1997 CHEVROLET TRACKER brake

Ignition Transaxle Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to
LOCK in each shift lever position.
With an automatic transmission, the key should turn
to LOCK only when the shift lever
is in PARK (P).
With a manual transmission, the key should turn to
LOCK only if you push the key in farther, while
turning it towards
LOCK.
On vehicles with a key release lever, try to turn the key
to LOCK without pressing the lever. The key should
turn to LOCK only when you press the key lever.
On all vehicles,
the key should come out only in LOCK.
Parking Brake and Automatic Transmission
PARK (P) Mechanism Check
A CA "TION:
-
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front
of your vehicle in case
it begins to roll. Be ready to apply the regular
brake at once should the vehicle begin to move.
Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot
on the regular brake, set the
parking brake.
To check the parking brake's holding ability:
With the engine running and transmission in
NEUTRAL
(N), slowly remove foot pressure from
the regular brake pedal.
Do this until the vehicle is
held by the parking brake only.
To check the PARK (P) mechanism's holding ability:
With the engine running, shift to PARK
(P).
Then release all brakes. If your vehicle is four-wheel
drive, be sure the transfer case is not in
NEUTRAL
(N).
Underbody Flushing Service
At least every spring, use plain water to flush any
corrosive materials from the underbody. Take care
to
clean thoroughly any areas where mud and other debris
can collect.
7-52
ProCarManuals.com

Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding,
and for damage or missing parts. Replace parts as
needed. Replace any cables that have high effort or
excessive wear.
Do not lubricate accelerator and cruise
control cables.
Rear Axle (All) and Front Axle
(Four-wheel Drive) Service
Check the gear lubricant level and add if needed. See
“Rear Axle” and “Four-wheel Drive” in
the Index. A
fluid loss may indicate a problem. Check the system(s),
and repair the system(s) if needed. Refer to “Scheduled
Maintenance Services,” earlier
in this section, to
determine when to change the lubricant.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition. Also inspect drum brake linings
for wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc.
Check parking brake adjustment. You may need to have
your brakes inspected more often if your driving habits
or conditions result in frequent braking.
Clutch System Service
Check clutch pedal free travel and adjust as necessary.
See “Clutch Adjustment’’ in the Index.
7-54
ProCarManuals.com

Part D: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from your
GM dealer.
USAGE
Engine Oil
Engine Coolant
FLUIDLUBRICANT
Engine oil with the American
Petroleum Institute Certified For
Gasoline Engines “Starburst”
symbol of the proper viscosity. To
determine the preferred viscosity for your vehicle’s engine, see
“Engine Oil” in the Index.
50150 mixture of clean water
(preferably distilled) and good
quality ethylene
glycol base
coolant (GM Part
No. 1052753 or
equivalent) conforming to GM
Specification 1825M or approved
recycled coolant conforming to
GM Specification 1825M. See
“Engine Coolant” in
the Index.
USAGE
Hydraulic Brake
System
Parking Brake Cable Guides
Power Steering System
Manual
Transmission (All) and
Transfer Case
(Four- Wheel
Drive)
Automatic
Transmission
Key Lock
Cylinders
FLUIDLUBRICANT
Delco Supreme 11 @ Brake Fluid
(GM Part No. 12377967 or
equivalent DOT-3 brake fluid).
Chassis lubricant (GM
Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of
NLGI # 2, Category LB or
DEXRON@-111 Automatic.
Transmission Fluid.
GM Goodwrench Synthetic
Manual Transmission Gear Oil
(GM Part No. 12346190
- 1 quart)
or equivalent
SAE 75W-90 GL-4
gear oil.
DEXRON@-I11 Automatic
Transmission Fluid.
Multi-Pur ose lubricant, Superlube
& (GM Part
No. 12346241 or equivalent).
GC-LB.
ProCarManuals.com

1997 CHEVROLET/GEO SERVICE PUBLICATIONS ORDERING INFORMATION
The following publications covering the operation and servicing of your vehicle can be purchased by filling out
the Service Publication
Order Form in this book and mailing it in with your check, money o\
rder,
or credit card information to Helm, Incorporated (address below.)
~~ ~~
CURRENT PUBLICATIONS FOR 1997 CHEVROLETIGEO
SERVICE MANUALS
Service Manuals have the diagnosis and repair information
on engines, transmission, axle, suspension, brakes,
electrical, steering, body, etc.
RETAIL SELL PRICE:
$90.00
TRANSMISSION, TRANSAXLE, TRANSFER CASE UNIT REPAIR MANUAL
This manual provides information on unit repair service
procedures, adjustments and specifications for the
1997
GM transmissions, transaxles and transfer cases.
RETAIL SELL PRICE: $40.00
SERVICE BULLETINS
Service Bulletins give technical service information needed
to knowledgeably service General Motors cars and trucks.
Each bulletin contains instructions to assist in the
diagnosis and service of your vehicle.
PLEASE COMPLETE THE ORDER FORM SHOWN ON
THE FOLLOWING PAGE AND MAIL TO:
Helm, Incorporated P.O. Box 07130 Detroit, MI 48207
OWNER’S INFORMATION
Owner publications are written directly for Owners and
intended to provide basic operational information about the
vehicle. The owner’s manual will include the Maintenance
Schedule for all models.
In-Portfolio: Includes a Portfolio, Owner’s Manual and
Warranty Booklet. RETAIL SELL PRICE:
$15.00
Without Portfolio: Owner’s Manual only.
RETAIL SELL PRICE:
$1 0.00
CURRENT & PAST MODEL ORDER FORMS
Service Publications are available for current and past
model GM vehicles. To request an order form, please
specify year and model name of the vehicle.
OR ORDER TOLL FREE: 1-800-782-4356
Monday-Friday 8:OO AM - 6:OO PM Eastern Time
For Credit Card Orders Only
(VlSA-MasterCard-Discover)
ProCarManuals.com

