1997 FORD RANGER check engine light

268
%*
[MC22800(R)01/96]
Power Steering Fluid
*
[MC22810(R)01/96]
Check the level of the power steering fluid at least twice a
year (i.e., every Spring and Fall).
%*
[MC22900(R)01/96]
Checking and Adding Power Steering Fluid
*
[MC22910(R)04/96]1.
Start the engine and let it run until the power steering fluid
reaches normal operating temperature. The power steering
fluid will be at the right temperature when the engine
coolant temperature gauge in the instrument cluster is near
the center of the normal operating temperature range.
*
[MC22912(R)01/96]2.
While the engine idles, turn the steering wheel back and
forth several times. Make sure that the cap assembly is
installed at this time.
*
[MC22914(R)01/96]3.
Turn the engine off.
%*
[MC22916(R)01/96]4.
Check the fluid level on the dipstick (which is highlighted in
yellow in your vehicle). The fluid level should be between
the arrows in the FULL HOT range, which is marked on the
side of the dipstick, opposite the side marked FULL COLD.
Do not add fluid if the level is within the FULL HOT range.
[MC22918(R)01/96]
10-1/2 pica
art:0021195-A
Power steering dipstick
File:11unmcr.ex
Update:Thu Mar 20 08:58:43 1997

Maintenance and Care
297
%*
[MC42450(R)01/96]
Information about your vehicle's emission control system is on
the Vehicle Emission Control Information decal located on or
near the engine. This decal identifies engine displacement and
gives some tune-up specifications.
%*
[MC42460(R)03/96]
How to Prepare Your Vehicle for
Inspection/Maintenance (I/M) Testing
*
[MC42470(R)04/96]
In some localities it may become a legal requirement to pass an
Inspection/Maintenance (I/M) test of the On-Board Diagnostic
(OBD) II system. If your check engine light is on, reference the
check engine light description under theWarning Lights and
Gaugessection. Your vehicle may not pass an I/M test with the
check engine light on. If the vehicle's powertrain system or its
battery has just been serviced, the OBD II system is reset to a
not ready for I/M testing condition. To prepare for I/M testing,
additional city and highway driving is necessary to complete the
check of the OBD II system.
*
[MC43000(R)05/96]
The driving modes required to reach the ready condition consist
of a minimum of 30 minutes of city and highway driving as
described below:
[MC43100(R)03/96]
n
20 minutes of driving in stop and go city-type traffic with at
least four (4) idle periods.
*
[MC43200(R)03/96]
n
10 minutes of driving on an expressway or highway
[MC43300(R)03/96]
Before completing the above driving modes, the engine must be
warmed up and operating temperature. Once started, the vehicle
must not be turned off during the above driving modes. If the
vehicle owner is unable to meet the I/M requirements by using
these driving patterns, an authorized service center can perform
a detailed OBD II Drive Cycle as it would any other type of
repair work.
File:11unmcr.ex
Update:Thu Mar 20 08:58:43 1997

347
Index
Climate control system.................. 64
Clock........................ 34,55
Clutch
fluid........................ 263
fluid reservoir.................261, 263
operation while driving............... 170
recommended shift speeds.............. 173
shifting the gears.................. 171
specifications.................... 313
Cold engine starting.................. 148
Combination lap and shoulder belts.........110, 112
Controls
mirrors........................ 86
power seat..................... 109
Convenience kit in cargo area.............. 229
Coolant (see Engine coolant)
checking and adding................ 265
preparing for storage................ 309
specifications.................... 313
temperature gauge.................. 22
warnings...................... 265
Cooling fan...................... 250
Crankcase emission filter................ 311
Customer Assistance Centre, Ford of Canada....... 324
D
Daytime running light system.............. 63
Defects, reporting................... 315
Defrost, windshield................. 67,70
Dipstick
automatic transmission fluid...........271, 273
engine oil..................... 258
power steering fluid................. 268
Disabled vehicle (see Towing).............. 242
File:unixr.ex
Update:Thu Mar 20 09:01:44 1997

348
Doors
lubricant specifications................ 313
Driveline universal joint and slip yoke......... 271
Driving under special conditions, heavy load...... 187
E
Electrical system
fuses......................218, 224
operating when the engine is off............ 73
relays....................... 225
Electronic sound system
accessory delay.................... 73
radio reception.................... 55
tuning the radio................. 29,46
warranty and service information............ 58
Emergencies, roadside
assistance..................... 317
battery acid spills................238, 277
fuel........................ 292
jump-starting.................... 237
towing....................... 242
Emergency brake (parking brake)..........158, 160
Emission control system
catalytic converter.................. 295
emissions warranty................ 3,295
Engine
check engine warning light.............. 14
does not start.................... 149
fuel injected engine, starting............. 147
fuel pump shut-off switch.............. 150
preparing to start.................. 147
service points.................... 253
starting...................... 148
starting after a collision............... 150
storing your vehicle................. 307
File:unixr.ex
Update:Thu Mar 20 09:01:44 1997

354
K
Keys
key in ignition chime................. 21
positions of the ignition................ 73
stuck in lock position................. 73
L
Lamps
checking...................... 298
combination cargo and brakelamp........... 72
daytime running light system............. 63
hazard flashers................... 217
headlamps...................... 61
illuminated entry system................ 97
instrument panel, dimming.............. 64
interior lamps.................. 61,64
replacing bulbs................... 298
trailer....................... 213
Lane change indicator (see Turn signal).......... 75
Lights, warning and indicator
airbag........................ 12
brake........................ 10
charging system................... 15
check engine..................... 14
engine oil pressure.................. 20
hazard warning light................ 217
high beam...................... 21
oil pressure...................... 20
overdrive off..................... 14
safety belt...................... 11
service engine soon.................. 14
turn signal indicator.................. 75
Load limits
GAWR....................... 187
GVWR....................... 187
trailer towing.................... 191
File:unixr.ex
Update:Thu Mar 20 09:01:44 1997

361
Index
Transmission
automatic operation................. 164
fluid, checking and adding (automatic)........ 272
fluid, checking and adding (manual)......... 274
lubricant specifications................ 313
Transmitter (see Remote entry).............. 93
Trip odometer...................... 25
Tune-up specifications (VECI).............. 297
Turn signal
indicator lights.................... 75
lever......................... 75
U
Used engine oil, disposal............250, 261, 273
V
Variable interval wipers................. 76
VECI (Vehicle Emission Control Information) decal.... 297
Vehicle Identification Number (VIN)........... 318
Vehicle loading
calculating the load................. 196
understanding loading information.......... 187
Vehicle storage.................... 307
Ventilating your vehicle (see Climate control)....... 64
Viscosity (see Engine oil)................ 257
Voltmeter (see Battery voltage gauge)......... 15,19
File:unixr.ex
Update:Thu Mar 20 09:01:44 1997