1998 CHEVROLET EXPRESS check oil

Downloaded from www.Manualslib.com manuals search engine Long Tripmighway Maintenance Schedule -- Gasoline Engines
The services shown in this schedule up to 100,000 miles
( 166 000 km) should be performed after 100,000 miles
(166
000 km) at the same intervals. The services shown
at
150,000 miles (240 000 km) should be performed at
the same interval after
150,000 miles (240 000 km).
See “Owner Checks and Services” and “Periodic
Maintenance Inspections” following.
Footnotes
The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to
the
completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services
be
performed at the indicated intervals and the maintenance
be recorded.
## Lubricate the front suspension, kingpin bushings,
steering linkage and rear driveline center splines.
+ A good time to check your brakes is during tire
rotation. See “Brake System Inspection” under “Periodic
Maintenance Inspections” in Part
C of this schedule.
** Drive axle service (see “Recommended Fluids and
Lubricants” in the Index for proper lubricant to use):
0 Locking Differential -- Drain fluid and refill at first
engine oil change. At subsequent oil changes, check
fluid level and add fluid as needed.
fluid as needed at every engine oil change.
0 Standard Differential -- Check fluid level and add
7-27

Downloaded from www.Manualslib.com manuals search engine 1 Long Trip/Highway Maintenance Schedule -= Gasoline Engines
7,500 Miles (12 500 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check axle fluid level and add fluid as needed. (See footnote **.)
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
rotation pattern and additional information. (See footnote
+.)
An Emission Control Service.
(See footnote #.)
15,000 Miles (25 000 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
0 Lubricate chassis components (or every 12 months, whichever occurs first).
I7 Check axle fluid level and add fluid as needed. (See footnote **.)
0 Vehicles With GVWR Above 8,500 lbs. Only: Inspect shields and underhood
insulation for damage or looseness. Adjust or replace as required.
This is a
Noise Emission Control Service. Applicable only to vehicles sold in the
United States.
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
rotation pattern and additional information. (See footnote
+.)
An Emission Control Service.
(See footnote #.)
I DATE I
MILEAGE
DATE
I
7-28

Downloaded from www.Manualslib.com manuals search engine Long. TriplHighway Maintenance Schedule -- Gasoline Engines ”
22,500 Miles (37 500 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check axle fluid level and add fluid as needed. (See footnote **.)
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
rotation pattern and additional information. (See footnote
+.)
MILEAGE An Emission Control Service.
(See footnote #.)
30,000 Miles (50 000 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check axle fluid level and add fluid as needed. (See footnote *4’.)
0 Clean and repack the front wheel bearings (or at each brake relining,
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for
(See footnote
#.)
whichever
occurs first).
proper rotation pattern and additional information. (See footnote
+.)
(Continued)
I DATE I
MILEAGE
7-29

Downloaded from www.Manualslib.com manuals search engine Long Trip/Highway Maintenance Schedule -- Gasoline Engines
30,000 Miles (50 000 km) (Continued)
0 Replace fuel filter.
An Emission Control Service. (See footnote?.)
17 Replace air cleaner filter.
An Emission Control Service.
0 Vehicles With GVWR Above 8,500 lbs. Only: Inspect shields and underhood
insulation
for damage or looseness. Adjust or replace as required. This is a
Noise Emission Control Service. Applicable only to vehicles sold in the
United States.
37,500 Miles (62 500 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check axle fluid level and add fluid as needed. (See footnote **.)
0 Rotate tires. See “Tire Inspection and Rotation’’ in the Index for proper
rotation pattern and additional information. (See footnote
+.)
(See footnote #.)
MILEAGE
7-30

Downloaded from www.Manualslib.com manuals search engine Long Tripmighway Maintenance Schedule -- Gasoline Engines
45,000 Miles (75 000 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check axle fluid level and add fluid as needed. (See footnote **.)
0 Vehicles With GVWR Above 8,500 lbs. Only: Inspect shields and underhood
insulation for damage or looseness. Adjust or replace as required.
This is a
Noise Emission Control Service. Applicable only to vehicles sold in the
United Stutes.
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
rotation pattern and additional information. (See footnote
+.)
An Emission Control Service.
(See footnote #.)
50,000 M -YS ,I3 000 km)
Change automatic transmission fluid and filter if the vehicle’s GVWR is
over
8600 lbs. or if the vehicle is mainly driven under one or more of
these conditions:
- In heavy city traffic where the outside temperature regularly reaches 90°F
- In hilly or mountainous terrain.
(32°C) or higher.
(Continued)
DATE I
I DATE I
MILEAGE ACTUAL I SERVICED BY
7-31

Downloaded from www.Manualslib.com manuals search engine Long Triphlighway Maintenance Schedule -- Gasoline Engines
50,000 Miles (83 000 km) (Continued)
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, change the fluid
and filter at
100,000 miles (166 000 km).
52,500 Miles (87 500 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check axle fluid level and add fluid as needed. (See footnote **.)
0 Rotate tires. See “Tire Inspection and Rotation” in the I\
ndex for proper
rotation pattern and additional information. (See footnote
+.)
An Emission Control Service.
(See footnote #.)
60,000 Miles (100 000 km)
I DATE I
MILEAGE
DATE
I
0 Change engine oil and filter (or every 12 months, whichever occurs first).
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check axle fluid level and add fluid as needed. (See footnote **.)
0 Clean and repack the front wheel bearings (or at each brake relining,
An Emission Control Service.
(See footnote #.)
whichever occurs first).
7-32

Downloaded from www.Manualslib.com manuals search engine I Long TripMighway Maintenance Schedule -- Gasoline Engines
67,500 Miles (112 500 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check axle fluid level and add fluid as needed. (See footnote **.)
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
rotation pattern and additional information. (See footnote
+.)
An Emission Control Service.
(See footnote #.)
75,000 Miles (125 000 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
An Emission Control Service.
Lubricate chassis components (or every 12 months, whichever occurs first).
Check axle fluid level and add fluid as needed. (See footnote **.)
0 Vehicles With GVWR Above 8,500 lbs. Only: Inspect shields and underhood
insulation for damage or looseness. Adjust or replace
as required. This is a
Noise Ernission Control Service. Applicable
only to vehicles sold in the
United States.
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
rotation pattern and additional information. (See footnote
+.)
(See footnote #.)
DATE I 1
MILEAGE
ACTUAL SERVICED BY
DATE __ - 1
7-34

Downloaded from www.Manualslib.com manuals search engine Long Tripmighway Maintenance Schedule -- Gasoline Engines
82,500 Miles (137 500 km)
0
0
Change engine oil and filter (or every 12 months, whichever occurs first).
An Emission Control Service.
Lubricate chassis components (or every 12 months, whichever occurs first).
(See footnote
#.)
Check axle fluid level and add fluid as needed. (See footnote *‘I:.)
Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
rotation pattern and additional information. (See footnote
+.)
90,000 Miles (150 000 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
El Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check axle fluid level and add fluid as needed. (See footnote 2::i:.)
0 Clean and repack the front wheel bearings (or at each brake relining,
0 Replace fuel filter.
0 Replace air cleaner filter.
An Emission Control Service.
(See footnote #.)
whichever occurs first).
An Emissio1z Corltr-ol Service. (See footnote*.)
An Emission Control Service.
I MILEAGE ACTUAL I SERVICEDBY I
I DATE I
MILEAGE
ACTUAL SERVICED BY
(Continued)
- 7-35