1998 HONDA CIVIC cruise control

Engine Removal/lnstallation
Installation (cont'd)
Except CVT:
12 x 1.25 mm64 N.m (6.5 kgd.m,
Tighten the bolts/nut on the left front mount in thenumbered sequence shown {O - @).
(t 12 x 1.25 mm83 N'm (8.5 kgf.m,61 tbt.trl
/+4 N.m 14.5 kgf.m,33 lbt.trl
O 12 r 1.25 mm59 N.m 16.0 kgt.m,43 tbt.rtlSeplace.
5-16
\
7. Perform the following:
. Clean the areas where the driveshaft(s) and theintermediate shaft contact the transmission (dif_ferential) thoroughly with solvent or carburetorcteaner, and dry with compressed air.. Check that the set rings on the ends of the drive_shaft and intermediate shaft click into place.CAUTION: Use new set rings,. Adjust the shift cable (see section 14).. Adjust the throttle cable (see section 11).. Adjust the cruise control cable (see section 23).. Refill the engine with engine oil (see page 8-6).. Refill the transmission with fluid (see section 13,14).
. Refill the radiator with engine coolant (see page10-7).
. Bleed air from the cooling system with the heatervalve open (see page j0-7).
. Clean the battery posts and cable terminals withsandpaper, assemble them, then apply grease toprevent corrosaon.. Inspect for fuel leakage (see section j l).After assembling the fuel line, turn on l) the igni_tion switch (do not operate the starter) so that thefuel pump runs for approximately two secondsand the fuel line pressurizes. Repeat this opera_taon two or three times, then check for fuel leak_age at any point in the fuel line,

System Description
Vacuum Connections
D16Y5 engin6 ('96 - 97 modelsl:
To EVAPORATIVE EMISSION(EVAPI
TWO WAY VALVE
MANIFOLDABSOLUTEPRESSURE IMAPISENSOR
€VAPORATIVEEMISSION IEVAPIPURGE CONTROL SOLENOIDVALVE
EXHAUST GAS BECIRCULATION(EGR) VALVE end EXHAUST GASRECIRCULATION IEGR) VALVELIFT SENSOR
Qo
FRONT OF VEHICLE
To CRUISECONTROLDIAPHRAGM(wath cruise control)
Qo
O: Vacuum hose No.
11-12
EXHAUST GAS RECIRCULATION(EGR) CONTROL SOLENOID VALVE {CVT}\.'.-' \
I
I
)
FUEL PRESSURE REGULATOR

D16Y5 engine l'98 - 00 models):
To EVAPORATIVE EMISSIONtEVAPI THREE WAY VALVE {98 model)
To EVAPORATIVE EMISSIONIEVAP' CONTBOLCANISTERFILTER 1'99 - 00 modelsl
EVAPORATIVE EMISSION {EVAPICONTROL CANISTERVENT SHUT VALVE
To EVAPORATIVE EMISSION
l'99 - 00 modelsl {EVAP)TWO WAY VALVE
EXHAUST GAS RECIRCULATION(EGRI VALVE and EXHAUST GASRECIRCULATION IEGRI VALVELIFT SENSORtcwl
..,.-----.-(CWontylEXHAUST GAS RECIRCULATION
IEGR} CONTROL SOLENOIOVALVE ICVTI
,t'ffi,
ig
EVAPORATIVEEMISSION {EVAP)PURGE CONTROLCANISTER
MANIFOLDABSOLUTEPRESSURE {MAPISENSOR
EVAPORATIVEEMISSION {EVAP)Qo
To CRUISECONTROLDIAPHRAGM(with cruise control)PURGE CONTROL SOLENOIDVALVEFRONT OF VEHICLE
FUEL PRESSURE REGULATOR
o: Vacuum hose No.
(cont'd)
1 1-13
L

