1997 FORD F SERIES MOTORHOME AND COMMERCIAL CHASSIS wheel

152
%*
[CS02660( ALL)01/96]
Vehicle Storage
*
[CS02670( ALL)01/96]
Maintenance Tips
*
[CS02680( ALL)01/96]
If you plan on storing your vehicle for an
extended period of time (60 days or more), refer
to the following maintenance recommendations
to ensure your vehicle stays in good operating
condition.
*
[CS02690( ALL)01/96]
General
*
[CS02700( ALL)01/96]
q
Store all vehicles in a dry, ventilated place.
*
[CS02710( ALL)01/96]
q
Protect from sunlight, if possible.
*
[CS02720( ALL)01/96]
q
If vehicles are stored outside, they require
regular maintenance to protect against rust
and damage.
*
[CS02730( ALL)01/96]
Body
*
[CS02740( ALL)01/96]
q
Wash vehicle thoroughly to remove dirt,
grease, oil, tar or mud from exterior surfaces,
rear wheel housing and underside of front
fenders.
*
[CS02750( ALL)01/96]
q
Periodically wash vehicles stored in exposed
locations.
*
[CS02760( ALL)01/96]
q
Touch-up raw or primed metal to prevent
rust.
*
[CS02770( ALL)01/96]
q
Cover chrome and stainless steel parts with a
thick coat of auto wax to prevent
discoloration. Re-wax as necessary when the
vehicle is washed.
*
[CS02780( ALL)01/96]
q
Lubricate all hood, door and trunk lid hinges
and latches with a light grade oil.
*
[CS02790( ALL)01/96]
q
Cover interior soft trim to prevent fading.
*
[CS02800( ALL)01/96]
q
Keep all rubber parts free from oil and
solvents.
File:12ltcsm.ex
Update:Fri Dec 13 11:25:18 1996

170
*
[BK01300( ALL)01/95]
To assure the durability of your vehicle and its
emission control systems, it is necessary that
scheduled maintenance be performed at the
designated intervals.
*
[BK01400( ALL)01/96]
Ford strongly recommends the use of genuine
Ford replacement parts. If other than Ford or
Motorcraft parts or Ford authorized
remanufactured parts are used for maintenance
replacements or for the service of components
affecting emission control, such non-Ford parts
should be equivalent to genuine Ford Motor
Company parts in performance and durability. It
is the owner's responsibility to determine the
equivalency of such parts. Please consult your
warranty booklet for complete warranty
information.
*
[BK01410( ALL)05/95]
No Cost PCV Valve Replacement
[BK01425( M)02/93]
THE PCV VALVE ON LIGHT TRUCKS IS A
CRITICAL EMISSION COMPONENT. YOUR
DEALER WILL REPLACE THE VALVE AT NO
COST AT 60,000 MILES/96,000 KILOMETERS
(EXCEPT CANADA VEHICLES).
*
[BK01435( ALL)06/94]
Wheel Lug Nuts
[BK01455( ALL)06/96]
Wheel lug nuts must be retightened to proper
torque specifications at 500 miles/800 km of
new vehicle operation (100 miles/160 km for
vehicles equipped for snowplowing). Proper
torque specifications are provided in your
Owner Guide. Also retighten to proper torque
specification at 500 miles/800 km after (1) any
wheel change or (2) any other time the wheel
lug nuts have been loosened.
File:18ltbkm.ex
Update:Thu Dec 12 13:32:30 1996

178 Severe Duty Schedule
*
[BK56300( ALL)06/95]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK56350( ALL)09/95]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK56400( ALL)08/95]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK56700( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK56900( ALL)08/95]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK57000( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK57100( ALL)08/95]
q
Inspect parking brake system for damage and
operation.
[BK57225( M)08/95]
q
Inspect parking brake fluid (F-Super Duty
only).
*
[BK57520( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK57550( ALL)04/93]
four pica chart:0060627-A
File:18ltbkm.ex
Update:Thu Dec 12 13:32:30 1996

184 Severe Duty Schedule
*
[BK63900( ALL)08/95]
q
Replace PCV valve. (7)
*
[BK64000( ALL)06/94]
q
Check thermactor hoses and clamps.
(Recommended, not required.)
*
[BK64125( ALL)04/95]
q
Replace spark plugs (Gasoline engines only).
*
[BK64200( ALL)08/95]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK64400( ALL)09/95]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK64500( ALL)06/95]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK64550( ALL)09/95]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK64600( ALL)08/95]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK64900( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK65100( ALL)08/95]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK65400( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK65500( ALL)08/95]
q
Inspect parking brake system for damage and
operation.
File:18ltbkm.ex
Update:Thu Dec 12 13:32:30 1996

