1997 VOLKSWAGEN PASSAT ECU

Downloaded from www.Manualslib.com manuals search engine 46-30

14 - Outer wheel bearing
15 - Hex nut Adjusting wheel
bearing play Using a screwdriver it
must be possible to
move the thrust
washer by finger
pressure (without
leverage) Page 42-20 Secure with locking
ring and new cotter pin 16 - Cotter pin Always replace 17 - Grease cap Removing and
installing Page 42-29 18 - Lock ring
19 - Thrust washer
20 - Wheel bolt, 110 Nm (81
ft lb) Page 4 of 10Rear wheel brakes, servicing (disc brakes)12/7/2004http://ebahn.bentleypublishers.com/vw/servlet/Display?action=Goto&type=repair&id=VW.B4.SU01.46.5

Downloaded from www.Manualslib.com manuals search engine 46-33

Brake pads, removing and installing

Note:
Mark brake pads when removing if they are to be
reused. Re-install in their original position to
prevent uneven braking!

Removing

- Remove wheels. - Remove parking brake cable from brake caliper
(arrow).
- Remove securing bolts from brake caliper housing; counter-hold on guide pins. - Remove brake pads. Page 7 of 10Rear wheel brakes, servicing (disc brakes)12/7/2004http://ebahn.bentleypublishers.com/vw/servlet/Display?action=Goto&type=repair&id=VW.B4.SU01.46.5

Downloaded from www.Manualslib.com manuals search engine 46-35

- Secure brake caliper housing with new self-
locking bolts. Note: - Attach parking brake cable (arrow) to brake caliper housing. After each brake pad change firmly depress brake
pedal several times with vehicle stationary, so
that the brake pads are properly seated in their
normal operating position. After changing brake pads check brake fluid level. Page 9 of 10Rear wheel brakes, servicing (disc brakes)12/7/2004http://ebahn.bentleypublishers.com/vw/servlet/Display?action=Goto&type=repair&id=VW.B4.SU01.46.5

Downloaded from www.Manualslib.com manuals search engine 46-39
The parking brake cable is secured by clamps to the
axle beam in the center of the two colored marks
(arrow). Fig. 1 Parking brake cable installation
position Fig. 2 Hand grip, removing - Pry up parking brake cable trim with a screwdriver
and pull grip and trim off forward. Page 3 of 9Parking brake lever assembly overview12/7/2004http://ebahn.bentleypublishers.com/vw/servlet/Display?action=Goto&type=repair&id=VW.B4.SU01.46.6

Downloaded from www.Manualslib.com manuals search engine 46-40
Fig. 3 Center console, removing - Remove rear ashtray (center console). - Remove console rear securing screws (arrows). Page 4 of 9Parking brake lever assembly overview12/7/2004http://ebahn.bentleypublishers.com/vw/servlet/Display?action=Goto&type=repair&id=VW.B4.SU01.46.6

Downloaded from www.Manualslib.com manuals search engine 46-41

Brake pedal/brake servo,
removing and installing
CAUTION!
The brake pedal travel must
not be restricted by
additional floor coverings.
Note:
Grease all mountings before
installing with G 000 602
grease.
1 - Securing clip Ensure securely
seated
2 - Pin
3 - Brake servo push rod
clevis
4 - Self-locking hex nut, 20 Nm (15 ft lb)
5 - Brake pedal pivot pin Page 5 of 9Parking brake lever assembly overview12/7/2004http://ebahn.bentleypublishers.com/vw/servlet/Display?action=Goto&type=repair&id=VW.B4.SU01.46.6

Downloaded from www.Manualslib.com manuals search engine 46-43

16 - Securing clip Ensure seated
securely
17 - Brake Light Switch Adjusting Page 46-45 Page 7 of 9Parking brake lever assembly overview12/7/2004http://ebahn.bentleypublishers.com/vw/servlet/Display?action=Goto&type=repair&id=VW.B4.SU01.46.6

Downloaded from www.Manualslib.com manuals search engine 46-44

Brake pedal, removing and installing

Note:
Grease all mounting and contact surfaces with
MoS
2 grease.
To remove brake servo disconnect brake pedal
at clevis only.

Removing

- Before removing brake pedal remove trim
- Remove brake pedal clevis pin connection
securing clip.

- Remove pin.
- Remove brake pedal pivot pin securing clip.
- Remove pivot pin.
- Remove mounting sleeve, return spring
mounting tube with brake pedal.

Installing

- Install in reverse order. Page 8 of 9Parking brake lever assembly overview12/7/2004http://ebahn.bentleypublishers.com/vw/servlet/Display?action=Goto&type=repair&id=VW.B4.SU01.46.6