1997 FORD F SERIES MOTORHOME AND COMMERCIAL CHASSIS steering wheel

74 %
*
[GF24080( ALL)01/96]
Driving in Bad Weather
%*
[GF24090( ALL)01/96]
Slippery roads
*
[GF24100( ALL)01/96]
Drive cautiously on wet or snowy roads:
*
[GF24110( ALL)01/96]
q
Do not quickly move the steering wheel
unless necessary.
*
[GF24120( ALL)01/96]
q
Drive slower than you normally would.
*
[GF24130( ALL)01/96]
q
Give your vehicle more distance to stop.
[GF24140( M)01/96]
q
Pump the brake pedal steadily and evenly to
avoid locking your front wheels
[GF24160( M)01/96]
q
To stop on ice, shift to N (Neutral) below 10
mph (16 km/h) and gently pump brakes.
*
[GF24170( ALL)01/96]
q
Consider using one of the lower gears.
*
[GF24200( E M)01/96]
RWARNING
To avoid skidding and losing control on
slippery roads, do not downshift into 1
(First) when you are moving faster than
20 mph (30 km/h).
%*
[GF24270( ALL)01/96]
High water
*
[GF24280( ALL)01/96]
Never attempt to cross water that is fast flowing
or of unknown depth.
*
[GF24290( ALL)01/96]
Do not drive through flooded areas unless you
are sure that the water is below the bottom of
the wheel hubs.
*
[GF24300( ALL)01/96]
If you must drive through high water, drive
slowly. You may have limited traction or wet
brakes, so allow extra stopping distance because
your vehicle will not stop as quickly as usual.
*
[GF24310( ALL)01/96]
After you drive through the standing water,
apply your brakes gently several times as your
vehicle moves slowly. This helps to dry the
brakes.
File:09ltgfm.ex
Update:Fri Dec 13 11:22:54 1996

87 %
*
[ER03000( ALL)01/96]
Circuit Breakers
[ER03100( M)01/96]
If you need to check a circuit breaker that is on
the fuse panel, locate the circuit breaker
according to the instructions on the charts given
earlier in this chapter.
*
[ER03150( ALL)01/96]
Since you need diagnostic equipment to check
whether a circuit breaker works and such
equipment comes with instructions, we do not
discuss how to check circuit breakers.
*
[ER03200( ALL)01/96]
However, you should know that the circuit
breakers will reset themselves and allow the
electrical parts to work again once the overload
on the circuit is removed. If the circuit breakers
continue to cut off electricity, have your vehicle's
electrical system checked.
*
[ER03250( ALL)01/96]
If you replace a circuit breaker, use one with the
same amperage rating. To remove a circuit
breaker mounted in the fuse panel, grip it with
your finger and thumb and pull it straight out
of its socket.
%
*
[ER03500( ALL)01/96]
Changing a Tire
*
[ER03600( ALL)01/96]
If you get a flat tire while you are driving, do
not apply the brake heavily. Instead, gradually
decrease the speed. Hold the steering wheel
firmly and slowly move to a safe place on the
side of the road. Park on a level spot, turn off
the ignition, set the parking brake, and turn on
the hazard flashers.
%*
[ER03700( ALL)01/96]
The Conventional Spare Tire
[ER03900( M)01/96]
With the conventional spare tire, you can use it
as a spare or as a regular tire. This spare tire is
identical to the other tires that come with your
vehicle.
File:10lterm.ex
Update:Fri Dec 13 11:23:45 1996

113
%*
[MC18300( ALL)01/96]
Power Steering Fluid
*
[MC18350( ALL)01/96]
Check the level of the power steering fluid at
least twice a year (i.e., every Spring and Fall).
*
[MC18400( ALL)01/96]
To check the level of your power steering fluid:
*
[MC18450( ALL)01/96]
1. Start the engine and let it run until the
power steering fluid reaches normal
operating temperature. The power steering
fluid will be at the right temperature when
the engine coolant temperature gauge in the
instrument cluster is near the center of the
NORMAL operating temperature range.
*
[MC18500( ALL)01/96]
2. While the engine idles, turn the steering
wheel back and forth several times. Make
sure that the cap assembly is installed at this
time.
[MC18600( M)01/96]
3. Then turn the engine off and do not press
the brake pedal.
%*
[MC18650( ALL)01/96]
4. Check the fluid level on the dipstick (which
is highlighted in yellow in your vehicle). The
fluid level should be between the arrows in
the FULL HOT range, which is marked on
the side of the dipstick, opposite the side
marked FULL COLD. Do not add fluid if the
level is within the FULL HOT range.
File:11ltmcm.ex
Update:Fri Dec 13 11:24:54 1996