System Description
Vacuum Connections {cont'd}
Dl6Y8 engine l'96 - 98 models):
To EVAPOBATIVE EMISSIONIEVAPI THREE WAY VALVE{'96 coupe, '97 coupe: all models.'97 sedan: KL model. 'g8-models)
EVAPORATIVE EMISSION (EVAPI
CONTROL CANISTERVENT SHUT VALVE{'96 coupe,'97 coupe: all models,'97 sedan: KL model. 'g8-modelsl
To EVAPORATIVE EMISSION{EVAP)TWO WAY VALVE
{'96 coupe,'97 coupe: all models,sed6n: KL model)
EVAPORATIVEEMISSION {EVAPIPUBGE CONTROLCANISTER
EVAPORATIVE EMISSION{EVAPI PUBGECONTROL CANISIERl'96 sadan, '97 sodan: XA,
FUEL PRESSUREREGULATORMANIFOLD ABSOLUTEPRESSURE (MAP) SENSOR
I
KC mod6l3l
EVAPORATIVEEMISSION {EVAPITo CRUISECONTROLDIAPHRAGM{with cruise control)
PURGE CONTROL SOLENOIDVALVE
FRONT OF VEHICLE
11-14

Dl6Y8 ongino ('99 - 00 modols):
€VAPORATIVE EMISSION (EVAP}
CONTROL CANISTERVENT SHUT VALVE
To EVAPORATIVE EMISSION
{EVAPI CONTROL CANISTERFILTER
To EVAPORATIVE EMISSION(EVAPI
TWO WAY VALVE
FRONT OF VEHICI-E
To CRUISECONTROLDIAPHRAGM(with cruise control)
EVAPORATIVEEMISSION IEVAPIPURGE CONTNOLCANISTER
REGULATOR
{cont'd)
1 1-15

System Description
Vacuum Connections (cont'dl
D16Y7 engine ('96 models,'97 coupe: KA. Kc models, '97 sedan: KA, Kc, KL lDx) models,'97 hatchback: all modelsl:
EVAPORATIVEEMISSION (EVAPIPURGE CONTROL
FUELPRESSUREREGULATOR
To EVAPORATIVEEMISSION {EVAP}TWO WAY VALVE
MANIFOLD ABSOTUTEPRESSURE (MAP)
To CRUISECONTROLDIAPHRAGMlwith cruise
EVAPORATIVEEMISSION (EVAPI
PURGE CONTROLCANISTERFRONT OFVEHICLE
11-16

Dl6YT engine ('97 coupe: KL model,'97 sedan: KL ILX) model,'98 model"gg model"oo model):
To EVAPORATIVE EMISSION{EVAP} THREE WAY VALVE
l'97 coupe: KL model,'97 sedan: KL (LX) model,'98 modellTo EVAPORATIVE EMISSION
{EVAP) CONTROL CANISTER
FILTER ('99 - 0O models)
EVAPORATIVE EMISSION {EVAP)CONTROL CANISTERVENT SHUT VALVE
EVAPORATIVE EMISSION (EVAP)
CONTROL CANISTERVENT SHUT VALVE
To EVAPORATIVE EMISSIONIEVAPITWO WAY VALVE
PURGE JOINTEVAPORATIVEEMISSION {EVAP}PURGE CONTROLCANISTERFUEL PRESSUREREGULATOR_.\,,..,_..-.
{'97 coupe: KL model,'97 sedan: KL (LX) model.'98 model)
MANIFOLD ABSOLUTEPRESSURE {MAP) SENSOR
To CRUISECONTROLDIAPHRAGM
lwith cruise control)
EVAPORATIVEEMISSION (EVAP}gtt
FRONT OF VEHICLE
PURGE CONTROL SOLENOID
VALVE
(cont'd)
11-17

System Description
Vacuum Gonnections (cont'd)
B16A2 engine:
EVAPORATIVE EMISSION (EVAPICONTROL CANISTERVENT SHUT VALVE
To EVAPORATIVE EMISSION(EVAPI CONTROL CANISTERFILTER
EVAPORATIVEEMISSION {EVAPIPURGE CONTROLCANISTER
To EVAPOBATTVE EM|SS|ON(EVAPI
TWO WAY VALVE
EVAPORATIVEEMISSION IEVAPIPUBGE CONTROL SOLENOIDVALVE
2
VEHICLE
MANIFOI.D ABSOLUIEPRESSURE (MAPI SENSOR
FUEL PRESSUREREGULATOR
To CRUISECONTROLDIAPHRAGM(with cruise control)
1 1-18