1998 BMW Z3M ROADSTER dash

BMBMWBMWBMW
Z3
04/99INTRODUCTION
0110.0-
1998
01
General Conventions
1. Switches and relays are always shown in rest position (e.g. K11).
2. A component shown in a dashed frame signifies that the component is
illustrated only in part (e.g. P90 and P91).
3. A component shown in a completely drawn frame signifies that the
component is illustrated in full (e.g. K11).
4. The dashed line between pin 8 and pin 6 of connector X293 indicates
that both pins belong to connector X293.
5. The dashed line from fuse F1 to pin 8 of connector X293 shows the
positive supply of relay K11. If required, refer to cell 0670.3 Fuse Details at
fuse F1 for the complete line progressing with plug connections, line
branches, wire colors and cross sections.6. The dashed line with an arrow at splice X452 indicates that several wires
lead to splice X452. All lines leading to the connection are illustrated in
cell 6100.0 Central Body Electronics (ZKE). An interrupted line with an
arrow indicates that only this one wire leads to another circuit.
7. The dashed line from pin 4 of connector X293 to ground X493 shows the
ground supply for relay K11. If required, refer to cell 0670.4 Ground
Distribution at ground X493 for the complete line progression with all plug
connections, line branches, wire colors, and cross sections.
8. The interrupted line from splice X452 with an A in the open arrow is
continued on page 6160.0–02.
Termination of wire 4 VI/SW from splice X452 with a wavy line indicates that
the wire is continued on the opposite page.






 !""




#""$


A WAVY LINE
MEANS WIRE IS
CONTINUED
ENTIRE COMPONENT
SHOWN
COMPONENT WITH
SCREW TERMINALS
CONNECTOR
ATTACHED TO
COMPONENT
PART OF COMPONENT
SHOWN
.75 BR.5 BR
X270
4
.5 BR
.5 BR
3
.5 BR.5 BR
X270
4
.5 BR
.75 GN/WS CONNECTOR
ATTACHED TO
COMPONENT LEAD
(PIGTAIL)
COMPONENT CASE
ATTACHED
DIRECTLY TO
METAL PART OF
CAR (GROUNDED)WIRE INSULATION
IS ONE COLOR
PIN NUMBER
WIRE INSULATION
IS ONE COLOR
WITH ANOTHER
COLOR STRIPE
(GREEN WITH
WHITE)
WIRE ATTACHED
TO METAL PART
OF CAR
(GROUNDED)
GROUND NUMBERED
FOR REFERENCE ON
COMPONENT LOCATION
CHART
WIRE SIZE IN MM
SQUARED
BL BLUEWIRE COLOR
BR BROWN
GE YELLOW
GN GREEN
GR GRAY
OR ORANGE
RS PINK
RT RED
SW BLACK
VI VIOLET
WS WHITE
ONE POLE, TWO
POSITION SWITCH
SWITCHES THAT
MOVE TOGETHER
DASHED LINE SHOWS A
MECHANICAL CONNECTION
BETWEEN SWITCHES
TR TRANSPARENT
CONNECTOR REFERENCE
NUMBER FOR COMPONENT
LOCATION CHART
TWO CONNECTIONS
(PINS) IN THE SAME
CONNECTOR
DASHED LINE INDICATES
TERMINALS OF THE
SAME CONNECTOR
12
X165
1212
SYMBOLS






POWER DISTRIBUTION CHART
RELAY PANEL UNDER LH SIDE OF DASHBOARD
 !""





#""$


N17
CRASH CONTROL
MODULEX65
K6301w
FUEL PUMP RELAYX6301
K46
HIGH BEAM LIGHT
RELAYX10262
*K46z
DAY LIGHT RELAY
MODULEX10262
*CDN






7000.0 COMPONENT LOCATION CHART






 !""#""$
COMP. DESCRIPTION LOCATION7100.0 8500.0
A2w . . INSTRUMENT CLUSTER . . . . . . . . . . . . . . . LH side of dash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20-2

A7 . . . .
SLIP CONTROL MODULE (ABS) . . . . . . . .
behind glove box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
00-1



A8 . . . .

CRUISE CONTROL MODULE
(TEMPOMAT) . . . . . . . . . . . . . . . . . . . . . . .

behind glove box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

00-2

A12 . . SUPPLEMENTAL RESTRAINT SYSTEM
CONTROL MODULE . . . . . . . . . . . . . . . . . below center console . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22-2

A18 . .

