1998 Lexus LS400 service

INTRODUCTION
221
DOITYOURSELF SERVICE
PRECAUTIONS
If you perform maintenance yourself, be sure to follow the
correct procedure given in this Section.
You should be aware that improper or incomplete servicing may
result in operating problems.
Performing doityourself maintenance during the warranty period
may affect your warranty coverage. Read the separate Lexus
Warranty statement for details and suggestions.
This Section gives instructions only for those items that are
relatively easy for an owner to perform. As explained in Section 5,
there are still a number of items that must be performed by a qualified
technician with special tools.
For information on tools and parts for doityourself maintenance,
see ”Parts and tools”.
Utmost care should be taken when working on your vehicle to
prevent accidental injury. Here are a few precautions that you should
be especially careful to observe:
CAUTION
When the engine is running, keep hands, clothing, and tools
away from the moving fan and engine drive belt.
(Removing rings, watches, and ties is advisable.)
Right after driving, the engine compartment the engine,
radiator, exhaust manifold and power steering fluid
reservoir, etc. will be hot. So be careful not to touch them.
Oil and other fluids may also be hot.
Do not smoke, cause sparks or allow open flames around
fuel or the battery. Their fumes are flammable.
Be extremely cautious when working on the battery. It
contains poisonous and corrosive sulfuric acid.
Do not get under your vehicle with just the body jack
supporting it. Always use automotive jack stands or other
solid supports.
Be sure the ignition is off if you work near the electric
cooling fan or radiator grille. With the ignition on, the
electric cooling fan may automatically start to run if the air
conditioning is on and/or if the coolant temperature is high.
Use eye protection whenever you work on or under your
vehicle where you may be exposed to flying or falling
material, fluid spray, etc.
NOTICE

SECTION 6 2
224
SERVICE PROCEDURES AND
SPECIFICATIONS
Engine
Specifications 225. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel 227. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Facts about engine oil consumption 229. . . . . . . . . . . . . . . . . . . . . . . . . . .
Used engine oil 230. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the engine oil level 230. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the engine coolant level 233. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Spark plugs 234. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

ENGINE
228
Improved gasolines
The American Automobile Manufacturers Association (AAMA)
has developed a specification of improved gasolines. The AAMA
specification offers optimal fuel information for better vehicle
performance and better protection of your engine.
Lexus recommends the use of gasolines that meet the AAMA
specification, if available, for improved drivability and emission
control system.
Gasolines containing MTBE
Gasolines that contain MTBE (Methyl TertiaryButyl Ether)
are available in the market. If you use a gasoline mixed with
MTBE, make certain that it does not contain more than 15% of
MTBE.
If the use of gasolines containing MTBE causes poor drivability
and/or poor fuel economy, you should stop using them.
Gasolines containing MMT
Some gasolines contain an octaneenhancing additive called
MMT (methylcyclopentadienyl manganese tricarbonyl).
Lexus does not recommend the use of gasolines that contain MMT.
If fuels containing MMT are used, your emission control system may
be adversely affected. The Malfunction Indicator Lamp on the
instrument cluster may come on. If this happens, contact your Lexus
dealer for service.
Gasolines containing alcohol
Gasohol is a mixture of gasoline and ethanol. If you use gasohol
in your Lexus, be sure that it is unleaded, has an octane rating
no lower than 87 and does not contain more than 10% ethanol.
Lexus does not recommend the use of gasolines containing
methanol.
If you use gasoline containing methanol, use only gasoline meeting
the requirements above and also containing less than 5% methanol
with cosolvents and corrosion inhibitors for methanol.
NOTICE
Do not use gasohol other than stated above. It will cause fuel
system damage or vehicle performance problems.
If drivability problems are encountered (poor hot starting,
vaporizing, engine knock, etc.), discontinue its use.
Take care not to spill gasohol during refueling. Gasohol may
cause paint damage.
Fuel tank capacity
85 L (22.5 gal., 18.7 lmp.gal.)

