1997 CHEVROLET TRACKER steering

GeGS Section 7 Maintenance Schedule
This section covers the maintenance required for your Geo. Your vehicle needs these services to retain its safety,
dependability and emission control performance.
7-2
7-2
7-3
7-4 7-4
7-4
7-49 7-49
7-49
7-50
7-50
7-53
Introduction Your Vehicle and the Environment
How This Section is Organized
Part A: Scheduled Maintenance Services
Using Your Maintenance Schedule
Selecting the Right Schedule
Part B: Owner Checks and Services
At Each Fuel Fill
At Least Once a Month
At Least Twice
a Year
At Least Once a Year
Part C: Periodic Maintenance Inspections
7-53
7-53
7-53
7-54
7-54
7-54
7-54
7-55
7-57
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
Exhaust System Inspection
Radiator and Heater Hose Inspection
Throttle Linkage Inspection Rear Axle (All) and Front Axle (Four-wheel
Drive) Service
Brake System Inspection
Clutch System Service
Part D: Recommended Fluids and Lubricants
Part E: Maintenance Record
7-1
ProCarManuals.com

I
Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each spring and fall). You should let your
GM dealer’s
service department or other qualified service center do
these
jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a
GM service manual. See “Service and Owner
Publications” in the Index.
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose
or missing parts, signs of
wear
or lack of lubrication. Inspect the power steering
lines and hoses
for proper hook-up, binding, leaks,
cracks, chafing,
etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look
for broken, damaged,
missing or out-of-position parts as well
as open seams,
holes, loose connections or other conditions which could
cause a heat build-up in the floor pan or could let
exhaust fumes into the vehicle. See “Engine Exhaust” in
the Index.
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen
or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed.
7-53
ProCarManuals.com

Part D: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from your
GM dealer.
USAGE
Engine Oil
Engine Coolant
FLUIDLUBRICANT
Engine oil with the American
Petroleum Institute Certified For
Gasoline Engines “Starburst”
symbol of the proper viscosity. To
determine the preferred viscosity for your vehicle’s engine, see
“Engine Oil” in the Index.
50150 mixture of clean water
(preferably distilled) and good
quality ethylene
glycol base
coolant (GM Part
No. 1052753 or
equivalent) conforming to GM
Specification 1825M or approved
recycled coolant conforming to
GM Specification 1825M. See
“Engine Coolant” in
the Index.
USAGE
Hydraulic Brake
System
Parking Brake Cable Guides
Power Steering System
Manual
Transmission (All) and
Transfer Case
(Four- Wheel
Drive)
Automatic
Transmission
Key Lock
Cylinders
FLUIDLUBRICANT
Delco Supreme 11 @ Brake Fluid
(GM Part No. 12377967 or
equivalent DOT-3 brake fluid).
Chassis lubricant (GM
Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of
NLGI # 2, Category LB or
DEXRON@-111 Automatic.
Transmission Fluid.
GM Goodwrench Synthetic
Manual Transmission Gear Oil
(GM Part No. 12346190
- 1 quart)
or equivalent
SAE 75W-90 GL-4
gear oil.
DEXRON@-I11 Automatic
Transmission Fluid.
Multi-Pur ose lubricant, Superlube
& (GM Part
No. 12346241 or equivalent).
GC-LB.
ProCarManuals.com