Severe Duty Schedule 191
*
[BK73000( ALL)08/95]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK73100( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK73200( ALL)08/95]
q
Inspect parking brake system for damage and
operation.
*
[BK73710( FM)02/95]
q
Inspect parking brake fluid (F-Super Duty).
*
[BK73720( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK73750( ALL)04/93]
four pica chart:0060627-A
*
[BK73800( ALL)01/95]
93,000 MILES (155,000 Kilometers)
*
[BK73900( ALL)11/95]
q
Change engine oil and replace oil filter.
*
[BK74250( ALL)04/93]
four pica chart:0060627-A
*
[BK74300( ALL)01/95]
96,000 MILES (160,000 Kilometers)
*
[BK74400( ALL)11/95]
q
Change engine oil and replace oil filter.
*
[BK74500( ALL)08/95]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK74900( ALL)09/95]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK75000( ALL)06/95]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
File:18ltbkm.ex
Update:Thu Dec 12 13:32:30 1996

Severe Duty Schedule 197
*
[BK81400( ALL)09/95]
q
Lubricate throttle kickdown or TV lever ball
studs.
*
[BK81600( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK81800( ALL)08/95]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK81900( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK82000( ALL)08/95]
q
Inspect parking brake system for damage and
operation.
*
[BK82502( FM)02/95]
q
Inspect parking brake fluid (F-Super Duty).
*
[BK82504( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK82506( ALL)08/95]
four pica chart:0060627-A
*
[BK82510( ALL)06/95]
(1) Extremely dusty conditions will require more frequent
replacement of your air filter. Check your air filter at
3,000 miles (5,000 km). If it is dirty replace it and then
keep replacing it at the same interval (every 3,000 miles
[5,000 km]). If it's not dirty, check it again at 6,000
miles (10,000 km) and again at 9,000 miles (15,000 km)
until you determine your unique maintenance interval.
Do not go beyond 30,000 miles (50,000 km) as described
in the chart. If in doubt, see your dealer.
*
[BK82520( ALL)05/93]
(2) If you operate your vehicle ªoff roadº in water that is
deeper than the hubs (1/2 wheel height) then these
items must be serviced daily.
*
[BK82530( ALL)05/93]
(3) City delivery vehicles and other unique applications that
require constant turning may need more frequent tire
rotation. You may need to develop your own tire
rotation interval based on your own observations of tire
wear. If in doubt, see your dealer.
File:18ltbkm.ex
Update:Thu Dec 12 13:32:30 1996

198 Severe Duty Schedule
*
[BK82541( FM)12/96]
(4) Synthetic oil MUST BE changed at 100,000 miles
(165,000 km) intervals.
*
[BK82550( ALL)08/95]
(5) Wheel lug nuts must be retightened to proper torque
specifications at 500 miles/800 km of new vehicle
operation (100 miles/160 km and 500 miles/800 km for
vehicles equipped with dual rear wheels or equipped
for snowplowing). Proper torque specifications are
provided in your Owner Guide. Also retighten to
proper torque specification at 500 miles/800 km after
(1) any wheel change or (2) any other time the wheel
lug nuts have been loosened.
*
[BK82560( ALL)09/95]
(6) On dual rear wheel light trucks, rotate the front tires
side-to-side without disturbing the rear tires.
*
[BK82575( ALL)08/95]
(7) At 60,000 miles (96,000 km) your dealer will replace the
PCV valve at no cost except on Canada and California
vehicles.
File:18ltbkm.ex
Update:Thu Dec 12 13:32:30 1996

Owner Maintenance Checks 199
Owner Maintenance
Checks
*
[BK82700( ALL)09/95]
The following lists are vehicle checks and
inspections that should be performed by the
owner or qualified service technician at the
frequencies indicated to help ensure safe,
dependable operation of your vehicle.
*
[BK82800( ALL)01/95]
Any adverse conditions should be brought to the
attention of your dealer or qualified service
technician for service advice as soon as possible.
*
[BK82900( ALL)01/95]
These Owner Maintenance Checks are generally
not covered by warranties and you may be
charged for labor, parts and lubricants used.
*
[BK83000( ALL)01/95]
When You Stop for Fuel:
*
[BK83100( ALL)01/95]
q
Check the engine oil level.
*
[BK83200( ALL)01/95]
q
Check the windshield washer fluid level.
*
[BK83300( ALL)01/95]
q
Look for low or under-inflated tires.
*
[BK83400( ALL)01/95]
While Operating Your Vehicle:
*
[BK83500( ALL)01/95]
q
Note any changes in the sound of the exhaust
or any smell of exhaust fumes in the vehicle.
*
[BK83600( ALL)04/93]
q
Check for vibrations in the steering wheel.
Notice any increased steering effort or
looseness in the steering wheel, or change in
its straight ahead position.
*
[BK83700( ALL)04/93]
q
Notice if your vehicleconstantly turns
slightlyor ªpullsº to one side when traveling
on smooth, level road.
*
[BK83800( ALL)01/95]
q
When stopping, listen and check for strange
sounds,pulling to one side, increased brake
pedal travel or ªhard to pushº brake pedal.
File:18ltbkm.ex
Update:Thu Dec 12 13:32:30 1996