1997 FORD CONTOUR engine

214
%*
[MC27300(ALL)01/96
]
Running Out of Fuel
*
[MC27400(ALL)08/95]
NOTE: Avoid running out of fuel because this situation may
have an adverse effect on modern powertrain
components.
*
[MC27500(ALL)01/96]
You may need to crank the engine several times before the fuel
system starts to pump fuel from the tank to the engine.
*
[MC27600(ALL)01/96]
RWARNING
Never pour fuel in the throttle body or attempt to start
the engine with the air cleaner removed. Doing so could
result in fire and personal injury.
%*
[MC27700(ALL)03/96]
Fuel Economy
*
[MC27800(ALL)01/96]
Fuel economy is an estimate of the efficiency of your vehicle
and can be calculated as Miles Per Gallon (MPG) or Liters Per
100 Kilometers (L/100K).
*
[MC27900(ALL)01/96]
Do not calculate fuel economy during your vehicle's break-in
period. This would not be an accurate estimate of how much
fuel your vehicle will normally use.
File:11cdmco.ex
Update:Thu Sep 12 11:08:18 1996

Maintenance and Care
215
*
[MC28000(ALL)01/96]
To calculate fuel economy:
*
[MC28100(ALL)01/96]1.
Fill the tank completely and record the initial odometer
reading.
*
[MC28200(ALL)01/96]2.
Every time you buy fuel record the amount (in gallons or
liters) purchased.
*
[MC28300(ALL)01/96]3.
After at least three to five tankfuls, fill the fuel tank and
record the final odometer reading.
*
[MC28400(ALL)01/96]4.
Use these equations to calculate your fuel economy:
*
[MC28500(ALL)01/96]
n
English: MPGU(total miles driven)V(gallons used)
*
[MC28600(ALL)01/96]
n
Metric: L/100kU(liters used)V(100 kilometers)
%*
[MC28700(ALL)01/96
]
Comparisons With Environmental Protection Agency
(EPA) and Transport Canada (TC) Fuel Economy
Estimates
*
[MC28800(ALL)05/96]
EPA fuel economy figures are obtained from laboratory tests
under simulated road conditions and may not reflect the actual
conditions you experience or your style of driving. The EPA
fuel economy estimate is not a guarantee that you will achieve
the fuel economy shown.
*
[MC28900(ALL)01/96]
The following decrease fuel economy:
*
[MC29000(ALL)01/96]
n
Lack of regular, scheduled maintenance
*
[MC29100(ALL)01/96]
n
Rapid acceleration and excessive speed
*
[MC29200(ALL)01/96]
n
Driving with your foot on the brake
*
[MC29300(ALL)01/96]
n
Sudden stops
*
[MC29400(ALL)01/96]
n
Extended engine idling
*
[MC29500(ALL)01/96]
n
Using speed control in hilly terrain
*
[MC29600(ALL)01/96]
n
Extended use of the A/C, defroster, rear window defroster
and other accessories
File:11cdmco.ex
Update:Thu Sep 12 11:08:18 1996

216
*
[MC29700(ALL)01/96]
n
Underinflated tires
*
[MC29800(ALL)01/96]
n
Heavy loads
*
[MC29900(ALL)01/96]
n
Aftermarket add-ons such as bike, ski or luggage racks, bug
deflectors, etc.
*
[MC30000(ALL)12/95]
Self-Service Pointers
*
[MC30100(ALL)12/95]
If you choose to do your own fueling, you should also perform
a few simple maintenance routines. This extra effort will save
you additional money and contribute to the driving efficiency of
your vehicle.
*
[MC30200(ALL)12/95]
The following procedures require only a tire gauge, a rag, an oil
can spout and windshield washer fluid.
*
[MC30300(ALL)12/95]
n
Check the engine oil at every refueling stop
*
[MC30400(ALL)12/95]
n
Clean the windshield, outside mirrors and headlights
*
[MC30500(ALL)12/95]
n
Check windshield washer fluid
*
[MC30600(ALL)12/95]
n
Check tires for excessive wear or worn edges
*
[MC30700(ALL)12/95]
n
Check the tire pressure at least monthly
%*
[MC30800(ALL)01/96]
Emission Control System
*
[MC30900(ALL)01/96]
Your vehicle is equipped with a catalytic converter which
enables your vehicle to comply with applicable exhaust emission
requirements.
*
[MC31000(ALL)05/96]
RWARNING
Exhaust leaks may result in the entry of harmful and
potentially lethal fumes into the passenger compartment.
Under extreme conditions excessive exhaust temperatures
could damage the fuel system, the interior floor covering,
or other vehicle components, possibly causing a fire.
File:11cdmco.ex
Update:Thu Sep 12 11:08:18 1996

