1997 FORD F SERIES MOTORHOME AND COMMERCIAL CHASSIS check transmission fluid

75 [GF24330( M)01/96]
NOTE: If the transmission is submerged in
water, the fluid should be checked and
changed, if necessary.
*
[GF24340( ALL)01/96]
NOTE: All rear axle lube quantities must be
replaced every 100,000 miles
(160,000 km) or if the axle has been
submerged in water. Otherwise, the
lube should not be checked or changed
unless a leak is suspected or repair
required.
*
[GF24350( ALL)01/96]
Rocking the vehicle
*
[GF24370( ALL)01/96]
If your vehicle gets stuck (for example, in mud
or snow), you may rock it out of the spot. Shift
in a steady rhythm between forward and reverse
gears. Allow the transmission to fully engage,
then press lightly on the accelerator. Do not rock
the vehicle for more than a few minutes. This
may overheat the engine and transmission,
causing damage to both. In addition, other
vehicle systems and components may also be
damaged.
*
[GF24380( ALL)01/96]
RWARNING
Do not spin the wheels at over 35 mph
(55 km/h). The tires may fail and injure a
passenger or bystander.
File:09ltgfm.ex
Update:Fri Dec 13 11:22:54 1996

114
*
[MC18700( ALL)01/96]
one third page art:0021016-B
Power steering dipstick
[MC18900( M)01/96]
one third page art:0020729-C
Power steering reservoir
*
[MC19050( ALL)01/96]
5. If the power steering fluid is low, add fluid
in small amounts, continuously checking the
level, until you reach the FULL HOT range.
Do not overfill.
% [MC19200( M)01/96]
q
Use only Motorcraft MERCONHAutomatic
Transmission Fluid XT-2-QDX or DDX or an
equivalent MERCONHapproved fluid.
*
[MC19250( ALL)01/96]
If the power steering fluid is low, do not drive
your vehicle for a long period of time before
adding fluid. This can damage the power
steering pump.
*
[MC19300( ALL)01/96]
6. When you are finished, put the dipstick back
in and make sure that it fits snugly.
File:11ltmcm.ex
Update:Fri Dec 13 11:24:54 1996

116 [MC19900( M)01/96]Inspecting for Road Damage
[MC20000( M)01/96]
The suspension and steering linkage in your
vehicle should be inspected periodically for
abnormal looseness and damaged seals. Also be
alert for changes in steering action. Hard
steering, excessive free play or unusual sounds
when turning or parking indicate a need for
inspection or servicing.
[MC20100( M)01/96]
NOTE: After any severe impact such as
striking large potholes, inadvertent
sliding into curbs on icy roads, or a
collision involving the front end,
observe the steering wheel alignment.
If the steering wheel spokes seem to
be in a different position while going
down the road, have the front
suspension and steering checked for
possible damage.
%
*
[MC21300( ALL)01/96]
Automatic Transmission Fluid
[MC21400( M)01/96]
Under normal driving conditions automatic
transmission fluid should not need changing.
Under severe duty conditions automatic
transmission fluid should be changed every
21,000 miles (34,000 km). However, if the
transmission is not working properly, for
instance, the transmission may slip or shift
slowly, or you may notice some sign of fluid
leakage, the fluid level should be checked.
[MC21500( ALL)01/96]
Transmission fluid, filter and seal assembly
should be changed every 21,000 miles
(34,000 km) only under any of the following
conditions.
[MC21550( ALL)01/96]
q
Extended periods of high speed driving
during hot weather at/or above+90ÊF
(+30ÊC).
[MC21600( ALL)01/96]
q
Towing a trailer for distances over 1,000 miles
(1,600 km) per trip.
File:11ltmcm.ex
Update:Fri Dec 13 11:24:54 1996

117 [MC21650( ALL)01/96]
q
Accumulating 5,000 miles (8,000 km) or more
per month.
[MC21700( ALL)01/96]
q
Continuous operation and/or extensive idling
(a delivery service as an example).
*
[MC21750( ALL)01/96]
q
Operating in severe dust conditions.
[MC21800( ALL)01/96]
NOTE: Use of a transmission fluid other than
specified could result in transmission
malfunction and/or failure. Refer to
ªAdding automatic transmission fluidº,
ªRefill capacitiesº and ªlubricant
specificationsº for further information.
%*
[MC21850( ALL)01/96]
Checking the Automatic Transmission
Fluid
[MC21875( ALL)01/96]
Transmission fluid should be checked at least
twice a year.
*
[MC21900( ALL)01/96]
It is preferable to check the transmission fluid
level at normal operating temperature
150ÊF-170ÊF (66ÊC-77ÊC),after approximately 20
miles (30 km) of driving. However, if necessary,
you can check the fluid level without having to
drive 20 miles (30 km) to obtain a normal
operating temperature if outside temperatures
are above50ÊF (10ÊC).
*
[MC21950( ALL)01/96]
NOTE: If the vehicle has been operated for an
extended period at high speeds or in
city traffic during hot weather, or
pulling a trailer, the vehicle should be
turned off for about 30 minutes to
allow the fluid to cool before checking.
*
[MC22000( ALL)01/96]
With the vehicle on a level surface, start the
engine and move the transmission shift selector
through all of the gear ranges allowing sufficient
time for each position to engage. Securely latch
the transmission shift selector in the P (Park)
position, fully set the parking brake and leave
the engine running.
File:11ltmcm.ex
Update:Fri Dec 13 11:24:54 1996