115
*
[MC19350( ALL)01/96]
If you check the power steering fluid when it is
cold, make sure that the fluid reaches the FULL
COLD range on the dipstick. The reading will
only be accurate if the fluid temperature is
approximately 50 to85ÊF (10 to 30ÊC).
*
[MC19400( ALL)01/96]
NOTE: Do not turn the steering wheel of your
vehicle with the engine off. It could
force power steering fluid out from the
reservoir cap or in extreme cases, it
could unseat the cap.
[MC19500( M)01/96]Suspension and Steering
[MC19600( M)01/96]
Modifications
[MC19700( M)01/96]
The suspension and steering systems on your
vehicle have been designed and tested to
provide both safe, predictable performance
whether loaded or empty as well as durable
load carrying capability. Any modifications to
the suspension or steering systems can reduce
your vehicle's performance capability and
adversely affect driver and passenger safety.
Ford recommends that you do not make
modifications such as adding or removing parts
(like lift kits or stabilizer bars) or by using
replacement parts not equivalent to the original
factory equipment.
[MC19800( M)01/96]
RWARNING
The low pressure gas shock absorbers are
charged with nitrogen gas to 90 psi (620
kPa). Do not attempt to heat, puncture or
open.
File:11ltmcm.ex
Update:Fri Dec 13 11:24:54 1996

116 [MC19900( M)01/96]Inspecting for Road Damage
[MC20000( M)01/96]
The suspension and steering linkage in your
vehicle should be inspected periodically for
abnormal looseness and damaged seals. Also be
alert for changes in steering action. Hard
steering, excessive free play or unusual sounds
when turning or parking indicate a need for
inspection or servicing.
[MC20100( M)01/96]
NOTE: After any severe impact such as
striking large potholes, inadvertent
sliding into curbs on icy roads, or a
collision involving the front end,
observe the steering wheel alignment.
If the steering wheel spokes seem to
be in a different position while going
down the road, have the front
suspension and steering checked for
possible damage.
%
*
[MC21300( ALL)01/96]
Automatic Transmission Fluid
[MC21400( M)01/96]
Under normal driving conditions automatic
transmission fluid should not need changing.
Under severe duty conditions automatic
transmission fluid should be changed every
21,000 miles (34,000 km). However, if the
transmission is not working properly, for
instance, the transmission may slip or shift
slowly, or you may notice some sign of fluid
leakage, the fluid level should be checked.
[MC21500( ALL)01/96]
Transmission fluid, filter and seal assembly
should be changed every 21,000 miles
(34,000 km) only under any of the following
conditions.
[MC21550( ALL)01/96]
q
Extended periods of high speed driving
during hot weather at/or above+90ÊF
(+30ÊC).
[MC21600( ALL)01/96]
q
Towing a trailer for distances over 1,000 miles
(1,600 km) per trip.
File:11ltmcm.ex
Update:Fri Dec 13 11:24:54 1996

127 [MC27600( M)01/96]
RWARNING
Use only wheel assemblies approved and
released by Ford Motor Company for your
vehicle model.
[MC27650( M)01/96]
A wheel or tire of the wrong size or type may
adversely affect such things as load carrying
capacity, wheel and bearing life, brake cooling,
speedometer/odometer calibration, stopping
ability, headlight aim, bumper height, vehicle
ground clearance, and tire or tire chain clearance
to the body and chassis. Replacement with used
wheels is not advised: they may have been
treated harshly or have high mileage, and they
could fail without warning.
[MC27700( M)01/96]
The use of wheels with load carrying limits
higher than the limits of the wheels originally
installed on your vehicle does not in itself
increase the GAWR or GVWR of the vehicle.
[MC27750( M)01/96]
RWARNING
Use only wheel assemblies approved and
released by Ford Motor Company for your
vehicle model.
[MC27800( M)01/96]
RWARNING
Alterations to the vehicle suspension or
steering by raising the chassis (i.e., use of
aftermarket ªlift kitsº) may adversely
affect vehicle handling and braking
performance.
File:11ltmcm.ex
Update:Fri Dec 13 11:24:54 1996

178 Severe Duty Schedule
*
[BK56300( ALL)06/95]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK56350( ALL)09/95]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK56400( ALL)08/95]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK56700( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK56900( ALL)08/95]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK57000( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK57100( ALL)08/95]
q
Inspect parking brake system for damage and
operation.
[BK57225( M)08/95]
q
Inspect parking brake fluid (F-Super Duty
only).
*
[BK57520( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK57550( ALL)04/93]
four pica chart:0060627-A
File:18ltbkm.ex
Update:Thu Dec 12 13:32:30 1996

184 Severe Duty Schedule
*
[BK63900( ALL)08/95]
q
Replace PCV valve. (7)
*
[BK64000( ALL)06/94]
q
Check thermactor hoses and clamps.
(Recommended, not required.)
*
[BK64125( ALL)04/95]
q
Replace spark plugs (Gasoline engines only).
*
[BK64200( ALL)08/95]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK64400( ALL)09/95]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK64500( ALL)06/95]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK64550( ALL)09/95]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK64600( ALL)08/95]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK64900( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK65100( ALL)08/95]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK65400( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK65500( ALL)08/95]
q
Inspect parking brake system for damage and
operation.
File:18ltbkm.ex
Update:Thu Dec 12 13:32:30 1996