218
*
[MC31700(ALL)01/96]
RWARNING
Do not park, idle, or drive your vehicle in dry grass or
other dry ground cover. The emission system heats up
the engine compartment and exhaust system, which can
start a fire.
*
[MC31800(ALL)01/96]
Watch for fluid leaks, strange odors, smoke, loss of oil pressure,
the charge warning light, the check engine light, or the
temperature warning light. These sometimes indicate that the
emission system is not working properly.
*
[MC31900(ALL)01/96]
Do not make any unauthorized changes to your vehicle or
engine. Changes that cause more unburned fuel to reach the
exhaust system can increase the temperature of the engine or
exhaust system.
*
[MC32000(ALL)01/96]
By law, anyone who manufactures, repairs, services, sells, leases,
trades vehicles, or supervises a fleet of vehicles is not permitted
to intentionally remove an emission control device or prevent it
from working. In some of the United States and in Canada,
vehicle owners may be liable if their emission control device is
removed or is prevented from working.
*
[MC32100(ALL)01/96]
Do not drive your vehicle if it does not operate properly. See
your dealer if the engine runs on for more than five seconds
after you shut it off or if it misfires, surges, stalls, or backfires.
%*
[MC32200(ALL)01/96
]
Information about your vehicle's emission control system is on
the Vehicle Emission Control Information decal located on or
near the engine. This decal identifies engine displacement and
gives some tune-up specifications.
File:11cdmco.ex
Update:Thu Sep 12 11:08:18 1996

Maintenance and Care
219
%*
[MC32300(ALL)03/96
]
How to Prepare Your Vehicle for
Inspection/Maintenance (I/M) Testing
*
[MC32400(ALL)05/96]
In some localities it may become a legal requirement to pass an
Inspection/Maintenance (I/M) test of the On-Board Diagnostic
(OBD) II system. If the vehicle's powertrain system or its battery
has just been serviced, the OBD II system is reset to a not ready
for I/M testing condition. To prepare for I/M testing, the law
specifies that additional mixed city and highway driving is
required to complete the check of the OBD II system.
*
[MC32500(ALL)05/96]
OBD II Drive Cycle
*
[MC32601(ALL)05/96]
The driving modes required to reach the ready condition consist
of a minimum of 30 minutes of city and highway driving as
described below:
*
[MC32701(ALL)05/96]
n
At least twenty minutes driving in stop and go, city type
traffic with at least four idle periods.
*
[MC32801(ALL)05/96]
n
At least ten minutes of driving on an expressway or
highway.
*
[MC32901(ALL)05/96]
Before completing the above driving modes, the engine must be
warmed up and at operating temperature. Once started, the
vehicle must not be turned off during these driving modes.
%*
[MC34300(ALL)03/96]
Lights and Bulb Replacement
*
[MC34400(ALL)01/96]
It is a good idea to check the operation of the following lights
frequently:
*
[MC34500(ALL)01/96]
n
headlamps
*
[MC34600(ALL)01/96]
n
tail lamps
*
[MC34700(ALL)01/96]
n
brakelamps
*
[MC34800(ALL)01/96]
n
high-mount brakelamp
*
[MC34900(ALL)01/96]
n
hazard flasher
File:11cdmco.ex
Update:Thu Sep 12 11:08:18 1996