Gem Section 9 Index
Adding Equipment to the Outside of Your Vehicle ..... 6-3
AirBag
....................................... 1-25
Adding Equipment
............................ 1-3 1
How Does it Restrain
.......................... 1-29
How it Works
................................ 1-27
Location
.................................... 1-27
Readiness Light
......................... 1-26. 2-63
Servicing ................................... 1-30
What Makes it Inflate
.......................... 1-28
What Will
You See After it Inflates ............... 1-29
When Should it Inflate
......................... 1-28
Aircleaner
.................................... 6-14
Air Conditioning
................................ 3-3
Air Conditioning Refrigerants
..................... 6-64
Alignment and Balance. Tire
...................... 6-46
Aluminum Wheels. Cleaning
...................... 6-55
Antenna
...................................... 3-19
Antifreeze
..................................... 6-23
Anti-Lock Brake System Active Light
................. 2-66. 4-9
Brake System Warning Light
................ 2-65. 4-7
Brakes
...................................... 4-7
Appearance Care
............................... 6-48
Appearance Care Materials
....................... 6-57 Arbitration
Program
.............................. 8-9
Ashtrays ...................................... 2-43
Audio Systems
.................................. 3-6
Automatic
Overdrive
................................... 2-14
Overdrive Off Switch
.......................... 2-14
Automatic Transmission
.......................... 2-9
Check
...................................... 7-50
Fluid
....................................... 6-16
Operation
................................... 2-10
Park Mechanism Check ........................ 7-52
Shifting
..................................... 2-10
Starting Your Engine
........................... 2-9
Axle. Front .................................... 6-23
Axle. Rear
.................................... 6-21
Battery
...................................... 6-33
Jump Starting
................................. 5-3
Warnings
................................ 5-3, 5-5
BBB Auto Line
................................. 8-9
Better Business Bureau Mediation ................... 8-9
Blizzard ...................................... 4-42
9-1
ProCarManuals.com

Brake Adjustment
.................................. 6-32
Fluid
....................................... 6-29
Master Cylinder
.............................. 6-29
Parking
..................................... 2-21
PedalTravel
................................. 6-32
Replacing System
Parts ........................ 6-32
System Warning Light
......................... 2-64
Trailer
...................................... 4-53
Transmission Shift Interlock
.................... 2-25
Transmission Shift Interlock Check
............... 7-5 1
Wear
....................................... 6-31
Brakes, Anti-Lock
............................... 4-7
Braking
........................................ 4-6
Braking
in Emergencies ........................... 4-9
Break-In, New Vehicle
........................... 2-7
Brightness Control
.............................. 2-38
BTSI
......................................... 2-25
BTSICheck
................................... 7-51
Bulb Replacement
.............................. 6-33
Canadian Roadside Assistance
.................... 8-7
Canvas Top Lowering and Raising
......................... 2-50
Preparing for Storage
.......................... 2-56
Removing and Installing
....................... 2-55
Capacities and Specifications
...................... 6-62
Carbon Monoxide
..................... 2-5,2-27, 4-43
Cassette Deck Service
........................... 7-49
Cassette Tape Player
........................ 3-8, 3-11
Cassette Tape Player Care
........................ 3- 1 8
CD Player Theft-Deterrent Feature ................. 3 - 15 Center
High-Mounted Stoplamp Bulb Replacement
.... 6-39
Certification Label
.............................. 4-47
Chains. Safety
................................. 4-53
Chains. Tire
................................... 6-48
Changing a Flat Tire
............................. 5-23
Charging System Light
.......................... 2-63
Checking Your Restraint Systems
.................. 1-45
Chemical Paint Spotting
.......................... 6-56
Child Restraints
........................... 1-35. 1-36
Securing in a Rear Seat Position
................. 1-37
Securing in the Right Front Seat Position
.......... 1-39
TopStrap
................................... 1-37
WheretoPut
................................ 1-36
Circuit Breakers and Fuses
....................... 6-59
Cleaner. Air
................................... 6-14
Cleaning Aluminum Wheels
............................ 6-55
Canvas Top and Plastic Window
................. 6-54
Exterior LampsLenses
........................ 6-53
Fabric
...................................... 6-49
Glass Surfaces
............................... 6-52
Inside of Your Ceo
............................ 6-49
Instrument Panel
............................. 6-51
Outside of Your Geo .......................... 6-53
Stains
...................................... 6-50
Tires
....................................... 6-55
Vinyl
....................................... 6-51
Wheels
..................................... 6-55
Cigarette Lighter
............................... 2-43
Special Problems
............................. 6-50
Windshield and Wiper Blades
................... 6-52
Climate Control System
........................... 3-2
9-2
ProCarManuals.com

