1997 FORD AEROSTAR brake light

272authorized service center can perform a detailed
OBD II drive cycle as it would any other type of
repair work.
%
*
[MC44600(ALL)03/96]
Lights and Bulb Replacement
*
[MC44700(ALL)01/96]
It is a good idea to check the operation of the
following lights frequently:
*
[MC44800(ALL)01/96]
q
headlamps
*
[MC44850(ALL)01/96]
q
high-mount brakelamp
*
[MC44900(ALL)01/96]
q
tail lamps
*
[MC45000(ALL)01/96]
q
brakelamps
*
[MC45100(ALL)01/96]
q
hazard flasher
*
[MC45200(ALL)01/96]
q
turn signals
*
[MC45300(ALL)05/96]
q
license plate lamps
%*
[MC45400(ALL)01/96]
The alignment of your headlamps should be
checked if:
*
[MC45500(ALL)01/96]
q
oncoming motorists frequently signal you to
turn off your vehicle's high beams when you
do not have the high beams on
*
[MC45600(ALL)01/96]
q
the headlamps do not seem to give you
enough light to see clearly at night
*
[MC45700(ALL)01/96]
q
the headlamp beams are pointed substantially
away from a position slightly down and to
the right
%*
[MC45800(ALL)01/96]
Headlamp Bulb
*
[MC45900(ALL)03/96]
The headlamps on your vehicle use replaceable
bulbs. When the lamp burns out, simply replace
the bulb, rather than the whole lamp.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

284
*
[MC56600(ALL)01/96]
Body
*
[MC56700(ALL)01/96]
q
Wash vehicle thoroughly to remove dirt,
grease, oil, tar or mud from exterior surfaces,
rear wheel housing and underside of front
fenders.
*
[MC56800(ALL)01/96]
q
Periodically wash vehicles stored in exposed
locations.
*
[MC56900(ALL)01/96]
q
Touch-up raw or primed metal to prevent
rust.
*
[MC57000(ALL)01/96]
q
Cover chrome and stainless steel parts with a
thick coat of auto wax to prevent
discoloration. Re-wax as necessary when the
vehicle is washed.
*
[MC57100(ALL)01/96]
q
Lubricate all hood, door and trunk lid hinges
and latches with a light grade oil.
*
[MC57200(ALL)01/96]
q
Cover interior soft trim to prevent fading.
*
[MC57300(ALL)01/96]
q
Keep all rubber parts free from oil and
solvents.
%*
[MC57350(ALL)01/96]
Engine
*
[MC57400(ALL)01/96]
q
Start engine every 15 days. Run at fast idle
until it reaches normal operating temperature.
*
[MC57500(ALL)01/96]
q
With your foot on the brake, shift through all
the gears while the engine is running.
%*
[MC57600(ALL)01/96]
Fuel system
%*
[MC57700(ALL)01/96]
q
Fill fuel tank with high-quality unleaded fuel
until the first automatic shutoff of the fuel
pump nozzle.
*
[MC57900(ALL)01/96]
NOTE: During extended periods of vehicle
storage (60 days or more), fuel may
deteriorate due to oxidation. This can
damage rubber and other polymers in
the fuel system and may also clog
small orifices.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

285
*
[MC58000(ALL)01/96]
Ford Gas Stabilizer should be added whenever
actual or expected storage periods exceed 60
days. Follow the instructions on the label. The
vehicle should then be operated at idle speed to
circulate the additive throughout the fuel system.
*
[MC58100(ALL)01/96]
A volatile corrosion inhibitor added to the fuel
system will protect the fuel system's inner
surfaces from corrosion. Follow the instructions
packaged with the product.
%*
[MC58200(ALL)01/96]
Cooling system
*
[MC58300(ALL)01/96]
q
Protect against freezing temperatures.
%*
[MC58400(ALL)01/96]
Battery
*
[MC58500(ALL)01/96]
q
Check and recharge as necessary.
*
[MC58600(ALL)01/96]
q
Keep connections clean and covered with a
light coat of grease.
%*
[MC58700(ALL)01/96]
Brakes
*
[MC58800(ALL)01/96]
q
Make sure brakes and parking brake are fully
released.
%*
[MC58900(ALL)01/96]
Tires
*
[MC59000(ALL)01/96]
q
Maintain recommended air pressure.
*
[MC59100(ALL)01/96]
Miscellaneous
*
[MC59200(ALL)01/96]
q
Make sure all linkages, cables, levers and
clevis pins under vehicle are covered with
grease to prevent rust.
*
[MC59300(ALL)01/96]
q
Move vehicles at least 25 feet (8 m) every 15
days to lubricate working parts and prevent
corrosion.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