HIFI AMPLIFIER . . . . . . . . . . . . . . . . . . . . . . .

in RH side of luggage compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

27-3


A35y . BOARD COMPUTER (BC – LOW) . . . . . . . center console . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 01-3
A51 . . WIPER/WASHER MODULE . . . . . . . . . . . . . behind glove box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 00-2
A52 . . SLIP CONTROL MODULE (ABS/ASC) . . . . behind glove box (4–cylinder) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 00-1

A52 . .
SLIP CONTROL MODULE (ABS/ASC) . . . .
behind glove box (6–cylinder) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
00-3

A64 . . WIPER/WASHER MODULE (LOW II) . . . . . behind glove box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 00-2


A104 .

BODY ELECTRONICS CONTROL
MODULE (ZKE IV) . . . . . . . . . . . . . . . . . . .

behind glove box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

00-2

A110 . . DIGITAL CLOCK . . . . . . . . . . . . . . . . . . . . . . . center console
A113 . . SEAT OCCUPANCY DETECTOR . . . . . . . . under RH front seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-1
A113 . . SEAT OCCUPANCY DETECTOR . . . . . . . . under RH front seat (WITH SPORT SEAT) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41-2

A605 .
FUSE HOLDER . . . . . . . . . . . . . . . . . . . . . . . .
center console (radio and console removed) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
38-1

A835 . TRANSMITTER MODULE (EWS II) . . . . . . near steering column . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 01-2


A836 .

ELECTRONIC IMMOBILIZER CONTROL
MODULE (EWS II) . . . . . . . . . . . . . . . . . . .

behind glove box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

00-1

A6000 ENGINE CONTROL MODULE (DME) . . . . . rear RH side of engine compartment in E–Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 01-1


A8500

TRANSMISSION CONTROL MODULE
(EGS) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

rear RH side of engine compartment in E–Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

01-1






COMPONENT LOCATION CHART





 !""#""$
COMP.8500.0 7100.0LOCATION DESCRIPTION


E105 .

HEAT/A/C CONTROL PANEL
ILLUMINATION . . . . . . . . . . . . . . . . . . . . . .

center of dash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

21-3



E106 .

HEAT/A/C CONTROL PANEL
ILLUMINATION . . . . . . . . . . . . . . . . . . . . . .

center of dash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

21-3

E800 . FRONT LEFT INTERIOR LIGHT . . . . . . . . . near interior rear view mirror
F97 . . . FUSIBLE LINK . . . . . . . . . . . . . . . . . . . . . . . . . in RH side of luggage compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 03-1

G1 . . .

BATTERY . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

in RH side of luggage compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

03-1


G5 . . . DRIVER’S AIR BAG GAS GENERATOR . . behind steering wheel


G6 . . .

PASSENGER’S AIR BAG GAS
GENERATOR . . . . . . . . . . . . . . . . . . . . . . .

behind glove box above





G12 . .

DRIVER’S SIDE PYROTECHNICAL BELT
TENSIONER . . . . . . . . . . . . . . . . . . . . . . . .

in LH front seat belt buckle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

38-2



G13 . .

PASSENGER’S SIDE PYROTECHNICAL
BELT TENSIONER . . . . . . . . . . . . . . . . . . .

in RH front seat belt buckle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

38-2

G14 . . LEFT SIDE AIR BAG GAS GENERATOR . LH front door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41-3
G15 . . RIGHT SIDE AIR BAG GAS GENERATOR RH front door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39-2
G6430 B+ JUMP START JUNCTION POINT . . . . . rear RH side of engine compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 03-2

G6509

GENERATOR . . . . . . . . . . . . . . . . . . . . . . . . . .

front LH side of engine compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

02-3


H1w . . ANTI–THEFT HORN (ALPINE) . . . . . . . . . . rear LH side of engine compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 09-1
H2 . . . LEFT HORN . . . . . . . . . . . . . . . . . . . . . . . . . . . under LH front bumper
H3 . . . RIGHT HORN . . . . . . . . . . . . . . . . . . . . . . . . . RH front of wheel well . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13-2

H4 . . .
RIGHT FRONT TURN LIGHT . . . . . . . . . . . .
front of vehicle



H7 . . . LEFT FRONT TURN LIGHT . . . . . . . . . . . . . front of vehicle
H8 . . . RIGHT FRONT AUXILIARY TURN LIGHT . front of vehicle






