1997 CHEVROLET TRACKER maintenance

I
Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each spring and fall). You should let your
GM dealer’s
service department or other qualified service center do
these
jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a
GM service manual. See “Service and Owner
Publications” in the Index.
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose
or missing parts, signs of
wear
or lack of lubrication. Inspect the power steering
lines and hoses
for proper hook-up, binding, leaks,
cracks, chafing,
etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look
for broken, damaged,
missing or out-of-position parts as well
as open seams,
holes, loose connections or other conditions which could
cause a heat build-up in the floor pan or could let
exhaust fumes into the vehicle. See “Engine Exhaust” in
the Index.
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen
or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed.
7-53
ProCarManuals.com

Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding,
and for damage or missing parts. Replace parts as
needed. Replace any cables that have high effort or
excessive wear.
Do not lubricate accelerator and cruise
control cables.
Rear Axle (All) and Front Axle
(Four-wheel Drive) Service
Check the gear lubricant level and add if needed. See
“Rear Axle” and “Four-wheel Drive” in
the Index. A
fluid loss may indicate a problem. Check the system(s),
and repair the system(s) if needed. Refer to “Scheduled
Maintenance Services,” earlier
in this section, to
determine when to change the lubricant.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition. Also inspect drum brake linings
for wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc.
Check parking brake adjustment. You may need to have
your brakes inspected more often if your driving habits
or conditions result in frequent braking.
Clutch System Service
Check clutch pedal free travel and adjust as necessary.
See “Clutch Adjustment’’ in the Index.
7-54
ProCarManuals.com

Part E: Maintenance Record
After the scheduled services are performed, record the
date, odometer reading and who performed the service
in
the boxes provided after the maintenance interval. Any
additional information
from “Owner Checks and
Services” or “Periodic Maintenance” can be added on
the following record pages.
Also, you should retain all
maintenance receipts. Your owner information portfolio
is a convenient place to store them.
I
Maintenance Record
ODOMETER
DATE MAINTENANCE PERFORMED
SERVICED
BY READJNG
7-57
ProCarManuals.com

Maintenance Record
7-58
ProCarManuals.com

1997 CHEVROLET/GEO SERVICE PUBLICATIONS ORDERING INFORMATION
The following publications covering the operation and servicing of your vehicle can be purchased by filling out
the Service Publication
Order Form in this book and mailing it in with your check, money o\
rder,
or credit card information to Helm, Incorporated (address below.)
~~ ~~
CURRENT PUBLICATIONS FOR 1997 CHEVROLETIGEO
SERVICE MANUALS
Service Manuals have the diagnosis and repair information
on engines, transmission, axle, suspension, brakes,
electrical, steering, body, etc.
RETAIL SELL PRICE:
$90.00
TRANSMISSION, TRANSAXLE, TRANSFER CASE UNIT REPAIR MANUAL
This manual provides information on unit repair service
procedures, adjustments and specifications for the
1997
GM transmissions, transaxles and transfer cases.
RETAIL SELL PRICE: $40.00
SERVICE BULLETINS
Service Bulletins give technical service information needed
to knowledgeably service General Motors cars and trucks.
Each bulletin contains instructions to assist in the
diagnosis and service of your vehicle.
PLEASE COMPLETE THE ORDER FORM SHOWN ON
THE FOLLOWING PAGE AND MAIL TO:
Helm, Incorporated P.O. Box 07130 Detroit, MI 48207
OWNER’S INFORMATION
Owner publications are written directly for Owners and
intended to provide basic operational information about the
vehicle. The owner’s manual will include the Maintenance
Schedule for all models.
In-Portfolio: Includes a Portfolio, Owner’s Manual and
Warranty Booklet. RETAIL SELL PRICE:
$15.00
Without Portfolio: Owner’s Manual only.
RETAIL SELL PRICE:
$1 0.00
CURRENT & PAST MODEL ORDER FORMS
Service Publications are available for current and past
model GM vehicles. To request an order form, please
specify year and model name of the vehicle.
OR ORDER TOLL FREE: 1-800-782-4356
Monday-Friday 8:OO AM - 6:OO PM Eastern Time
For Credit Card Orders Only
(VlSA-MasterCard-Discover)
ProCarManuals.com