336 Index
Autolamp system (see Headlamps)..... 72
Automatic transmission
fluid, adding............. 248
fluid, checking............ 247
fluid, refill capacities......... 294
fluid, specification........... 296
Axle
lubricant specifications......... 296
refill capacities............ 294
traction lok............177, 254
B
Basic vehicle warranty........... 3
Battery
acid, treating emergencies.....223, 250
charging system warning light...... 13
disconnecting............. 226
how to service............ 249
jumping a disabled battery....... 222
maintenance-free........... 249
proper disposal, recycling....... 250
replacement, specifications....... 293
servicing............... 249
voltage gauge............ 13,15
when storing your vehicle....... 285
Brake fluid
brake warning light........... 9
checking and adding......... 236
description.............. 236
specifications...........237, 296
Brakelamp, high-mount brakelamp..... 72
Brakes
adjustment.............. 163
anti-lock............... 163
applying the brakes.......... 166
brake warning light........... 9
fluid, checking and adding....... 236
fluid, refill capacities.......236, 294
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996

Index 341
Emergency brake (parking brake)..... 165
Emission control system
catalytic converter.......... 269
emissions warranty......... 3,269
Engine
check engine warning light....... 12
does not start............ 158
fuel injected engine, starting...... 153
fuel pump shut-off switch....... 158
preparing to start........... 153
refill capacities............ 294
service points............ 297
starting............... 154
starting after a collision........ 158
storing your vehicle.......... 283
Engine block heater........... 157
Engine coolant
checking and adding......... 240
checking hoses............ 243
disposal.............230, 248
drain and flush............ 243
preparing for storage......... 285
proper solution..........230, 248
recovery reservoir........240, 297
refill capacities............ 294
specifications............. 296
temperature gauge........... 17
Engine coolant temperature gauge
description............... 17
mechanical............... 17
Engine coolant temperature
gauge:electronic............. 17
Engine fan............... 230
Engine:idle speed control........ 156
Engine knocking............ 264
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996

Index 345
H
Hazard flashers............ 78,199
Headlamps
aiming................ 272
checking alignment.......... 272
cleaning............... 281
daytime running lights......... 72
replacing bulbs............ 272
turning on and off........... 71
warning chime............. 14
Heating
heating and air conditioning system . . . 62
rear seat controls............ 67
standard heater system......... 65
High beams
indicator light............. 14
operation............... 71
High-mount brakelamp, description..... 72
High-mount brakelamp:location...... 72
Hitch................. 194
Hood
latch location............. 231
lubrication specifications........ 296
release lever............. 231
working under the hood....... 230
Hoses, checking............. 243
I
Identification Number, Vehicle (VIN) . . . 300
Idle
relearning..........226, 230, 250
speed................ 156
Ignition
chime................. 14
positions of the ignition......... 74
Indicator lights and chimes (see Lights) . . . 7
Infant seats (see Safety seats).....128, 130
Instrument cluster............. 9
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996

346 Index
Instrument panel............. 59
cleaning............... 282
registers................ 61
Integrated child seat
(see Built-in child seat)........ 141
Interval wipers.............. 76
J
Jack
operation.............216, 219
positioning............216, 219
storage................ 211
Jump-starting your vehicle
attaching cables............ 224
disconnecting cables.......... 226
K
Keys
key in ignition chime.......... 14
positions of the ignition......... 74
stuck in lock position.......... 74
L
Lamps
checking............... 272
daytime running light system...... 72
hazard flashers.......... 78,199
headlamps............... 71
high-mount brakelamp......... 72
illuminated entry system......... 73
interior lamps.............. 71
replacing bulbs............ 272
trailer................ 195
Lane change indicator (see Turn signal) . . . 75
Lap belts................ 116
Lights, warning and indicator
airbag................. 13
brake................. 9
charging system............. 13
check engine.............. 12
door ajar................ 11
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996

Index 347
Lights, warning and indicator (continued)
engine oil pressure........... 16
hazard warning light........ 78,199
high beam............... 14
oil pressure.............. 16
safety belt............... 11
service engine soon........... 12
turn signal indicator.......... 75
Load limits
GAWR................ 179
GVWR................ 179
trailer towing............. 181
Lubricant specifications......... 296
Lug nuts
standard............... 219
tightening sequence........216, 221
Lumbar support, seats.......... 106
Lumbar support pad.......... 106
M
Maintenance schedule and record
(see separate Maintenance Schedule
and Record booklet).......... 3
Maintenance (see Servicing)....... 229
Manual transmission
fluid capacities............ 294
lubricant specifications........ 296
Master cylinder, brakes......... 236
Methanol in fuel............ 265
Mileage, calculating fuel economy.... 268
Mirrors
dual electric remote control....... 91
rearview................ 91
side view mirrors............ 91
side view mirrors (power)........ 91
Motorcraft parts............. 293
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996