COMPONENT LOCATION CHART






 !""#""$
COMP.8500.0 7100.0LOCATION DESCRIPTION
H9 . . . LEFT FRONT AUXILIARY TURN LIGHT . . front of vehicle

H10 . .
CHIME MODULE . . . . . . . . . . . . . . . . . . . . . .
below LH side of dash



H34 . . HIGH LEVEL STOP LIGHT . . . . . . . . . . . . . . on lift gate
H50 . . RIGHT FRONT HIGH RANGE SPEAKER . in upper RH front door
H51 . . RIGHT FRONT LOW RANGE SPEAKER . in lower RH A–pillar
H52 . . RIGHT REAR LOW RANGE SPEAKER . . . in rear speaker box

H54 . .
RIGHT FRONT MIDRANGE SPEAKER . . .
in upper RH front door





H54z .

REAR RIGHT MID–HIGH RANGE
SPEAKER . . . . . . . . . . . . . . . . . . . . . . . . . .

in rear speaker box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

40-3

H55 . . LEFT FRONT MIDRANGE SPEAKER . . . . in upper LH front door
H55z . REAR LEFT MID–HIGH RANGE SPEAKER in rear speaker box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42-1
H57 . . LEFT REAR LOW RANGE SPEAKER . . . . in rear speaker box
H58 . . LEFT FRONT LOW RANGE SPEAKER . . . in lower LH A–pillar

H59 . .

LEFT FRONT HIGH RANGE SPEAKER . .

in upper LH front door




H500 . REAR WOOFER . . . . . . . . . . . . . . . . . . . . . . . in rear speaker box
I1008 . SEAT MAT . . . . . . . . . . . . . . . . . . . . . . . . . . . . in passenger’s seat area
K2 . . . . HORN RELAY . . . . . . . . . . . . . . . . . . . . . . . . . rear LH side of engine compartment in Power Distribution Box . . . . . . . . . . . . . . . . . . 09-2

K4 . . . .
BLOWER RELAY . . . . . . . . . . . . . . . . . . . . . .
rear LH side of engine compartment in Power Distribution Box . . . . . . . . . . . . . . . . . .
09-2

K9 . . . . UNLOADER RELAY, TERMINAL 15 . . . . . . rear LH side of engine compartment in Power Distribution Box . . . . . . . . . . . . . . . . . . 09-3
K10 . . ABS RELAY . . . . . . . . . . . . . . . . . . . . . . . . . . . rear LH side of engine compartment in Power Distribution Box . . . . . . . . . . . . . . . . . . 09-3
K16 . . HAZARD FLASHER RELAY . . . . . . . . . . . . . rear LH side of engine compartment in Power Distribution Box . . . . . . . . . . . . . . . . . . 09-2
K19 . . COMPRESSOR CONTROL RELAY . . . . . . rear LH side of engine compartment in Power Distribution Box . . . . . . . . . . . . . . . . . . 09-3






COMPONENT LOCATION CHART





 !""#""$
COMP.8500.0 7100.0LOCATION DESCRIPTION
K21 . . NORMAL SPEED RELAY . . . . . . . . . . . . . . . rear LH side of engine compartment in Power Distribution Box . . . . . . . . . . . . . . . . . . 09-3

K22 . .
HIGH SPEED RELAY . . . . . . . . . . . . . . . . . . .
rear LH side of engine compartment in Power Distribution Box . . . . . . . . . . . . . . . . . .
09-3

K33a . AIR CONDITIONING RELAY, MOTRONIC . Power Distribution Box, rear LH side of engine compartment . . . . . . . . . . . . . . . . . . . 08-3
K46 . . HIGH BEAM LIGHT RELAY . . . . . . . . . . . . . footwell, driver’s side (USA) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19-1
K46z . DAY LIGHT RELAY MODULE . . . . . . . . . . . . footwell, driver’s side (CDN)
K47 . . FRONT FOG LIGHT RELAY . . . . . . . . . . . . . rear LH side of engine compartment in Power Distribution Box . . . . . . . . . . . . . . . . . . 09-2

K48 . .
LOW BEAM LIGHT RELAY . . . . . . . . . . . . . .
rear LH side of engine compartment in Power Distribution Box . . . . . . . . . . . . . . . . . .
09-2