Maintenance and Care
227
*
[MC40500(ALL)01/96]
Cleaning the Engine
*
[MC40600(ALL)01/96]
A clean engine is more efficient because a buildup of grease and
dirt acts as an insulator, keeping the engine warmer than usual.
*
[MC40700(ALL)01/96]
n
Extreme care must be used if a power washer is used to
clean the engine. The high pressure fluid could penetrate
sealed parts and assemblies causing damage or malfunctions.
*
[MC40800(ALL)04/96]
n
In order to avoid possible cracking of the engine block or
fuel injection pump, do not spray a hot engine or injection
pump with cold water.
*
[MC40900(ALL)04/96]
n
The alternator, distributor and air intake must be covered.
Covering these components will help prevent water damage.
*
[MC41000(ALL)01/96]
n
Never wash or rinse the engine while it is running. Water
getting into the engine may cause internal damage.
%*
[MC41100(ALL)03/96
]
Cleaning the Wheels
*
[MC41200(ALL)03/96]
Wash the wheels with the same detergent you use to wash your
vehicle's body. Do not use acid-based wheel cleaners, steel wool,
abrasives, fuel, or strong detergents. These substances will
damage protective coatings. Use tar and road oil remover to
remove grease and tar.
*
[MC41300(ALL)03/96]
NOTE: Before going to a car wash, find out if the brushes are
abrasive.
File:11cdmco.ex
Update:Thu Sep 12 11:08:18 1996

Capacities and Specifications
233
%*
[CS02400(ALL)01/96]
Engine
*
[CS02500(ALL)01/96]
n
Start engine every 15 days. Run at fast idle until it reaches
normal operating temperature.
*
[CS02600(ALL)01/96]
n
With your foot on the brake, shift through all the gears
while the engine is running.
%*
[CS02700(ALL)01/96]
Fuel system
%*
[CS02800(ALL)01/96]
n
Fill fuel tank with high-quality unleaded fuel until the first
automatic shutoff of the fuel pump nozzle.
*
[CS02900(ALL)01/96]
NOTE: During extended periods of vehicle storage (60 days or
more), fuel may deteriorate due to oxidation. This can
damage rubber and other polymers in the fuel system
and may also clog small orifices.
*
[CS03000(ALL)01/96]
Ford Gas Stabilizer should be added whenever actual or
expected storage periods exceed 60 days. Follow the instructions
on the label. The vehicle should then be operated at idle speed
to circulate the additive throughout the fuel system.
*
[CS03100(ALL)01/96]
A volatile corrosion inhibitor added to the fuel system will
protect the fuel system's inner surfaces from corrosion. Follow
the instructions packaged with the product.
%*
[CS03200(ALL)01/96]
Cooling system
*
[CS03300(ALL)01/96]
n
Protect against freezing temperatures.
File:12cdcso.ex
Update:Thu Sep 12 11:08:45 1996

246
*
[HS08800(ALL)06/95]
Officials at the embassy or consulate can tell you where to get
unleaded fuel. If you cannot get unleaded fuel or can get only
fuel with an anti-knock index that is lower than your vehicle
needs, contact a district or owner relations office before you
leave the U.S. or Canada.
*
[HS08900(ALL)06/95]
Use of leaded fuel in your vehicle without a proper conversion
may damage the effectiveness of your emissions control system
and may cause engine knocking or serious engine damage. Ford
Motor Company is not responsible for any damage that is
caused by use of improper fuel.
*
[HS09000(ALL)06/95]
You may also have difficulty importing your vehicle back into
the U.S. if you use leaded fuel.
*
[HS09100(ALL)06/95]
If your vehicle must be serviced while you are traveling or
living in Central or South America, the Caribbean, or the
Middle East, contact the nearest Ford dealership. If the
dealership cannot help you, write to:
*
[HS09200(ALL)10/95]
7-1/2 pica art:0040273-C
*
[HS09300(ALL)06/95]
If you are in other foreign countries, contact the nearest Ford
dealership. If the dealership cannot help you, they can direct
you to the appropriate Ford affiliate office.
*
[HS09400(ALL)06/95]
If you buy your vehicle in North America and then relocate
outside of the U.S. or Canada, register your Vehicle
Identification Number and new address with Ford Motor
Company Export Operations.
File:14cdhso.ex
Update:Fri May 24 08:39:27 1996