118
*
[MC22100( ALL)01/96]
RWARNING
Your vehicle should not be driven if the
fluid level is below the bottom hole on
the dipstick and outside temperatures are
above50ÊF (10ÊC).
*
[MC22150( ALL)01/96]
Wipe off the dipstick cap, pull the dipstick out
and wipe the indicator end clean. Put the
dipstick back into the filler tube and make sure
it is fully seated. Pull the dipstick out and read
the fluid level.
*
[MC22200( ALL)01/96]
When checking fluid at normal operating
temperature, the fluid level should be within the
crosshatched area on the dipstick. When the
vehicle has not been driven, and outside
temperature is above50ÊF (10ÊC), thefluid level
should be between the holes on the dipstick.
%*
[MC22250( ALL)01/96]
Adding Automatic Transmission Fluid
*
[MC22300( ALL)01/96]
The fluid type is stamped on the dipstick.
Before adding any fluid, be sure that the
correct type will be used.
*
[MC22350( ALL)01/96]
Add fluid in 1/2 pint (.25L) increments through
the filler tube to bring the level to the correct
area on the dipstick. If an overfill occurs, excess
fluid should be removed by a qualified
technician.
%*
[MC22400( ALL)01/96]
NOTE: Always dispose of used automotive
fluids in a responsible manner. Follow
your community's standards for
disposing of these types of fluids. Call
your local recycling center to find out
about recycling automotive fluids.
File:11ltmcm.ex
Update:Fri Dec 13 11:24:54 1996

Severe Duty Schedule 175
*
[BK52401( ALL)01/95]
15,000 MILES (25,000 Kilometers)
*
[BK52501( ALL)11/95]
q
Change engine oil and replace oil filter.
*
[BK52550( ALL)06/95]
q
Inspect engine cooling system, hoses, and clamps;
and check coolant strength every 15,000 miles
(25,000 km) or 12 months.
*
[BK52601( ALL)08/95]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK52801( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK53001( ALL)08/95]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK53030( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK53035( FM)02/95]
q
Inspect parking brake fluid (F-Super Duty).
*
[BK53050( ALL)04/93]
four pica chart:0060627-A
*
[BK53101( ALL)01/95]
18,000 MILES (30,000 Kilometers)
*
[BK53201( ALL)11/95]
q
Change engine oil and replace oil filter.
*
[BK53501( ALL)09/95]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK53601( ALL)06/95]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK53610( ALL)09/95]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
File:18ltbkm.ex
Update:Thu Dec 12 13:32:30 1996

Severe Duty Schedule 181
*
[BK60000( ALL)01/95]
45,000 MILES (75,000 Kilometers)
*
[BK60100( ALL)11/95]
q
Change engine oil and replace oil filter.
*
[BK60150( ALL)06/95]
q
Inspect engine cooling system, hoses, and clamps;
and check coolant strength every 15,000 miles
(25,000 km) or 12 months.
*
[BK60400( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK60600( ALL)08/95]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK60630( FM)02/95]
q
Inspect parking brake fluid (F-Super Duty).
*
[BK60635( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK60650( ALL)04/93]
four pica chart:0060627-A
*
[BK60700( ALL)01/95]
48,000 MILES (80,000 Kilometers)
*
[BK60800( ALL)11/95]
q
Change engine oil and replace oil filter.
*
[BK60900( ALL)01/95]
q
Change engine coolant initially at 48,000 miles
(80,000 km) or 48 months. Thereafter, change
engine coolant every 30,000 miles (50,000 km) or
36 months.
*
[BK61300( ALL)09/95]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK61400( ALL)06/95]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
File:18ltbkm.ex
Update:Thu Dec 12 13:32:30 1996

Severe Duty Schedule 185
*
[BK66030( FM)02/95]
q
Inspect parking brake fluid (F-Super Duty).
*
[BK66035( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK66050( ALL)04/93]
four pica chart:0060627-A
*
[BK66100( ALL)01/95]
63,000 MILES (105,000 Kilometers)
*
[BK66200( ALL)11/95]
q
Change engine oil and replace oil filter.
*
[BK66350( ALL)10/95]
q
Change automatic transmission fluid.
*
[BK66550( ALL)04/93]
four pica chart:0060627-A
*
[BK66600( ALL)01/95]
66,000 MILES (110,000 Kilometers)
*
[BK66700( ALL)11/95]
q
Change engine oil and replace oil filter.
*
[BK66900( ALL)09/95]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK67000( ALL)06/95]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK67050( ALL)09/95]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
File:18ltbkm.ex
Update:Thu Dec 12 13:32:30 1996