ENGINE
230Failure to check the oil level regularly could lead to serious
engine trouble due to insufficient oil.
For detailed information on oil level check, see ”Checking the
engine oil level” on page 230.
USED ENGINE OIL
CAUTION
Used engine oil contains potentially harmful contaminants
which may cause skin disorders such as inflammation or
skin cancer, so care should be taken to avoid prolonged and
repeated contact with it. To remove used engine oil from
your skin, wash thoroughly with soap and water.
Do not leave used oil within the reach of children.
Dispose of used oil and used oil filters only in a safe and
acceptable manner. Do not dispose of used oil and used oil
filters in household trash, in sewers or onto the ground.
Call your Lexus dealer or a service station for information
concerning recycling or disposal.
CHECKING THE ENGINE OIL
LEVEL
62L004-4
With the engine at operating temperature and turned off, check
the oil level on the dipstick.
1. To get a true reading, the vehicle should be on a level spot. After
turning off the engine, wait a few minutes for the oil to drain back
into the bottom of the engine.
2. Pull out the dipstick, and wipe it clean with a rag.
3. Reinsert the dipstick and push it in as far as it will go, or the
reading will not be correct.

ENGINE
232
Engine oil selection
Use API SH, ”EnergyConserving II” or SJ, ”EnergyConserving”
multigrade engine oil or ILSAC multigrade engine oil.
Recommended viscosity (SAE):
62L0051
Temperature range anticipated before next oil change
SAE 5W30 is the best choice for your vehicle, for good fuel
economy, and good starting in cold weather.
If you use SAE 10W30 engine oil in extremely low
temperatures, the engine may become difficult to start, so SAE
5W30 engine oil is recommended.
Oil identification marks
62L0061
API Service Symbol
ILSAC Certification Mark
Either or both API registered marks are added to some oil containers
to help you select the oil you should use.
The API Service Symbol is located anywhere on the outside of the
container.
The top portion of the label shows the oil quality by API
(American Petroleum Institute) designation such as SJ. The
center portion of the label shows the SAE viscosity grade such as
SAE 5W30. ”EnergyConserving”, shown in the lower portion,
indicates that the oil has fuelsaving capabilities.
The ILSAC (International Lubricant Standardization and
Approval Committee) Certification Mark is displayed on the
front of the container.

SECTION 6 3
236
SERVICE PROCEDURES AND
SPECIFICATIONS
Chassis
Specifications 237. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking brake fluid 239. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking power steering fluid 240. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking tire pressure 241. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rotating tires 242. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking and replacing tires 243. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installing snow tires and chains 245. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing wheels 247. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 247. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Suspension and chassis 247. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

CHASSIS
244
Uniform tire quality grading
This information has been prepared in accordance with
regulations issued by the National Highway Traffic Safety
Administration of the U.S. Department of Transportation. It
provides the purchasers and/or prospective purchasers of Lexus
vehicles with information on uniform tire quality grading.
Your Lexus dealer will help answer any questions you may have
as you read this information.
DOT quality grades All passenger vehicle tires must conform
to Federal Safety Requirements in addition to these grades.
These quality grades are molded on the sidewall.
Treadwear The treadwear grade is a comparative rating based on
the wear rate of the tire when tested under controlled conditions on
a specified government test course. For example, a tire graded 150
would wear one and a half (1 1/2) times as well on the government
course as a tire graded 100. The relative performance of tires
depends upon the actual conditions of their use, however, and may
depart significantly from the norm due to variations in driving
habits, service practices and differences in road characteristics and
climate.
Traction A, B, C The traction grades, from highest to lowest, are
A, B and C, and they represent the tire’s ability to stop on wet
pavement as measured under controlled conditions on specified
government test surfaces of asphalt and concrete. A tire marked C
may have poor traction performance.Warning: The traction grade assigned to this tire is based on braking
(straight ahead) traction tests and does not include cornering
(turning) traction.
Temperature A, B, C The temperature grades are A (the highest),
B, and C, representing the tire’s resistance to the generation of heat
and its ability to dissipate heat when tested under controlled
conditions on a specified indoor laboratory test wheel. Sustained
high temperature can cause the material of the tire to degenerate and
reduce tire life, and excessive temperature can lead to sudden tire
failure. The grade C corresponds to a level of performance which all
passenger car tires must meet under the Federal Motor Vehicle
Safety Standard No. 109. Grades B and A represent higher levels of
performance on the laboratory test wheel than the minimum required
by law.
Warning: The temperature grade of this tire established for a tire that
is properly inflated and not overloaded. Excessive speed,
underinflation, or excessive loading, either separately or in
combination, can cause heat buildup and possible tire failure.

SECTION 6 4
248
SERVICE PROCEDURES AND
SPECIFICATIONS
Electrical components
Specifications 249. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking battery condition 253. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery recharging precautions 257. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking and replacing the blade type fuses 258. . . . . . . . . . . . . . . . . . . .
Checking the cartridge type fuses 260. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adding washer fluid 261. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the headlight aim 261. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing light bulbs 264. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .