1998 CHEVROLET EXPRESS oil temperature

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Short Trip/City Definition -- Gasoline Engines
Follow the Short Trip/City Maintenance Schedule if any
one of these conditions is true for your vehicle:
Most trips are less than 5 to 10 miles (8 to 16 km).
This is particularly important when outside
temperatures are below freezing.
Most trips include extensive idling (such as frequent
driving
in stop-and-go traffic).
Most trips are through dusty areas.
You frequently tow a trailer or use a carrier on top of
If the vehicle is used for delivery service, police, taxi
One of the reasons you should follow this schedule if
you operate your vehicle under any of these conditions
is that these conditions cause engine oil
to break
down sooner:
your vehicle.
or other commercial application.
Short Trip/City Intervals -- Gasoline Engines
Every
3,000 Miles (5 000 km): Engine Oil and Filter
Change (or
3 months, whichever occurs first). Chassis
Lubrication (or
3 months, whichever occurs first). Drive
Axle Service (or
3 months, whichever occurs first).
Every 6,000 Miles (10 000 km): Tire Rotation.
Every 15,000 Miles (25 000 km): Air Cleaner Filter
Inspection, if driving in dusty conditions. Shields and
Underhood Insulation Inspection (GVWR above
8,500 lbs. only). Front Wheel Bearing Repack (or at
each brake relining, whichever occurs first).
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement. Fuel Filter Replacement.
Every 50,000 Miles (83 000 km): Automatic
Transmission Service (vehicles over
8600 GVWR or
driven under severe conditions only).
7-5

Downloaded from www.Manualslib.com manuals search engine -
Short Trip/City Maintenance Schedule -- Gasoline Engines
48.000 Miles (80 000 km) , ,
Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
Lubricate chassis components (or every 3 months, whichever occurs first).
(See footnote
#.)
Check axle fluid level and add fluid as needed. (See footnote **.)
Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
rotation pattern and additional information. (See footnote
+.)
DATE I
50,000 Miles (83 000 km)
17 Change automatic transmission fluid and filter if the vehicle’s GVWR is
over 8600 lbs. or if the vehicle is mainly driven under one or more of
these conditions:
- In heavy city traffic where the outside temperature regularly reaches 90°F
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, change the fluid
and filter at
IO0,OOO miles (I 66 000 km).
(32°C) or higher.
7-16

Downloaded from www.Manualslib.com manuals search engine I Short TripKity Maintenance Schedule -- Gasoline Engines I
0 Check axle fluid level and add fluid as needed. (See footnote **.)
Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
rotation pattern and additional information. (See footnote
+.)
99,000 Miles (165 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
17 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check axle fluid level and add fluid as needed. (See footnote **.)
An Emission Control Service.
(See footnote #.)
100,000 Miles (166 000 km)
0 Inspect spark plug wires.
An Emission Control Service.
17 Replace spark plugs.
An Emission Control Service.
17 Change automatic transmission fluid and filter if the vehicle’s GVWR is
over
8600 lbs. or if the vehicle is mainly driven under one or more of
these conditions:
- In heavy city traffic where the outside temperature regularly reaches 90°F
(32°C) or higher.
I 1
DATE I
I MILEAGE ACTUAL I SERVICEDBY I
DATE I
I MILEAGE ACTUAL I SERVICEDBY: I
(Continued)
7-25

Downloaded from www.Manualslib.com manuals search engine Long Tripmighway Maintenance Schedule -- Gasoline Engines
45,000 Miles (75 000 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check axle fluid level and add fluid as needed. (See footnote **.)
0 Vehicles With GVWR Above 8,500 lbs. Only: Inspect shields and underhood
insulation for damage or looseness. Adjust or replace as required.
This is a
Noise Emission Control Service. Applicable only to vehicles sold in the
United Stutes.
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
rotation pattern and additional information. (See footnote
+.)
An Emission Control Service.
(See footnote #.)
50,000 M -YS ,I3 000 km)
Change automatic transmission fluid and filter if the vehicle’s GVWR is
over
8600 lbs. or if the vehicle is mainly driven under one or more of
these conditions:
- In heavy city traffic where the outside temperature regularly reaches 90°F
- In hilly or mountainous terrain.
(32°C) or higher.
(Continued)
DATE I
I DATE I
MILEAGE ACTUAL I SERVICED BY
7-31

Downloaded from www.Manualslib.com manuals search engine Engine ....................................... 6-10
Coolant
..................................... 6-21
Coolant Level Check
.......................... 7-38
Coolant Temperature Gage
..................... 2-57
Cooling System
.............................. 5- 14
Exhaust
...................... 2.29.2.30.2.33 .4.26
FuseBlock
.................................. 6-65
Identification
........................... 6.60. 6.67
OilLevelCheck
.............................. 7-38
Overheating
................................. 5-11
Running While Parked ......................... 2-30
Starting Your
................................ 2- 18
EngineOil
.................................... 6-12
Adding
..................................... 6-13
Additives
................................... 6-15
Checking ................................... 6-13
Pressure Gage
................................ 2-60
Used
....................................... 6-16
Whentochange
.............................. 6-15
Exhaust, Engine
................. 2-29.2-30,2-33, 4-26
Engine Coolant Heater
........................... 2-20
Engine Oil (Continued)
Exterior Lamps
................................. 2-40
Fabric Cleaning
............................... 6-52
Filling a Portable Fuel Container .................... 6-7
FillingYourTank
................................ 6-5
Filter. Air
..................................... 6-16
Finish Care
.................................... 6-55
Finish Damage
................................. 6-57 First Gear. Automatic Transmission
................ 2-23
Flashers. Hazard Warning
......................... 5-2
Flat Tire. Changing
............................. 5-22
Fluids and Lubricants
............................ 7-44
Foreign Countries. Fuel
........................... 6-5
French Language Manual
11
Front Parkingnurn Signal Lamp Bulb Replacement .... 6-35
Front Storage Area
.............................. 2-48
FrontTowing
.................................. 5-10
Fuel .......................................... 6-3
Canada ...................................... 6-3
Filling
a Portable Container ...................... 6-7
FillingYourTank
.............................. 6-5
Gage
....................................... 2-63
In Foreign Countries
........................... 6-5
Tankcapacity
............................... 6-69
Fuses and Circuit Breakers
....................... 6-61
.. ...........................
Gages
Engine Coolant Temperature
.................... 2-57
Engine Oil Pressure
........................... 2-60
Fuel
....................................... 2-63
Speedometer
................................. 2-52
Voltmeter
................................... 2-55
GAWR
....................................... 4-27
Gear Positions. Automatic Transmission
............. 2-21
Gross Axle Weight Rating
........................ 4-27
Gross Vehicle Weight Rating
...................... 4-27
Guide en Franpis
11
GVWR ....................................... 4-27
.. .................................
9-4

Downloaded from www.Manualslib.com manuals search engine Off-Road Recovery ............................. 4- 1 1
Oil. Engine .................................... 6-12
Overheating Engine
............................. 5- 1 1
Owner Checks and Services ....................... 7-38
Owner Publications. Ordering
................ 8- 1 1. 8- I2
Paint Spotting. Chemical
........................ 6-58
Park Automatic Transmission
....................... 2-21
Shifting Into
................................. 2-25
Shifting Out of
............................... 2-28
AtNight
.................................... 2-15
Brake ...................................... 2-24
BrakeMechanismCheck
....................... 7-41
Over Things That Burn
........................ 2-29
With a Trailer
................................ 4-36
Passenger Position
.............................. 1-26
Passing
................................... 4-11
Passlock
..................................... 2-16
Periodic Maintenance Inspections
.................. 7-42
Power
Antenna Mast Care
............................ 3-27
DoorLocks
................................... 2-5
Remote Control Mirror
........................ 2-45
Seat
......................................... 1-3
Steering
..................................... 4-8
Steering Fluid
................................ 6-25
Windows
................................... 2-31
Pregnancy. Use
of Safety Belts .................... 1-25
Parking
Lots
....................................... 2-16
8 *.
Problems on the Road ............................ 5-1
Publications. Service and Owner
.............. 8- 1 1. 8- 12
Radiator
..................................... 5-18
Radiator Pressure Cap ........................... 6-24
Radio Reception
................................ 3-23
Radios
.......................... 3-7.3-9.3-11. 3- 16
Rain. Driving In
................................ 4-15
Reading Lamps
................................ 2-43
Rear Axle
....................................... 6-21
Door Security Locks
........................... 2-5
Outside Seat Position
.......................... 1-34
Seatpassengers
.............................. 1-34
Towing
..................................... 5-11
Rear Air Conditioning and Rear Heater
............... 3-5
Rear Heater Controls (without Air Conditioning)
....... 3-4
Rear Passenger Temperature Control
................. 3-5
Rear Safety Belt Comfort Guides
.................. 1-37
Rearview Mirror
................................ 2-45
Reclining Front Seatbacks
......................... 1-3
Recommended Fluids and Lubricants
............... 7-44
Recovery Tank. Coolant
.......................... 5-16
Refrigerants. Air Conditioning
.................... 6-70
Remote Compact Disc Player
..................... 3-20
Replacement Bulbs
...................................... 6-66
Parts
....................................... 6-69
Wheel
...................................... 6-49
Replacing Safety
Belts ........................... 1-62
Reporting Safety Defects
.................... 8- 10. 8- 1 1
9-7