increase the
engine idle speed. This aids in engine cooling and air conditioner
efficiency. If the engine overheats, press the air intake selector
button to select the fresh air position to stop the air conditioner
compressor. Increase the engine speed for a short time.
Vehicles with trailers should not be parked on a grade. However,
if you must park on a grade, place wheel chocks under the
trailer's wheels as follows:
Driving
237

To avoid damaging your vehicle or your battery, and to avoid
injury to yourself, follow these directions for preparing your vehicle
to jump-start and connecting the jumper cables in the order
they are given. If in doubt, call for road service.
Preparing Your Vehicle
1. Your vehicle has a 12-volt starting system, so you need to use
a 12-volt jumper system. You will damage your starting
motor, ignition system, and other electrical parts if you connect
them to a 24-volt power supply (either two 12-volt batteries
in series or a 24-volt generator set).
2. Do not disconnect the battery of the disabled vehicle. You
could damage the vehicle's electrical system.
3. Park the booster vehicle close to the hood of the disabled
vehicle.Make sure the vehicles do not touch each other.Set the
parking brake on both vehicles and stay clear of the engine
cooling fan and other moving parts.
4. Check all battery terminals and remove any excessive
corrosion before you attach the jumper cables.
5. Turn on the heater blower in both vehicles. Turn off all other
switches and lights in both vehicles to prevent possible
damage to either vehicle's electrical systems.
Roadside Emergencies
269

Service Made Easy
Ford has two goals for servicing your vehicle.
1. When we can, we design parts that do not need to be
serviced.
2. We want to make servicing your vehicle as easy as possible.
To help you:
mWe highlight do-it-yourself items in yellow in your engine
compartment so that you can find them easily.
mWhen possible, we design parts that can be replaced without
tools.
mWe give you a Maintenance Schedule that makes tracking
routine service for your vehicle easy. TheMaintenance
Schedulebooklet is part of your owners portfolio.
This chapter tells you about the basic parts that you need to
check and service regularly.
If your vehicle needs professional servicing, your dealership can
provide the parts and service required. Check yourWarranty Guide
to find out which parts and services are covered. Also see the
Customer Assistancechapter of this Owner's Manual.
Ford Motor Company recommends that the Owner Maintenance
Checks listed in theMaintenance Schedulebooklet be
performed for the proper operation of your vehicle. In addition
to the conditions listed in the Owner Maintenance Checklist, be
alert for any unusual noise, vibration, or other indication that
your vehicle may need service. If you do notice something unusual,
see that your vehicle is serviced promptly.
Use only recommended fuels, lubricants, fluids, and service parts
that meet Ford Motor Company specifications. Motorcraft
parts are designed and built to provide the best performance in
your vehicle.
Maintenance and Care
275

7. Refill the engine with a CERTIFIED engine oil of the preferred
viscosity. Start the engine and check for leaks. Follow
directions inChecking and adding engine oilto be sure the
engine is filled to the proper level.
WARNING
Continuous contact with USED motor oil has caused
cancer in laboratory mice.
Protect your skin by washing with soap and water.
Brake Fluid
Your vehicle is equipped with a brake fluid level indicator in the
master cylinder which lights the BRAKE warning light on the
instrument panel when the brake fluid level is low.
Under normal circumstances, your vehicle should not use up
brake fluid rapidly. However, expect the level of the brake fluid
to slowly fall as you put more mileage on your vehicle and
the brake pads wear.
Check the brake fluid at least once a year. You can do this by
looking at the fluid level in the plastic brake fluid reservoir on the
master cylinder. The fluid level should be at or near the MAX
mark.
WARNING
Brake fluid is toxic.
If brake fluid contacts eyes, flush eyes with running water for 15
minutes. Get medical attention if irritation persists. If taken
internally, drink water and induce vomiting. Get medical attention
immediately.
282

Windshield Washer Fluid
Check the level of the windshield washer fluid every time you
stop for fuel, or when the warning light indicates low washer fluid.
The reservoir for washer fluid is located in the engine
compartment. This reservoir contains the fluid for both the
windshield and liftgate washers.
WARNING
Do not put windshield washer fluid in the container for
the engine coolant.
If sprayed to clean the glass, engine coolant or antifreeze could
make it difficult to see through the windshield.
Windshield washer fluid reservoir
284

WARNING
Do not park, idle, or drive your vehicle in dry grass or
other dry ground cover. The emission system heats up the
engine compartment and exhaust system, which can
start a fire.
WARNING
Do not remove the floor carpet in your vehicle. Emission
controls cause high exhaust temperatures under the
floor.
Watch for fluid leaks, strange odors, smoke and loss of oil
pressure. Also watch for the charge warning light, the check engine
light, or the temperature warning light. These sometimes
indicate that the emission system is not working properly.
Do not make any unauthorized changes to your vehicle or engine.
Changes that cause more unburned fuel to reach the exhaust
system can increase the temperature of the engine or exhaust
system.
In general, maintenance, replacement, or service of the emission
control devices or systems in your new Ford Motor
Company vehicle or engine may be performed at your expense
by any automotive repair establishment or individual using
automotive parts equivalent to those with which your vehicle or
engine was originally equipped.
By law, anyone who manufactures, repairs, services, sells, leases
vehicles, trades vehicles, or supervises a fleet of vehicles is
not permitted to intentionally remove an emission control device
or prevent it from working. In some of the United States and
in Canada, vehicle owners may be liable if their emission control
device is removed or is prevented from working.
314

A
Accessory position on the ignition..............86
Air bag supplemental restraint system...........144
and child safety seats..................153
description.....................144, 146
driver air bag....................144, 146
indicator light.......................11
operation........................146
passenger air bag....................146
service and information labels..............146
tone generator....................149, 149
Air cleaner filter
location.........................341
Alcohol
in fuel..........................310
Antenna, radio (see Electronic sound system).......29,84
Antifreeze (see Engine coolant)...............285
Anti-lock brake system (ABS)
description........................215
noise...........................215
see also Brake......................215
warninig light.......................9
Anti-theft lug nuts and key.................261
Anti-theft system
triggering........................116
Appeals (see Dispute settlement board)...........348
Assistance (see Customer assistance)............345
Audio system (see Electronic sound system).........29
Automatic transaxle
driving with.......................221
fluid, adding....................291, 292
fluid, checking......................291
fluid, specification....................339
Index
373

Controls
mirrors..........................109
Convenience kit in cargo area................255
Coolant (see Engine coolant)................285
checking and adding...................285
drain and flush.....................289
preparing for storage...................335
specifications.......................339
temperature gauge...................18,23
warnings.........................285
Cooling fan.........................276
Customer Assistance Centre, Ford of Canada........352
D
Daytime running light system................78
Defrost
rear window.......................75
windshield........................56
Dipstick..........................281
automatic transaxle fluid.................291
engine oil........................281
power steering fluid.................289, 289
Disabled vehicle (see Towing)................272
Dispute Settlement Board..................348
Doors............................97
door ajar warning light..................15
lubricant specifications..................339
Driving under special conditions
heavy load........................226
towing a trailer.....................227
Index
377