Methanol ...................................... 6-4
Mirrors
....................................... 2-39
Convex Outside
.............................. 2-41
ManualAdjust
............................... 2-40
Power Remote Control
......................... 2-40
MMT
......................................... 6-4
ModelReference
................................. 111
Mountain Roads ................................ 4-38
Multifunction Lever
............................. 2-29
...
Neutral. Automatic Transmission ................. 2- 12
Neutral. Manual Transmission
..................... 2- 15
New Vehicle Break-In
............................ 2-7
Nightvision
................................... 4-31
Odometer
.................................... 2-61
Odometer. Trip
................................. 2-61
Off-Road Driving
.............................. 4- 15
Off-RoadRecovery
............................. 4-12
Oil. Engine
.................................... 6-10
Oil Pressure Light
......................... 2.69. 6. IO
Overdrive. Automatic Transmission ................ 2- 14
Overdrive Off Light ............................. 2-71
Overheating Engine
............................. 5 . 13
Owner Checks and Services
....................... 7-49
Owner Publications. Ordering
..................... 8- 11
Paint Spotting. Chemical
........................ 6-56
Park
Automatic Transmission
....................... 2- 10 Shifting Into
................................. 2-23
Shifting Out of
............................... 2-25
AtNight
..................................... 2-6
Brake
...................................... 2-21
Brake Mechanism Check
....................... 7-52
Over Things That Burn
........................ 2-26
With a Trailer
................................ 4-55
Your Vehicle. Manual Transmission
.............. 2-26
Parking Lamp Bulb Replacement
.................. 6-35
Passenger Position
......................... 1.25. 1-31
Parking
Passing
....................................... 4-12
Periodic Maintenance Inspections
.................. 7-53
DoorLocks
................................... 2-4
Remote Control Mirror
........................ 2-40
Steering
.................................... 4-10
Steering Fluid
................................ 6-26
Windows
................................... 2-28
Power Indicator Light
........................... 2-70
Power Mode Selector Switch
...................... 2-14
Pregnancy. Use of Safety Belts
.................... 1-24
Problems on the Road
............................ 5-1
Publications. Service and Owner ................... 8-11
Radiator. Coolant .............................. 5-20
Radiator Pressure Cap
........................... 6-26
Radio Reception
................................ 3-17
Radios ............................... 3-7.3-8. 3-11
Rain. Driving In
................................ 4-32
Preparing
Your Canvas Top for Storage ............. 2-56
9-7
ProCarManuals.com