1997 CHEVROLET/GEO SERVICE PUBLICATIONS ORDERING INFORMATION
The following publications covering the operation and servicing of your vehicle can be purchased by filling out
the Service Publication
Order Form in this book and mailing it in with your check, money o\
rder,
or credit card information to Helm, Incorporated (address below.)
~~ ~~
CURRENT PUBLICATIONS FOR 1997 CHEVROLETIGEO
SERVICE MANUALS
Service Manuals have the diagnosis and repair information
on engines, transmission, axle, suspension, brakes,
electrical, steering, body, etc.
RETAIL SELL PRICE:
$90.00
TRANSMISSION, TRANSAXLE, TRANSFER CASE UNIT REPAIR MANUAL
This manual provides information on unit repair service
procedures, adjustments and specifications for the
1997
GM transmissions, transaxles and transfer cases.
RETAIL SELL PRICE: $40.00
SERVICE BULLETINS
Service Bulletins give technical service information needed
to knowledgeably service General Motors cars and trucks.
Each bulletin contains instructions to assist in the
diagnosis and service of your vehicle.
PLEASE COMPLETE THE ORDER FORM SHOWN ON
THE FOLLOWING PAGE AND MAIL TO:
Helm, Incorporated P.O. Box 07130 Detroit, MI 48207
OWNER’S INFORMATION
Owner publications are written directly for Owners and
intended to provide basic operational information about the
vehicle. The owner’s manual will include the Maintenance
Schedule for all models.
In-Portfolio: Includes a Portfolio, Owner’s Manual and
Warranty Booklet. RETAIL SELL PRICE:
$15.00
Without Portfolio: Owner’s Manual only.
RETAIL SELL PRICE:
$1 0.00
CURRENT & PAST MODEL ORDER FORMS
Service Publications are available for current and past
model GM vehicles. To request an order form, please
specify year and model name of the vehicle.
OR ORDER TOLL FREE: 1-800-782-4356
Monday-Friday 8:OO AM - 6:OO PM Eastern Time
For Credit Card Orders Only
(VlSA-MasterCard-Discover)
ProCarManuals.com

Gear Positions. Manual Transmission ............... 2- 14
Glove Box
.................................... 2-41
Gross Axle Weight Rating ........................ 4-47
Gross Vehicle Weight Rating
...................... 4-47
Guide en FranGais
11
GV WR. ....................................... 4-47
.. .................................
Halogen Bulbs .. ............................. 6-33
Hazard Warning Flashers
.......................... 5-2
Head Restraints
................................. 1-4
Headlamps
.................................... 2-3 1
Bulb Replacement ............................ 6-34
HighLow Beam Changer
...................... 2-3 1
Hearing Impaired. Customer Assistance .............. 8-4
Heating
........................................ 3-4
Highway Hypnosis
.............................. 4-38
Hill and Mountain Roads
......................... 4-38
Hitches. Trailer
................................. 4-52
Checking Things Under
......................... 6-7
Hood Latch Operation Check
..................... 7-49
Hubs, Freewheeling ............................. 2- 17
Hydroplaning
.................................. 4-34
Hood
Prop
........................................ 6-8
Release
...................................... 6-7
Horn ......................................... 2-29
Ignition Positions
............................... 2-7
Ignition Transaxle
Lock Check .................... 7-52
Inflation. Tire .................................. 6-41
Inside Daymight Rearview
Mirror ................. 2-39 Inspections
Brakesystem
................................ 7-54
FrontAxle
.................................. 7-54
Exhaust
Systems
............................. 7-53
Front Drive Axle Boot
......................... 7-53
Front Drive Axle Seal
......................... 7-53
Radiator and Heater Hose
...................... 7-53
RearAxle
................................... 7-54
Steering
.................................... 7-53
Suspension
.................................. 7-53
Throttle Linkage
.............................. 7-54
Instrument Panel
............................... 2-58
Brightness Control
............................ 2-38
Cleaning
.................................... 6-51
Cluster ..................................... 2-60
FuseBlock .................................. 6-59
Interior Lamps
................................. 2-38
Jack. Tire
.................................... 5-25
Jump Starting ................................... 5-3
Key Lock Cylinders Service ..................... 7-50
Keys
.......................................... 2-2
Labels Certification
................................. 4-47
Service Parts Identification
..................... 6-58
Tire-Loading Information ...................... 4-47
Vehicle Identification Number
................... 6-58
9-5
ProCarManuals.com

