1998 CHEVROLET PRIZM headlamp

Downloaded from www.Manualslib.com manuals search engine 3.
4.
5.
6.
7.
Remove the bolt (A) near the top inside of the
headlamp assembly.
Remove the bolt
(B) near the top outside of the
headlamp assembly.
Remove the headlamp assembly by pulling up and out.
Remove the electrical connector from the back
of
the assembly.
Pry back the rubber covering from the back of
the assembly.
8. Press down and move the metal retainer away from
you and then lift the metal retainer to the right.
6-34

Downloaded from www.Manualslib.com manuals search engine Used Replacement Wheels
I
A CAUTION:
Using the wrong replacement wheels, wheel
bolts
or wheel nuts on your vehicle can be
dangerous. It could affect the braking and
handling of your vehicle, make your tires lose
air and make you lose control. You could have
a collision in which you or others could be
injured. Always use the correct wheel, wheel
bolts and wheel nuts for replacement.
I
I
NOTICE:
The wrong wheel can also cause problems with
bearing life, brake cooling, speedometer or
odometer calibration, headlamp aim, bumper
height, vehicle ground clearance and tire or tire
chain clearance to the body and chassis.
See “Changing a Flat Tire” in the Index for
more information.
A CAUTION:
Putting a used wheel on your vehicle is
dangerous. You can’t know how it’s been used or
how far
it’s been driven. It could fail suddenly
and cause an accident.
If you have to replace a
wheel, use a new GM original equipment wheel.
6-43

Downloaded from www.Manualslib.com manuals search engine Headlamps Wiring Fuses and Circuit Breakers
The
headlamp wiring is protected by a circuit breaker.
An electrical overload will cause the lamps to go on and
off, or in some cases to remain
off. If this happens, have
your headlamp wiring checked right away.
Windshield Wipers Fuses
The windshield wiper motor is protected by a circuit
breaker and a fuse. If the motor overheats due to heavy
snow, etc., the wiper will stop until the motor cools. If
the overload is caused by some electrical problem, and
not snow, etc., be sure to get it fixed.
Power Windows and Other Power Options
Circuit breakers protect the power windows and other
power accessories. When the current load is too heavy,
the circuit breaker opens and closes, protecting the
circuit until the problem is fixed or goes away. The wiring circuits in your vehicle are protected from
short circuits by fuses, circuit breakers and fusible
thermal links in
the wiring itself. This greatly reduces
the chance of fires caused by electrical problems.
Look at the silver-colored band inside the fuse. If the
band is broken or melted, replace the fuse. Be sure you
replace
a bad fuse with a new one of the correct size.
If you ever have a problem on the road and don’t
have a
spare fuse, you can borrow one. Just pick some feature
of your vehicle that you can get along without -- like the
radio or air conditioner
-- and use its fuse, if it is of the
value you need. Replace it as soon as you can.
Before replacing
a fuse, turn every electrical switch off.
6-54

Downloaded from www.Manualslib.com manuals search engine Engine Compartment Fusemelay Block
(Driver's Side)
Most of your fuses are in the engine compartment
fuse block. Some are in three electrical centers in your
engine compartment. These electrical centers also have
relays, circuit breakers and other electrical components.
The larger electrical center in the engine compartment
has a fuse puller located between the EFI and FAN
relays. You can use the puller to remove any fuses.
Fusemelay Usage
FL ABS
ST
MAIN
FL ALT
DOME
[.-I
0 HAZARD
0 AM2
0 HEAD (LH -UPR) HEAD (LH) or
[,,,,I ENGlN
This engine compartment fusehelay block is located
on the driver's side of the engine compartment near
the air cleaner. HEAD
HAZARD
AM2
HEAD (LH) or
HEAD (LH-UPR)
LT-S
HEAD
(RH) or
EFI or F-HTR
HORN
EFI or F-HTR
FAN
No. 1
RDI HEAD (RH-UPR)
ABS System
Starting System (Relay)
Starting System, Headlamps
Charging System,
Cooling Fan
Sunroof, Dome Lamp, RKE
System, Trunk Lamp, DRL,
Radio, Warning Alarms
Headlamp (Relay)
Hazard Lamps
Starting System, Accessories
Left Headlamp (High-Beam)
Charging System
Right Headlamp (High-Beam)
Fuel Injection System
Horn System
Fuel Injection System (Relay)
Cooling Fan (Relay) Cooling Fan
6-56