Reminder Light ......................... 1 . 13. 2.62
Replacing After a Crash
........................ 1-46
Right Front Passenger Position
.................. 1-25
Smaller Children and Babies
.................... 1-34
Use During Pregnancy
......................... 1-24
WhyTheyWork
.............................. 1-14
Safety Chains
.................................. 4-53
Safety Defects. Reporting
........................ 8-10
Safety Warnings and Symbols
....................... iv
Scheduled Maintenance Services
.................... 7-4
Seatback
Folding Rear
.............................. 1-6. 1-9
Reclining Front
............................... 1-3
EasyEntry
................................... 1-4
ManualFront ................................. 1-2
Rear
.................................... 1-6. 1.9
Restraint Systems
.............................. 1 . 1
Seat Controls ................................. 1-2
Securing a Child Restraint
...................... 1-36
Second Gear. Automatic Transmission
.............. 2- 12
Second Gear. Manual Transmission
................. 2- 15
Service ........................................ 6-2
Bulletins. Ordering ............................ 8- 11
Engine Soon Light
............................ 2-67
Manuals. Ordering ............................ 8- 1 1
Parts Identification Label ....................... 6-58
Publications. Ordering
......................... 8- 11
Work. Doing Your
Own ......................... 6-2
Service and Appearance Care ...................... 6-1
Service and Owner Publications ................... 8- 1 1
Seats Service Publications
.............................. 8-1
1
Sheet Metal Damage
............................ 6-55
Shift Lever
............................... 2- 10. 2- 14
Shiftspeeds ................................... 2-16
Shifting Automatic Transmission
....................... 2-10
IntoPARK(P)
............................... 2-23
Manual Transmission
.......................... 2-14
Out of PARK (P)
............................. 2-25
Signaling Turns
................................ 2-30
Skidding
...................................... 4-14
Sound Equipment. Adding
........................ 3-18
Specifications and Capacities
...................... 6-62
Specifications. Engine
........................... 6-62
Speedometer
................................... 2-61
Stains. Cleaning
................................ 6-50
Starter Switch Check
............................ 7-51
Steam ........................................ 5-13
Steering
...................................... 4-10
In Emergencies
............................... 4-11
Power
...................................... 4-10
Tips
........................................ 4-10
StorageAreas
.................................. 2-41
Storage. Vehicle ................................ 6-33
Stuck: In Sand. Mud.
Ice or Snow .................. 5-34
Sunvisors
.................................... 2-44
Sunroof ....................................... 2-45
Symbols. Vehicle
................................. vi
Servicing
Your Air Bag-Equipped Geo
.............. 1-30
Side Window. Removing and Installing the
........... 2-48
Speech Impaired. Customer Assistance
............... 8-4
9-9
ProCarManuals.com

Tachometer .................................. 2-6 1
Tailgate Lock Release ............................ 2-6
Tailgate
........................................ 2-5
TapePlayerCare
............................... 3-18
Theft
.......................................... 2-6
Theft-Deterrent Feature. CD Player
................ 3- 15
Thermostat .................................... 6-26
Third Gear. Manual Transmission
.................. 2- 15
Tirechains
.................................... 6-48
TireLoading
................................... 4-47
Tire-Loading Information Label
................... 4-47
Tires
......................................... 6-40
Alignment and Balance
........................ 6-46
Chains
..................................... 6-48
ChangingaFlat
.............................. 5-23
Cleaning
.................................... 6-55
Inflation
.................................... 6-41
Inflation Check
............................... 7-49
Inspection and Rotation
........................ 6-42
Pressure
.................................... 6-41
Storing a Flat or Spare
......................... 5-32
Temperature
................................. 6-46
Traction
.................................... 6-45
Treadwear
................................... 6-45
Uniform Quality Grading
....................... 6-45
Wear Indicators
.............................. 6-43
When It’s Time for New
....................... 6-43
Buying
New
.................................. 6-44
Loading
.................................... 4-47
Wheel Replacement
........................... 6-46 Top
Strap
..................................... 1-37
Torque. Wheel Nut
......................... 5-32. 6-64
TorqueLock
................................... 2-24
Towing ATrailer
.................................... 4-49
Recreational Vehicle
.......................... 4-44
Towing Your Vehicle
............................. 5-8
Trailer Brakes
..................................... 4-53
Driving on Grades
............................ 4-55
Driving with
................................. 4-53
Hitches
..................................... 4-52
Maintenance When Towing
..................... 4-56
Parking on Hills
.............................. 4-55
Safety Chains
................................ 4-53
Total Weight on Tires
.......................... 4-52
Towing
..................................... 4-49
Turnsignals
................................. 4-55
Weight ..................................... 4-51
Tongueweight
............................... 4-51
Transfer Case. Manual Shift
................. 2-20, 6-22
Transmission Fluid Automatic
................................... 6-16
Manual
..................................... 6-19
Transportation. Courtesy
.......................... 8-7
Trip Odometer ................................. 2-61
TTYUsers
..................................... 8-4
Turn Signal and Lane Change Signals
............... 2-30
Turn SignaVMultifunction Lever
................... 2-29
Turn Signals When Towing a Trailer
................ 4-55
9-10
ProCarManuals.com