1997 PONTIAC FIREBIRD manual transmission

Manual Transmission Fluid
When to Check
A good time to have it checked is when the engine oil is
changed. However, the fluid in your manual
transmission doesn’t require changing.
How to Check
Because this operation can be difficult, you may
choose to have this done at your Pontiac dealership
Service Department.
If you do it yourself, be sure to follow all the
instructions here, or
you could get a false reading.
NOTICE:
Too much or too little fluid can damage your
transmission.
Too much ‘can mean that some of
the fluid could come out and fall on hot engine parts
or exhaust system parts, starting a fire. Be
: sure to get an accurate reading if you check your
I transmission fluid.
Check the fluid level only when your engine is off, the
vehicle is parked on a level place and the transmission is
cool
enough for you to rest your fingers on the
transmission case.
Then, follow these steps:
1. Remove the filler plug.
2. Check that the lubricant level is up to the bottom
of the filler plug hole.
3. If the fluid level is good, install the plug and be sure
it is fully seated. If the fluid level
is low, add more
fluid as described in the next steps.
How to Add Fluid
Here’s how to add fluid. Refer to the Maintenance
Schedule to determine what kind of fluid to use. See
“Recommended Fluids and Lubricants” in the Index.
1. Remove the filler plug.
2. Add fluid at the filler plug hole. Add only enough
fluid to bring the fluid level up to the bottom of
the filler plug hole.
3. Install the filler plug. Be sure the plug is fully seated.
6-27

Capacities (Approximate)
The following approximate capacities are given in
English. and metric conversions. Please refer to
“Recommended Fluids and Lubricants” in the Index
for more information.
Air Conditioning?
, ... See the refrigerant
information label
under the hood.
Automatic Transmission Drain and Refill
............... 10 pints (4.7 L)*
Overhaul
VIN Engine Code K ........ 17.6 pints (8.3 L)*
VIN Engine Code P ....... 2 1.6 pints (10.2 L)*
Cooling System
VIN Engine Code K
With Manual Transmission . . 12.5 quarts (11.8 L)
With Automatic Transmission 12.3 quarts (1 1.6 L)
VIN Engine Code P
With Manual Transmission . 15.3 quarts (14.5 L)
With Automatic Transmission 15.1 quarts (14.3 L)
Crankcase
Oil and Filter Change
3800 (VIN K) ........... 4.5 quarts (4.3 L)**
5.7L (VIN P ) ............ 5.0 quarts (4.7 L)**
Fuel Tank
.................. 15.5 gallons (58.7 L)
Manual Transmission
Five-Speed
........... , . 6.8 pints (3.2 L)*
Six-Speed .......... ..... 8.0 pints (3.8L)*
Rear Axle Lubricant ............ 3.5 pints (1.7L)
Not all air conditioning refrigerants are the same.
If the air conditioning system in your vehicle needs
refrigerant, be sure the proper refrigerant is used.
If you’re not sure, ask your Pontiac dealer,
* Recheck fluid level after filling. See “Automatic
Transmission Fluid”
or “Manual Transmission Fluid”
in the Index.
** Recheck the oil level after filling. See “Engine Oil”
in
the Index.
6-74

I Short Trip/City Maintenance Schedule I
I!T9000 Miles (25 000. km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An,Emission Control Service.
0 Inspect air cleaner filter if you are driving
in dusty conditions. Replace filter if
necessary.
An Emission Control Servic'e. (See
footnote"f.)
0 Change 'automatic transmission fluid and
filter
if the vehicle is mainly driven I.-- ler
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, poli'ce or
delivery service.
lf you do not use your vehicle under any of
these conditions, change the fluid and filter at
~00,000 miles (166 000 km).
Manual transmission fluid doesn't
require chanqe.
- -
DATE
SERVICED BY: ACTUAL MILEAGE -
i

Short Trip/City Maintenance Schedule
30,000 Miles (50 000 km)
Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every
6 months, whichever occurs first).
(See footnote
#.)
0 Change the rear axle gear lubricant if
vehicle is used to pull a trailer.
Replace air cleaner filter.
Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service. (See footnote?.)
An Emission Control Service.
0 Change automatic transmission fluid and
filter if the vehicle is mainly driven under
one
or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90" F
(32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
If you do not use your vehicle under any of
these conditions, change the fluid and-filter at
100,000 miles (166 000 km).
Manual transmission fluid doesn't
require change.
delivery service.
(Continued)

I Short Trip/City Maintenance Schedule I
~~
Manual transmission fluid doesn’t require change.
in dusty conditions. Replace filter if
necessary.
An Emission Control Service.
(See footnote?.)
Inspect air cleaner filter if you are driving
t
DATE
SERVICED BY: ACTUAL MILEAGE
.
48,000 Miles (80 000 km)
Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
Lubricate chassis components (or every
6 months, whichever occurs first).
(See footnote
#.)
Cl Change the rear axle gear lubricant if
vehicle
is used to pull a trailer.
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information.
(See footnote
+.) (Also see footnote ++.)
DATE SERVICED BY: ACTUAL MILEAGE
7-17

I Short Trip/City Maintenance Schedule I
60,000 Miles (I00 000 km) (Continued)
- Uses such as found in taxi, police or
If you do not use your vehicle under any of
these conditions, change the fluid and filter at
lO0,OOO miles (166 000 km).
Manual transmission fluid doesn’t
require change.
0 Inspect engine accessory drive belt.
0 Replace air cleaner filter.
delivery
service.
An Emission Control Service.
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket €or any
damage. Replace parts as needed.
An Emission Control Service. (See footnote?.)
0 Rotate tires. See “Tire Inspection and
Rotation’’ in the Index for proper rotation
pattern and additional
information.
(See footnote +.) (Also see hotnote ++.)

1 Short Trip/City Maintenance Schedule 1
75,000 Miles (125 000 km)
Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more
of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, change the fluid and filter ut
100,000 miles (1 66 000 km).
Manual transmission fluid doesn’t
require change.
in dusty conditions. Replace filter if
necessary. An Emission Control Service.
(See footnote?.)
Inspect air cleaner filter if you are driving
DATE
SERVICED BY: ACTUAL MILEAGE
7-23

90,000 Miles (150 000 km)
Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Sewice.
0 Lubricate chassis components (or every
6 months, whichever occurs first).
(See footnote #.)
0 Change the rear axle gear lubricant if
vehicle is used to pull a trailer.
0 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 F
(32 C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
vyou do not use your vehicle under any oj
these conditions, change the fluid and filter at
100,000 miles (166 000 km).
Manual transmission fluid doesn’t
require change.
Replace air cleaner filter.
An Emission Contrul Service.
Inspect fuel tank, cap and lines fur damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service. (See fOOtnOte-f..)
delivery
service.
Short TripKity Maintenance Schedule
7-26