Methanol ...................................... 6-4
Mirrors
....................................... 2-39
Convex Outside
.............................. 2-41
ManualAdjust
............................... 2-40
Power Remote Control
......................... 2-40
MMT
......................................... 6-4
ModelReference
................................. 111
Mountain Roads ................................ 4-38
Multifunction Lever
............................. 2-29
...
Neutral. Automatic Transmission ................. 2- 12
Neutral. Manual Transmission
..................... 2- 15
New Vehicle Break-In
............................ 2-7
Nightvision
................................... 4-31
Odometer
.................................... 2-61
Odometer. Trip
................................. 2-61
Off-Road Driving
.............................. 4- 15
Off-RoadRecovery
............................. 4-12
Oil. Engine
.................................... 6-10
Oil Pressure Light
......................... 2.69. 6. IO
Overdrive. Automatic Transmission ................ 2- 14
Overdrive Off Light ............................. 2-71
Overheating Engine
............................. 5 . 13
Owner Checks and Services
....................... 7-49
Owner Publications. Ordering
..................... 8- 11
Paint Spotting. Chemical
........................ 6-56
Park
Automatic Transmission
....................... 2- 10 Shifting Into
................................. 2-23
Shifting Out of
............................... 2-25
AtNight
..................................... 2-6
Brake
...................................... 2-21
Brake Mechanism Check
....................... 7-52
Over Things That Burn
........................ 2-26
With a Trailer
................................ 4-55
Your Vehicle. Manual Transmission
.............. 2-26
Parking Lamp Bulb Replacement
.................. 6-35
Passenger Position
......................... 1.25. 1-31
Parking
Passing
....................................... 4-12
Periodic Maintenance Inspections
.................. 7-53
DoorLocks
................................... 2-4
Remote Control Mirror
........................ 2-40
Steering
.................................... 4-10
Steering Fluid
................................ 6-26
Windows
................................... 2-28
Power Indicator Light
........................... 2-70
Power Mode Selector Switch
...................... 2-14
Pregnancy. Use of Safety Belts
.................... 1-24
Problems on the Road
............................ 5-1
Publications. Service and Owner ................... 8-11
Radiator. Coolant .............................. 5-20
Radiator Pressure Cap
........................... 6-26
Radio Reception
................................ 3-17
Radios ............................... 3-7.3-8. 3-11
Rain. Driving In
................................ 4-32
Preparing
Your Canvas Top for Storage ............. 2-56
9-7
ProCarManuals.com

Reminder Light ......................... 1 . 13. 2.62
Replacing After a Crash
........................ 1-46
Right Front Passenger Position
.................. 1-25
Smaller Children and Babies
.................... 1-34
Use During Pregnancy
......................... 1-24
WhyTheyWork
.............................. 1-14
Safety Chains
.................................. 4-53
Safety Defects. Reporting
........................ 8-10
Safety Warnings and Symbols
....................... iv
Scheduled Maintenance Services
.................... 7-4
Seatback
Folding Rear
.............................. 1-6. 1-9
Reclining Front
............................... 1-3
EasyEntry
................................... 1-4
ManualFront ................................. 1-2
Rear
.................................... 1-6. 1.9
Restraint Systems
.............................. 1 . 1
Seat Controls ................................. 1-2
Securing a Child Restraint
...................... 1-36
Second Gear. Automatic Transmission
.............. 2- 12
Second Gear. Manual Transmission
................. 2- 15
Service ........................................ 6-2
Bulletins. Ordering ............................ 8- 11
Engine Soon Light
............................ 2-67
Manuals. Ordering ............................ 8- 1 1
Parts Identification Label ....................... 6-58
Publications. Ordering
......................... 8- 11
Work. Doing Your
Own ......................... 6-2
Service and Appearance Care ...................... 6-1
Service and Owner Publications ................... 8- 1 1
Seats Service Publications
.............................. 8-1
1
Sheet Metal Damage
............................ 6-55
Shift Lever
............................... 2- 10. 2- 14
Shiftspeeds ................................... 2-16
Shifting Automatic Transmission
....................... 2-10
IntoPARK(P)
............................... 2-23
Manual Transmission
.......................... 2-14
Out of PARK (P)
............................. 2-25
Signaling Turns
................................ 2-30
Skidding
...................................... 4-14
Sound Equipment. Adding
........................ 3-18
Specifications and Capacities
...................... 6-62
Specifications. Engine
........................... 6-62
Speedometer
................................... 2-61
Stains. Cleaning
................................ 6-50
Starter Switch Check
............................ 7-51
Steam ........................................ 5-13
Steering
...................................... 4-10
In Emergencies
............................... 4-11
Power
...................................... 4-10
Tips
........................................ 4-10
StorageAreas
.................................. 2-41
Storage. Vehicle ................................ 6-33
Stuck: In Sand. Mud.
Ice or Snow .................. 5-34
Sunvisors
.................................... 2-44
Sunroof ....................................... 2-45
Symbols. Vehicle
................................. vi
Servicing
Your Air Bag-Equipped Geo
.............. 1-30
Side Window. Removing and Installing the
........... 2-48
Speech Impaired. Customer Assistance
............... 8-4
9-9
ProCarManuals.com