K75 . . ABS PUMP MOTOR RELAY . . . . . . . . . . . . . rear LH side of engine compartment in Power Distribution Box . . . . . . . . . . . . . . . . . . 09-3
K94 . . ENGINE CONTROL RELAY (ABS/ASC) . . Power Distribution Box, rear LH side of engine compartment . . . . . . . . . . . . . . . . . . . 08-3
K95 . . VALVE RELAY (ABS/ASC) . . . . . . . . . . . . . . Power Distribution Box, rear LH side of engine compartment . . . . . . . . . . . . . . . . . . . 08-3

K910 .
PASSENGER’S SEAT TILT ADJUST
CUT–OFF RELAY . . . . . . . . . . . . . . . . . . . .
underside of RH front seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
41-1


K911 . .
PASSENGER’S SEAT LENGTH ADJUST
CUT–OFF RELAY . . . . . . . . . . . . . . . . . . . .
underside of RH front seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
41-1


K920 .
DRIVER’S SEAT TILT ADJUST CUT–OFF
RELAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
underside of LH front seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
42-2


K921 .
DRIVER’S SEAT LENGTH ADJUST
CUT–OFF RELAY . . . . . . . . . . . . . . . . . . . .
underside of LH front seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
42-2

K6300 ENGINE CONTROL MODULE RELAY . . . . rear RH side of engine compartment in E–Box (6–cylinder) . . . . . . . . . . . . . . . . . . . . . 01-1

K6300
ENGINE CONTROL MODULE RELAY . . . .
rear RH side of engine compartment in E–Box (4–cylinder) . . . . . . . . . . . . . . . . . . . . .
36-3

K6301w FUEL PUMP RELAY . . . . . . . . . . . . . . . . . . . . below LH side of dash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19-1
K6304 SECONDARY AIR PUMP RELAY . . . . . . . . rear RH side of engine compartment in E–Box (6–cylinder) . . . . . . . . . . . . . . . . . . . . . 01-1
K6304 SECONDARY AIR PUMP RELAY . . . . . . . . rear LH side of engine compartment (4–cylinder) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37-1






COMPONENT LOCATION CHART





 !""#""$
COMP.8500.0 7100.0LOCATION DESCRIPTION
M52 . . DRIVER’S SEAT HEIGHT MOTOR . . . . . . . under LH front seat (WITH SPORT SEAT) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42-3

M59 . .
PASSENGER’S SEAT HEIGHT MOTOR . .
under RH front seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
24-1



M60 . .

PASSENGER’S SEAT MOVEMENT
MOTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . .

under RH front seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

24-1

M93 . .

AUXILIARY THROTTLE POSITION
MOTOR (ADS) . . . . . . . . . . . . . . . . . . . . . .

front of engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

35-3



M101 .

CONVERTIBLE TOP MOTOR . . . . . . . . . . .

in LH side of luggage compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

25-3


M111 . FRESH AIR RECIRCULATION MOTOR . . . RH side of LH footwell . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21-2
M805 . ELECTRICAL COMPRESSOR . . . . . . . . . . . TIRE INFLATION SYSTEM
M6506 E–BOX FAN . . . . . . . . . . . . . . . . . . . . . . . . . . . in E–Box

M6510
STARTER . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
rear LH side of engine compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
02-2

N5 . . . ANALOG CLOCK . . . . . . . . . . . . . . . . . . . . . . center console
N8 . . . ANTENNA AMPLIFIER AM/FM . . . . . . . . . . in LH side of luggage compartment behind trim panel
N9 . . . RADIO . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . center console

N12w .
ANTI–THEFT CONTROL MODULE
(ALPINE) . . . . . . . . . . . . . . . . . . . . . . . . . . .
behind glove box



N17 . . CRASH CONTROL MODULE . . . . . . . . . . . . footwell, driver’s side . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19-1

N22 . .
CD CHANGER . . . . . . . . . . . . . . . . . . . . . . . . .
in LH forward side of luggage compartment



P90 . . FRONT POWER DISTRIBUTION BOX . . . rear LH side of engine compartment
P95 . . AUXILIARY FUSE BOX . . . . . . . . . . . . . . . . . below LH side of dash
P97 . . AUXILIARY FUSE BOX . . . . . . . . . . . . . . . . . below LH side of dash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19-1
R11 . . . BLOWER RESISTORS . . . . . . . . . . . . . . . . . rear of engine compartment behind firewall