Gear Positions. Manual Transmission ............... 2- 14
Glove Box
.................................... 2-41
Gross Axle Weight Rating ........................ 4-47
Gross Vehicle Weight Rating
...................... 4-47
Guide en FranGais
11
GV WR. ....................................... 4-47
.. .................................
Halogen Bulbs .. ............................. 6-33
Hazard Warning Flashers
.......................... 5-2
Head Restraints
................................. 1-4
Headlamps
.................................... 2-3 1
Bulb Replacement ............................ 6-34
HighLow Beam Changer
...................... 2-3 1
Hearing Impaired. Customer Assistance .............. 8-4
Heating
........................................ 3-4
Highway Hypnosis
.............................. 4-38
Hill and Mountain Roads
......................... 4-38
Hitches. Trailer
................................. 4-52
Checking Things Under
......................... 6-7
Hood Latch Operation Check
..................... 7-49
Hubs, Freewheeling ............................. 2- 17
Hydroplaning
.................................. 4-34
Hood
Prop
........................................ 6-8
Release
...................................... 6-7
Horn ......................................... 2-29
Ignition Positions
............................... 2-7
Ignition Transaxle
Lock Check .................... 7-52
Inflation. Tire .................................. 6-41
Inside Daymight Rearview
Mirror ................. 2-39 Inspections
Brakesystem
................................ 7-54
FrontAxle
.................................. 7-54
Exhaust
Systems
............................. 7-53
Front Drive Axle Boot
......................... 7-53
Front Drive Axle Seal
......................... 7-53
Radiator and Heater Hose
...................... 7-53
RearAxle
................................... 7-54
Steering
.................................... 7-53
Suspension
.................................. 7-53
Throttle Linkage
.............................. 7-54
Instrument Panel
............................... 2-58
Brightness Control
............................ 2-38
Cleaning
.................................... 6-51
Cluster ..................................... 2-60
FuseBlock .................................. 6-59
Interior Lamps
................................. 2-38
Jack. Tire
.................................... 5-25
Jump Starting ................................... 5-3
Key Lock Cylinders Service ..................... 7-50
Keys
.......................................... 2-2
Labels Certification
................................. 4-47
Service Parts Identification
..................... 6-58
Tire-Loading Information ...................... 4-47
Vehicle Identification Number
................... 6-58
9-5
ProCarManuals.com

Methanol ...................................... 6-4
Mirrors
....................................... 2-39
Convex Outside
.............................. 2-41
ManualAdjust
............................... 2-40
Power Remote Control
......................... 2-40
MMT
......................................... 6-4
ModelReference
................................. 111
Mountain Roads ................................ 4-38
Multifunction Lever
............................. 2-29
...
Neutral. Automatic Transmission ................. 2- 12
Neutral. Manual Transmission
..................... 2- 15
New Vehicle Break-In
............................ 2-7
Nightvision
................................... 4-31
Odometer
.................................... 2-61
Odometer. Trip
................................. 2-61
Off-Road Driving
.............................. 4- 15
Off-RoadRecovery
............................. 4-12
Oil. Engine
.................................... 6-10
Oil Pressure Light
......................... 2.69. 6. IO
Overdrive. Automatic Transmission ................ 2- 14
Overdrive Off Light ............................. 2-71
Overheating Engine
............................. 5 . 13
Owner Checks and Services
....................... 7-49
Owner Publications. Ordering
..................... 8- 11
Paint Spotting. Chemical
........................ 6-56
Park
Automatic Transmission
....................... 2- 10 Shifting Into
................................. 2-23
Shifting Out of
............................... 2-25
AtNight
..................................... 2-6
Brake
...................................... 2-21
Brake Mechanism Check
....................... 7-52
Over Things That Burn
........................ 2-26
With a Trailer
................................ 4-55
Your Vehicle. Manual Transmission
.............. 2-26
Parking Lamp Bulb Replacement
.................. 6-35
Passenger Position
......................... 1.25. 1-31
Parking
Passing
....................................... 4-12
Periodic Maintenance Inspections
.................. 7-53
DoorLocks
................................... 2-4
Remote Control Mirror
........................ 2-40
Steering
.................................... 4-10
Steering Fluid
................................ 6-26
Windows
................................... 2-28
Power Indicator Light
........................... 2-70
Power Mode Selector Switch
...................... 2-14
Pregnancy. Use of Safety Belts
.................... 1-24
Problems on the Road
............................ 5-1
Publications. Service and Owner ................... 8-11
Radiator. Coolant .............................. 5-20
Radiator Pressure Cap
........................... 6-26
Radio Reception
................................ 3-17
Radios ............................... 3-7.3-8. 3-11
Rain. Driving In
................................ 4-32
Preparing
Your Canvas Top for Storage ............. 2-56
9-7
ProCarManuals.com