1998 CHEVROLET TRACKER engine

Downloaded from www.Manualslib.com manuals search engine I Short Trip/City Maintenance Schedule I
84,000 Miles (I40 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
Inspect the locking front hubs (if equipped) for correct operation (or every
An Emission Control Service.
rotation pattern and additional information. (See footnote +.)
3 months, whichever occurs first). Repair or replace if necessary\
.
87,000 Miles (I45 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Inspect the locking front hubs (if equipped) for correct operation (or every
An Emission Control Service.
3 months, whichever occurs first). Repair or replace if necessary.
90,000 Miles (150 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Replace automatic transmission fluid hose (or every 45 months, whichever
An Emission Control Sewice.
bearings (or at each brake relining, whichever occurs first).
occurs first).
I DATE I
MILEAGE
I DATE I
I MILEAGE ACTUAL I SERVICEDBY: I
I DATE I
MILEAGE
7-26

Downloaded from www.Manualslib.com manuals search engine I Short Trip/City Maintenance Schedule I
0 Change automatic transmission fluid and filter if the vehicle is mainly driven
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly r\
eaches
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, change the fluid
and
filter every 100,000 miles (166 000 km).
occurs first).
An Emission Control Service.
17 Inspect camshaft timing belt.
An Emission Control Service. (See footnote T.)
90°F (32°C) or higher.
0 Inspect engine accessory drive belts (or every 24 months, whichever
0 Drain, flush and refill cooling system (or every 30 months, whichever occur\
s
first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean
radiator, condenser, pressure cap and neck. Pressure test the cooling system
and pressure cap.
An Emission Control Service. (See footnote?.)
0 Replace spark plugs.
An Emission Control Service.
(Continued)
7-27

Downloaded from www.Manualslib.com manuals search engine Short TripKity Maintenance Schedule
90,000 Miles (150 000 km) (Continued)
0
0
0
0
0
0
0
0
Replace air cleaner filter.
An Emission Control Service.
Inspect fuel tank, cap and lines for dam&ge Or leaks. Inspect fuel cap gasket
for
any damage. Replace parts as needed.
An Emission Control Service. (See footnote?.)
Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
rotation pattern and additional information. (See footnote
+.)
Change manual transmission fluid.
Change transfer case fluid.
Change differential fluid.
Inspect the valve lash and adjust if necessary.
An Emission Control Service.
Replace fuel filter (or every 30 months, whichever occurs first).
An Emission Control Service. (See footnote?.)
Check engine idle speed and adjust it to underhood label specifications.
An Emission Control Service. (See footnote?.)
Inspect the locking front hubs (if equipped) for correct operation (or every
3 months, whichever occurs first). Repair or replace as necessary.
Inspect propeller shafts and u-joints for looseness and damage (or every
15 months, whichever occurs first). Inspect more frequently if used off-road
or for pulling
a trailer. Tighten u-joint flange bolts if necessary.
7-28

Downloaded from www.Manualslib.com manuals search engine I Short TripKity Maintenance Schedule I
93,000 Miles (155 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Inspect the locking front hubs (if equipped) for correct operation (or every
An Emission Control Service.
3 months, whichever occurs first). Repair or replace if necessary.
96,000 Miles (160 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
0 Inspect the locking front hubs (if equipped) for correct operation (or every
An Emission Control Sewice.
rotation pattern and additional information. (See footnote +.)
3 months, whichever occurs first). Repair or replace if necessary.
99,000 Miles (165 000 km)
0 Change engine oil and fiiter (or every 3 months, whichever occurs first).
0 Inspect the locking front hubs (if equipped) for correct operation (or every
An Emission Control Service.
3 months, whichever occurs first). Repair or replace if necessary.
DATE
MILEAGE
ACTUAL SERVICED BY:
DATE 1
I MILEAGE ACTUAL I SERVICEDBY: I
I DATE I
MILEAGE
7-29
~ .

Downloaded from www.Manualslib.com manuals search engine I Short Trip/City Maintenance Schedule I
100,000 Miles (166 000 km)
0 If you haven’t used your vehicle under severe service condit\
ions listed
previously and, therefore, haven’t changed your automatic tran\
smission
fluid, change both the fluid and filter.
0 Replace Positive Crankcase Ventilation (PCV) valve. Replace any\
worn,
plugged or collapsed hoses.
An Emission Control Service.
An Emission Control Service.
An Emission Control Sewice.
An Emission Control Service.
0 Inspect Exhaust Gas Recirculation (EGR) system.
0 Inspect fuel injector.
0 Replace evaporative emissions canister.
DATE I
7-30

Downloaded from www.Manualslib.com manuals search engine Long Tripmighway Maintenance Schedule
The services shown in this schedule up to 100,000 miles
(166 000 km) should be performed after 100,000 miles
(166
000 km) at the same intervals.
See “Owner Checks and Services” and “Periodic
Maintenance Inspections” following.
Footnotes
‘f The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the
completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
+ A good time to check your brakes is during tire
rotation. See “Brake System Inspection” under “Periodic
Maintenance Inspections” in
Part C of this schedule.

Downloaded from www.Manualslib.com manuals search engine Long Trip/Highway Maintenance Schedule
7,500 Miles (I2 500 km)
0 Change engine oil and filter (or every 7.5 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and Rotation’’ in the Index for proper
0 Inspect the locking front hubs (if equipped) for correct operation (or every
An Emission Control Service.
rotation pattern and additional information. (See footnote +.)
3 months, whichever occurs first). Repair or replace if necessary.
I DATE I
15,000 Miles (25 000 km)
0 Change engine oil and filter (or every 7.5 months, whichever occurs first).
0 Change automatic transmission fluid and filter if the vehicle i\
s mainly driven
An Emission Control Service. MILEAGE
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly r\
eaches
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
lfyou do not use your vehicle under any of these conditions, change the fluid
and filter every
100,000 miles (I 66 000 km).
rotation pattern and additional information. (See footnote +.)
90°F (32°C) or higher.
0 Rotate tires. See “Tire Inspection and Rotation” in the I\
ndex for proper
7-32

Downloaded from www.Manualslib.com manuals search engine 1 Long Trip/Highway Maintenance Schedule I
Inspect the locking front hubs (if equipped) for correct operation (or every
3 months, whichever occurs first). Repair or replace if necessary.
0 Inspect the valve lash and adjust if necessary.
An Emission Control Service.
0 Check engine idle speed and adjust it to underhood label specifications.
0 Inspect propeller shafts and u-joints for looseness and damage (or every
An Emission Control Service. (See footnote?.)
15 months, whichever occurs first). Inspect more frequently if used off-road
or for pulling a trailer. Tighten u-joint flange bolts if necessary.
22,500 Miles (37 500 km)
0 Change engine oil and filter (or every 7.5 months, whichever occurs first).
Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
0 Inspect the locking front hubs (if equipped) for correct operation (or every
An Emission Control Service.
rotation pattern and additional information. (See footnote +.)
3 months, whichever occurs first). Repair or replace if necessary\
.
I DATE I
30,000 Miles (50 000 km)
0 Change engine oil and filter (or every 7.5 months, whichever occurs first).
An Emission Control Service.
7-33