Downloaded from www.Manualslib.com manuals search engine Fusemelay Usage
ENGINE MAIN
HORN (Relay)
AM1 Main Engine (Relay)
Horn System
Starting System, Air Bags
Engine Compartment Fusemelay Block (Driver’s
Side)
-
e5 HEAD(RH - LWR)
0
0
HEAD(LH -LWR)
CDS Elm FAN N0.3 FAN N0.2 El3
DIMMER
This engine compartment fusehelay block is located
on the driver’s side of the engine compartment near
the battery.
Fusemelay Usage
DRL
HEAD
(RH-LWR)
HEAD (LH-LWR)
CDS
AC
MG
AC FAN N0.3
AC FAN
N0.2
DIMMER DRL System
Right Headlamps (Low-Beam)
Left Headlamps (Low-Beam)
A/C Condenser Fan
Air Conditioning System (Relay)
Air Conditioner Fan Relay
#3
Air Conditioner Fan Relay #2
Instrument Panel Dimming
(Relay)
6-57

Downloaded from www.Manualslib.com manuals search engine Engine Compartment Fusemelay Block (Passenger's Side)
n
This engine compartment fusehelay block is located on
the passenger's side
of the engine compartment near the
windshield washer fluid reservoir.
Fusemelay Usage
NC
HTR
HTR
DRL Air Conditioning System
Heating System
Heating System (Relay)
DRL System (Relay)
Replacement Bulbs
Headlamp High/Low Beam ................ HB 2
Front Turn SignaVSidemarker ............ 1157NA
Application Bulb Number
Stoplamp/"aillamp ....................... 1157
Back-up
................................ 921
Rear Sidemarker ......................... 168
Rear Turn Signal
........................ 1156
6-58

Downloaded from www.Manualslib.com manuals search engine Engineoil .................................... 6-12
Additives
6- 15
Checking ................................... 6-12
Used
....................................... 6-16
Adding
..................................... 6-13
Pressure Light
............................... 2-52
What Kind to Use
............................. 6-14
When to Change
.............................. 6-15
Ethanol
........................................ 6-5
Exhaust, Engine
............. 2-9,2-24,4-27,4-33, 7-42
Exterior Lamps
................................. 2-32
Fabric Cleaning
............................... 6-45
Fabric Protection
............................... 6-46
~ Fifth Gear, Manual Transaxle ..................... 2-18
Filling a Portable Fuel Container
.................... 6-8
FillingYourTank
................................ 6-6
Filter, Air
................................ 6-16, 6-60
Finish Damage
................................. 6-50
First Gear, Manual Transaxle ...................... 2- 18
Flashers, Hazard Warning
......................... 5-2
Flash-to-Pass Feature ........................... 2-28
Flat Tire, Changing
............................. 5-23
Fluid Capacities
................................ 6-59
Fluid Level Check
.............................. 7-38
Fluids and Lubricants
............................ 7-44
Folding Rear Seatback
............................ 1-5
Foreign Countries, Fuel
........................... 6-5
Fourth Gear, Manual Transaxle .................... 2-18
French Language Manual
........................... ii
Front Turn Signal Lamp Bulb Replacement .......... 6-33
...................................
Finishcare .................................... 6-49
FrontTowing
.................................. 5-10
.......................................... Fuel 6-3 Canada ...................................... 6-3
Filling a Portable Fuel Container
.................. 6-8
Filling Your Tank
.............................. 6-6
In Foreign Countries
........................... 6-5
Remote Door Release
........................... 6-6
Fuses and Circuit Breakers
....................... 6-54
Gages Engine Coolant Temperature
.................... 2-49
GAWR
....................................... 4-29
Gear Positions, Manual Transaxle
.................. 2-18
Gross Axle Weight Rating ........................ 4-29
Gross Vehicle Weight Rating
...................... 4-29
....................................... Gage 2-54
Fuel
....................................... 2-54
GloveBox
.................................... 2-37
Guide en Frangais
11
GVWR ....................................... 4-29
.. .................................
Halogen Bulbs ................................ 6-33
Hazard Warning Flashers
.......................... 5-2
Head Restraints ................................. 1-4
Bulb Replacement
............................ 6-33
High/Low Beam Changer
...................... 2-28
Hearing Impaired, Customer Assistance
.............. 8-4
Hill and Mountain Roads
......................... 4-22
Hitches, Trailer
................................. 4-33
Headlamps
.................................... 2-32
OnReminder
................................ 2-33
Heating
........................................ 3-3
High-BeamHeadlamps
.......................... 2-28
9-4